Download: FOREWORD This wiring diagram manual has been prepared to provide information on the electrical system of the 2007 YARIS. Applicable models: NCP91, 93 Series

FOREWORD This wiring diagram manual has been prepared to provide information on the electrical system of the 2007 YARIS. Applicable models: NCP91, 93 Series Refer to the following manuals for additional service specifications and repair procedures for these models: Manual Name Pub. No. 2007 YARIS Repair Manual RM01V0U 2007 YARIS New Car Features NM01V0U All information in this manual is based on the latest product information at the time of publication. However, specifications and procedures are subject to change without notice. NOTICE Always follow the directions given in the above repair man...
Author: Zoble1980 Shared: 8/19/19
Downloads: 80 Views: 1828

Content

FOREWORD

This wiring diagram manual has been prepared to provide information on the electrical system of the 2007 YARIS. Applicable models: NCP91, 93 Series Refer to the following manuals for additional service specifications and repair procedures for these models: Manual Name Pub. No. 2007 YARIS Repair Manual RM01V0U 2007 YARIS New Car Features NM01V0U All information in this manual is based on the latest product information at the time of publication. However, specifications and procedures are subject to change without notice.

NOTICE

Always follow the directions given in the above repair manuals when handling supplemental restraint system components (such as removal, installation, inspection, etc.) in order to prevent accidents and supplemental restraint system malfunction. All rights reserved. This book may not be reproduced or copied, in whole or in part, without the written permission of Toyota Motor Corporation. First Printing : Feb. 03, 2006 01–060203–00, 2007 YARIS

ELECTRICAL WIRING DIAGRAM

Section Code Page INTRODUCTION .A .2 HOW TO USE THIS MANUAL .B .3 TROUBLESHOOTING .C .12 ABBREVIATIONS .D .17 GLOSSARY OF TERMS AND SYMBOLS .E .18 RELAY LOCATIONS .F .20 ELECTRICAL WIRING ROUTING .G .46 SYSTEM CIRCUITS .H .67 GROUND POINT .I .244 POWER SOURCE (Current Flow Chart) .J .252 CONNECTOR LIST .K .258 PART NUMBER OF CONNECTORS .L .276 OVERALL ELECTRICAL WIRING DIAGRAM . M .280,

A INTRODUCTION

This manual consists of the following 13 sections: No. Section Description INDEX Index of the contents of this manual.

A

INTRODUCTION Brief explanation of each section. B HOW TO USE THISMANUAL Instructions on how to use this manual. C TROUBLE–SHOOTING Describes the basic inspection procedures for electrical circuits. D ABBREVIATIONS Defines the abbreviations used in this manual. GLOSSARY OF E TERMS AND Defines the symbols and functions of major parts.

SYMBOLS

F RELAY LOCATIONS Shows position of the Electronic Control Unit, Relays, Relay Block, etc.This section is closely related to the system circuit. G ELECTRICAL Describes position of Parts Connectors, Splice points, Ground points, etc.WIRING ROUTING This section is closely related to the system circuit. INDEX Index of the system circuits. Electrical circuits of each system are shown from the power supply through ground H points. Wiring connections and their positions are shown and classified by code SYSTEM CIRCUITS according to the connection method. (Refer to the section, ”How to use this manual”). The ”System Outline” and ”Service Hints” useful for troubleshooting are also contained in this section. I GROUND POINT Shows ground positions of all parts described in this manual. J POWER SOURCE(Current Flow Chart) Describes power distribution from the power supply to various electrical loads. K CONNECTOR LIST Describes the form of the connectors for the parts appeared in this book.This section is closely related to the system circuit. L PART NUMBER OFCONNECTORS Indicates the part number of the connectors used in this manual.

OVERALL

M ELECTRICAL Provides circuit diagrams showing the circuit connections. WIRING DIAGRAM, HOW TO USE THIS MANUAL B This manual provides information on the electrical circuits installed on vehicles by dividing them into a circuit for each system. The actual wiring of each system circuit is shown from the point where the power source is received from the battery as far as each ground point. (All circuit diagrams are shown with the switches in the OFF position.) When troubleshooting any problem, first understand the operation of the circuit where the problem was detected (see System Circuit section), the power source supplying power to that circuit (see Power Source section), and the ground points (see Ground Point section). See the System Outline to understand the circuit operation. When the circuit operation is understood, begin troubleshooting of the problem circuit to isolate the cause. Use Relay Location and Electrical Wiring Routing sections to find each part, junction block and wiring harness connectors, wiring harness and wiring harness connectors and ground points of each system circuit. Internal wiring for each junction block is also provided for better understanding of connection within a junction block. Wiring related to each system is indicated in each system circuit by arrows (from_, to_). When overall connections are required, see the Overall Electrical Wiring Diagram at the end of this manual.,

B HOW TO USE THIS MANUAL

* The system shown here is an EXAMPLE ONLY. It is different to the actual circuit shown in the SYSTEM CIRCUITS SECTION. [A]

Stop Light

[M] (BAT) (IG) 15A 7.5A STOP GAUGE [B] 1 3 IB 4 IB 7 3C [C] [G]H6 Stop Lamp SW 14 CH1 15 3C 15 CH1 [E] [D] G – W [F] H478Light Failure Sensor42111 [H] 1 G – R HJ1 [N] [I] (Shielded) 4 3 [J] H17Center Stop Lamp361W– B HJ1 H1 [K] H2 50 [L] W – B G – R Stop Skid Control ECU with Actuator J7 Rear Combination Lamp (RH) W – B W – B G – R G – R G – W G – W W – R Stop H9 Rear Combination Lamp (LH)

R

(W/G) LLLW– B G – B (S/D) (S/D) (S/D) W – B Y – G R – L R – L Rear Lights H7 Combination Meter,

B

[A] : System Title [H] : Indicates the wiring color. [B] : Indicates a Relay Block. No shading is used and Wire colors are indicated by an alphabetical code. only the Relay Block No. is shown to distinguish it B = Black W = White BR = Brown from the J/B L = Blue V = Violet SB = Sky Blue Example: Indicates Relay Block No.1 R = Red G = Green LG = Light Green [C] : ( ) is used to indicate different wiring and P = Pink Y = Yellow GR = Gray connector, etc. when the vehicle model, engine type, or specification is different. O = Orange The first letter indicates the basic wire color and the [D] : Indicates related system. second letter indicates the color of the stripe. [E] : Indicates the code for the (male and female) connectors which are used to join two wire Example: L – Y harnesses. The connector code consists of two alphabetical and one numerical characters. L Y (Blue) (Yellow) [I] : Indicates a shielded cable. Female Male ( ) The first character of the connector code indicates the alphabetical code allocated to the wire harness which has the female connector, and the second [J] : Indicates the pin number of the connector. shows that of the wire harness which has the male The numbering system is different for female and connector. male connectors. The third character indicates a serial number used to distinguish between the wire harness Example: Numbered in other Numbered in other combinations in cases when more than one of the from upper left to from upper right to same combination of wire harnesses exist lower right lower left (e.g. CH1 and CH2). Symbol ( ) indicates the male terminal connector. Numbers outside connector codes indicate the pin Female Male numbers of both male and female connectors. [F] : Represents a part (all parts are shown in sky blue). [K] : Indicates the ground point. The code consists of the The code is the same as the code used in parts two characters: A letter and number. position. The first character of the code indicates the alphabetical code allocated to the wire harness. [G] : Junction Block (The number in the circle is the J/B The second character indicates a serial number No. and the connector code is shown beside it). used to distinguish between the ground points in Junction Blocks are shaded to clearly separate cases when more than one ground point exist on the them from other parts. same wire harness. [L] : Page No. Example: [M] : Indicates the ignition key position(s) when the power is supplied to the fuse(s). 3C indicates that [N] : Indicates a wiring Splice Point. it is inside Junction Block No.3 Example:,

B HOW TO USE THIS MANUAL

[O] System Outline Current is applied at all times through the STOP fuse to TERMINAL 2 of the stop lamp SW. When the ignition SW is turned on, current flows from the GAUGE fuse to TERMINAL 8 of the light failure sensor, and also flows through the rear lights warning light to TERMINAL 4 of the light failure sensor. Stop Light Disconnection Warning When the ignition SW is turned on and the brake pedal is pressed (Stop lamp SW on), if the stop light circuit is open, the current flowing from TERMINAL 7 of the light failure sensor to TERMINALS 1, 2 changes, so the light failure sensor detects the disconnection and the warning circuit of the light failure sensor is activated. As a result, the current flows from TERMINAL 4 of the light failure sensor to TERMINAL 11 to GROUND and turns the rear lights warning light on. By pressing the brake pedal, the current flowing to TERMINAL 8 of the light failure sensor keeps the warning circuit on and holds the warning light on until the ignition SW is turned off. [P] : Parts Location Code See Page Code See Page Code See Page H4 36 H7 36 H17 38 H6 36 H9 38 J7 38 [Q] : Relay Blocks Code See Page Relay Blocks (Relay Block Location) 1 18 R/B No.1 (Instrument Panel Brace LH) [R] : Junction Block and Wire Harness Connector Code See Page Junction Block and Wire Harness (Connector Location) 3C 22 Instrument Panel Wire and J/B No.3 (Instrument Panel Brace LH) IB 20 Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel) [S] : Connector Joining Wire Harness and Wire Harness Code See Page Joining Wire Harness and Wire Harness (Connector Location) CH1 42 Engine Room Main Wire and Instrument Panel Wire (Left Kick Panel) HJ1 50 Instrument Panel Wire and Floor Wire (Right Kick Panel) [T] : Ground Points Code See Page Ground Points Location H1 50 Under the Left Center Pillar H2 50 Back Panel Center,

B

[O] : Explains the system outline. [P] : Indicates reference pages showing the parts locations in the system circuit on the vehicle. Example : Code ”H4” (Light Failure Sensor) is on page 36 of the manual. * The first character of the code indicates the alphabetical code allocated to the wire harness, and the second character indicates the serial number of the parts connected to the wire harness. Example : H 4 ÁSerial number for the connected parts ÁCode for the wire harness [Q] : Indicates the reference page showing the position on the vehicle of Relay Block Connectors in the system circuit. Example : Connector ”1” is described on page 18 of this manual and is installed on the left side of the instrument panel. [R] : Indicates the reference page showing the position on the vehicle of J/B and Wire Harness in the system circuit. Example : Connector ”3C” connects the Instrument Panel Wire and J/B No.3. It is described on page 22 of this manual, and is installed on the instrument panel left side. [S] : Indicates the reference page describing the wiring harness and wiring harness connector (the female wiring harness is shown first, followed by the male wiring harness). Example : Connector ”CH1” connects the Engine Room Main Wire (female) and Instrument Panel Wire (male). It is described on page 42 of this manual, and is installed on the left side kick panel. [T] : Indicates the reference page showing the position of the ground points on the vehicle. Example : Ground point ”H2” is described on page 50 of this manual and is installed on the back panel center.,

B HOW TO USE THIS MANUAL The ground points circuit diagram shows the connections from all major parts to the respective ground points. When

troubleshooting a faulty ground point, checking the system circuits which use a common ground may help you identify the problem ground quickly. The relationship between ground points ( A1 , A2 and D4 shown below) can also be checked this way.

I GROUND POINT

D43 Junction H23 Connector12 DLC3 BR BR 9 BR 10 6 (Shielded) (SG) HB4 DB1 D63 5 BR Throttle (L) Position SW D60 A2043BR Injection(E1) Headlamp Leveling W – B 8 Pump Assembly Motor (LH) (LH E) L5 2 11 BR3 (E1) Power Window W – B W – B 7 Master SW (E) LA1 1 D2 BR Engine ECU (E01) A22 Cooling Fan W – B 4 Motor No.3 (E) BR (E02) D4 (5L–E) A8 Headlamp Leveling W – B Motor (RH) (RH E) A5 C2 Pressure SW W – B W – B Fog Lamp (–S) (E) (Front LH) A23 5 C4 Turn Signal Lamp W – B W – B W – B W – B Fog Lamp (Front LH) (E) CA1 (E) (Front RH) A11 A10 Windshield W – B W – B Brake Fluid Level Wiper Motor (E) (E) Warning SW I9 12 A1 Headlamp W – B W – B7W– B W – B Turn Signal Lamp Leveling SW (E) IH2 HA1 (E) (Front RH) A6 Clearance Lamp W – B (E) 3 K5(Front RH) W – B W – B Power Window KA1 (E) Master SW A21 Clearance Lamp W – B W – B (Front LH) (E) 20 W – B (Shielded) A1 19 W – B (Shielded) W – B (GND2) A24 18 W – B (Shielded) Option Connector (Vacuum) W – B (GND1) 17 W – B (Shielded) W – B 21 W – B (GND) AB1 B19 Skid Control ECU with Actuator W – B 12 W – B W – B 6 (GND) AB1 AB1 W – B A2 * The system shown here is an EXAMPLE ONLY. It is different to the actual circuit shown in the SYSTEM CIRCUITS SECTION. W – B W – B W – B W – B W – B W – B W – B W – B A25 Junction (Shielded) Connector (Shielded) B36 Junction BR Connector W – B,

B The ”Current Flow Chart” section, describes which parts each power source (fuses, fusible links, and circuit breakers)

transmits current to. In the Power Source circuit diagram, the conditions when battery power is supplied to each system are explained. Since all System Circuit diagrams start from the power source, the power source system must be fully understood.

J POWER SOURCE (Current Flow Chart)

The chart below shows the route by which current flows from the battery to each electrical source (Fusible Link, Circuit Breaker, Fues, etc.) and other parts 10A ECU–B Short Pin227.5A DOME 15A EFI Battery 30A AM2 2 Fusible Link Block 6 10A HAZARD 20A RADIO NO.1 StarterS210A HORN 100A ALT 6 60A ABS 5

Engine Room R/B (See Page 20)

Fuse System Page ABS 194 ABS and Traction Control 187 20A STOP Cruise Control 180 Electronically Controlled Transmission 166 Multiplex Communication System 210 Cigarette Lighter 214 Combination Meter 230 Headlight 112 10A DOME Interior Light 122 Key Reminder and Seat Belt Warning Light Auto Turn Off System Theft Deterrent and Door Lock Control

Power Source

1.25BB1WFL MAIN BA1 Battery 50A MAIN 7.5A DOMEB12W7WW12R22AH1117.5A AM1 B 612W– R22AH1 15A HAZ–RADIO12W84H8 Ignition SW 20A DEFOG B – Y12W– R11∗ The system shown here is an EXAMPLE ONLY. It is different to the actual circuit shown in the SYSTEM CIRCUITS SECTION.

ACC

IG1 AM1 W – R ST1 IG2 AM2 W ST2,

B HOW TO USE THIS MANUAL K CONNECTOR LIST

A1 [A] A2 A3 [C] Black Gray1234123456712345678[B] [D] B1 B2 Black Gray12345612345678910111213

K CONNECTOR LIST

BA1 Black [E] BD2 Gray [F] 1234432112345543215678910 11 11 1098765678910 11 12 13 13 12 11 109876[A] : Indicates connector to be connected to a part. (The numeral indicates the pin No.) [B] : Junction Connector Indicates a connector which is connected to a short terminal. Junction Connector Junction connector in this manual include a short terminal which is connected to a number of wire harnesses. Always perform inspection with the short terminal installed. Short Terminal [C] : Parts Code The first letter of the code is taken from the first letter of part, and the numbers indicates its order in parts which start with the same letter. [D] : Connector Color Connectors not indicated are milky white in color. [E] : Indicates the connector shapes which are used to join wire harnesses. On Left : Female connector shapes On Right : Male connector shapes Numbers indicate pin numbers. [F] : Indicates connector colors. (Connectors with not indicated colors are white),

B L PART NUMBER OF CONNECTORS

Code Part Name Part Number Code Part Name Part Number A1 Turn Signal Lamp (Front RH) 90980–11019 B22 Door Courtesy SW (Front LH) 90980–12470 A2 Inlet Air Temp. Sensor 90980–11163 B23 Front Seat Outer Belt (LH) 90980–12253 A3 Air Flow Meter 90980–12292 B24 Blower SW (Rear Heater) 90980–10463 A4 A/C Pressure Sensor 90980–10845 B25 Front Seat Outer Belt (RH) 90980–12253 A5 Pressure SW 90980–10943 B26 Door Courtesy SW (Front RH) 90980–12470 A6 Clearance Lamp (Front RH) 90980–11156 B27 Cooling Fan ECU No.1 90980–10841 [A7] Headlam[Bp (]RH) 9098[0C–1]1314 B28 Cooling Fan ECU No.2 A8 Headlamp Leveling Motor (RH) 90980–11016 B29 Water Temp. Sensor (Radiator) 90980–10735 A9 Brake Vacuum Warning SW 90980–11252 B30 Fuel Filter Warning SW 90980–11003 A10 Brake Fluid Level Warning SW 90980–11207 B32 Door Control Relay (LH) 90980–10789 A11 Windshield Washer Motor 90980–11599 B33 Step Lamp (LH) 90980–10121 A12 Airbag Sensor (Front RH) 90980–11856 B34 Junction Connector A13 Airbag Squib B35 Junction Connector 90980–11398 90980–12490 [A] : Part Code [B] : Part Name [C] : Part Number

Toyota Part Number are indicated. Not all of the above part numbers of the connector are established for the supply.

,

C TROUBLESHOOTING

To Ignition SW VOLTAGE CHECK IG Terminal (a) Establish conditions in which voltage is present at the check point. Example: Fuse [A] – Ignition SW on [B] – Ignition SW and SW 1 on [A] [C] – Ignition SW, SW 1 and Relay on (SW 2 off) (b) Using a voltmeter, connect the negative lead to a good ground SW 1 Voltmeter point or negative battery terminal, and the positive lead to the connector or component terminal. [B] This check can be done with a test light instead of a voltmeter. Relay [C] SW 2 Solenoid

CONTINUITY AND RESISTANCE CHECK

(a) Disconnect the battery terminal or wire so there is no voltage between the check points. Ohmmeter (b) Contact the two leads of an ohmmeter to each of the check points.

SW

If the circuit has diodes, reverse the two leads and check again. When contacting the negative lead to the diode positive side Ohmmeter and the positive lead to the negative side, there should be continuity. When contacting the two leads in reverse, there should be no continuity. Diode Digital Type Analog Type (c) Use a volt/ohmmeter with high impedance (10 kΩ/V minimum) for troubleshooting of the electrical circuit.,

C

To Ignition SW FINDING A SHORT CIRCUIT IG Terminal (a) Remove the blown fuse and disconnect all loads of the fuse. (b) Connect a test light in place of the fuse. (c) Establish conditions in which the test light comes on. Test Light Fuse Case Example: [A] – Ignition SW on Short [A] [B] – Ignition SW and SW 1 on [C] – Ignition SW, SW 1 and Relay on (Connect the Relay) and SW 2 off (or Disconnect SW 2) SW 1 (d) Disconnect and reconnect the connectors while watching the test light. Short [B] The short lies between the connector where the test light stays lit and the connector where the light goes out. Disconnect Disconnect (e) Find the exact location of the short by lightly shaking the problem wire along the body. Light Relay CAUTION: (a) Do not open the cover or the case of the ECU unless Short [C] absolutely necessary. (If the IC terminals are touched, the IC may be destroyed by static electricity.) (b) When replacing the internal mechanism (ECU part) of Disconnect the digital meter, be careful that no part of your body or clothing comes in contact with the terminals of leads SW 2 Solenoid from the IC, etc. of the replacement part (spare part).

DISCONNECTION OF MALE AND FEMALE CONNECTORS

To pull apart the connectors, pull on the connector itself, not the wire harness. HINT : Check to see what kind of connector you are disconnecting before pulling apart. Pull Up Pull Up Press Down Press Down,

C TROUBLESHOOTING

Reference: HOW TO REPLACE TERMINAL (with terminal retainer or secondary locking device) 1. PREPARE THE SPECIAL TOOL HINT : To remove the terminal from the connector, please construct and use the special tool or like object shown on the left. 2. DISCONNECT CONNECTOR (mm) Example: Up Tool 3. DISENGAGE THE SECONDARY LOCKING DEVICE OR(Case 1) TERMINAL RETAINER. (a) Locking device must be disengaged before the terminal locking clip can be released and the terminal removed from the connector. (b) Use a special tool or the terminal pick to unlock the secondary locking device or terminal retainer. NOTICE: Terminal Retainer Do not remove the terminal retainer from connector body. [A] For Non–Waterproof Type Connector Terminal Retainer HINT : The needle insertion position varies according to the connector’s shape (number of terminals etc.), so check the position before inserting it. ”Case 1” [Retainer at Full Lock Position] Raise the terminal retainer up to the temporary lock position. Terminal Stopper Retainer [Retainer at Temporary Lock Position] Example: Secondary ”Case 2” (Case 2) Locking Device Open the secondary locking device.,

C

Tool Tab Tab Example: [B] For Waterproof Type ConnectorTerminal (Case 1) Retainer Tool HINT : Terminal retainer color is different according to connector body. Example: Terminal Retainer : Connector Body Black or White : Gray Black or White : Dark Gray Tool Access Hole Gray or White : Black [Male] ( Mark) [Female] ”Case 1” Type where terminal retainer is pulled up to the temporary lock position (Pull Type). Insert the special tool into the terminal retainer access hole (Mark) and pull the terminal retainer up to the temporary lock position. Retainer at Full Lock Position HINT : The needle insertion position varies according to the connector’s shape (Number of terminals etc.), so check the position before inserting it. Retainer at Temporary Lock Position [Male] [Female] Example: Terminal Retainer ”Case 2” (Case 2) Type which cannot be pulled as far as Power Lock insert the tool straight into the access hole of terminal retainer as shown. Tool Tool Press Down [Male] Press Down [Female],

C TROUBLESHOOTING

Push the terminal retainer down to the temporary lock position. Retainer at Full Lock Position Retainer at Temporary Lock Position [Male] [Female] Locking Lug (c) Release the locking lug from terminal and pull the terminal out from rear. Tool 4. INSTALL TERMINAL TO CONNECTOR (a) Insert the terminal. HINT: 1. Make sure the terminal is positioned correctly. 2. Insert the terminal until the locking lug locks firmly. 3. Insert the terminal with terminal retainer in the temporary lock position. (b) Push the secondary locking device or terminal retainer in to the full lock position. 5. CONNECT CONNECTOR,

ABBREVIATIONS D ABBREVIATIONS

The following abbreviations are used in this manual. A/C = Air Conditioning A/T = Automatic Transaxle ABS = Anti–Lock Brake System CAN = Controller Area Network CPU = Central Processing Unit EBD = Electronic Brake Force Distribution ECU = Electronic Control Unit EPS = Electric Motor Power Steering H/B = Hatchback Type IC = Integrated Circuit J/B = Junction Block LED = Light Emitting Diode LH = Left–Hand M/T = Manual Transaxle PTC = Positive Temperature Coefficient R/B = Relay Block RH = Right–Hand S/D = Sedan Type SRS = Supplemental Restraint System SW = Switch TEMP. = Temperature VSV = Vacuum Switching Valve w/ = With w/o = Without ∗ The titles given inside the components are the names of the terminals (terminal codes) and are not treated as being abbreviations.,

E GLOSSARY OF TERMS AND SYMBOLS

BATTERY GROUND Stores chemical energy and The point at which wiring attaches to converts it into electrical energy. the Body, thereby providing a return Provides DC current for the auto’s path for an electrical circuit; without a various electrical circuits. ground, current cannot flow. CAPACITOR (Condenser) HEADLIGHTS A small holding unit for temporary 1. SINGLE Current flow causes a headlight storage of electrical voltage. FILAMENT filament to heat up and emit light. A headlight may have either a single (1) filament or a double (2) filament CIGARETTE LIGHTER An electric resistance heating 2. DOUBLE FILAMENT element. CIRCUIT BREAKER HORN Basically a reusable fuse, a circuit An electric device which sounds a breaker will heat and open if too loud audible signal. much current flows through it. Some units automatically reset when cool, others must be manually reset. DIODE IGNITION COIL A semiconductor which allows Converts low–voltage DC current current flow in only one direction. into high–voltage ignition current for firing the spark plugs. DIODE, ZENER LIGHT A diode which allows current flow in one Current flow through a filament direction but blocks reverse flow only up causes the filament to heat up and to a specific voltage. Above that potential, emit light. it passes the excess voltage. This acts as a simple voltage regulator. PHOTODIODE LED (LIGHT EMITTING DIODE) The photodiode is a semiconductor Upon current flow, these diodes emit which controls the current flow light without producing the heat of a according to the amount of light. comparable light. DISTRIBUTOR, IIA METER, ANALOG Channels high–voltage current from Current flow activates a magnetic the ignition coil to the individual coil which causes a needle to move, spark plugs. thereby providing a relative display against a background calibration. FUSE METER, DIGITAL A thin metal strip which burns through Current flow activates one or many when too much current flows through it, LED’s, LCD’s, or fluorescentFUEL thereby stopping current flow and displays, which provide a relative or protecting a circuit from damage. digital display. FUSIBLE LINK (for Medium Current Fuse) A heavy–gauge wire placed in high MOTOR amperage circuits which burns through on overloads, thereby protecting the circuit. A power unit which converts The numbers indicate the crosssection M electrical energy into mechanical surface area of the wires. energy, especially rotary motion.(for High Current Fuse or Fusible Link),

E

RELAY SPEAKER Basically, an electrically operated An electromechanical device which 1. NORMALLYswitch which may be normally creates sound waves from current CLOSED closed (1) or open (2). flow. Current flow through a small coil creates a magnetic field which either opens or closes an attached switch. 2. NORMALLY SWITCH, MANUAL OPEN Opens and closes 1. NORMALLY circuits, thereby OPEN stopping (1) or allowing (2) current RELAY, DOUBLE THROW flow. A relay which passes current 2. NORMALLY through one set of contacts or the CLOSED other. RESISTOR SWITCH, DOUBLE THROW An electrical component with a fixed A switch which continuously passes resistance, placed in a circuit to current through one set of contacts reduce voltage to a specific value. or the other. RESISTOR, TAPPED SWITCH, IGNITION A resistor which supplies two or A key operated switch with several more different non adjustable positions which allows various resistance values. circuits, particularly the primary ignition circuit, to become operational. RESISTOR, VARIABLE or RHEOSTAT A controllable resistor with a variable rate of resistance. Also called a potentiometer or rheostat. SENSOR (Thermistor) SWITCH, WIPER PARK A resistor which varies its resistance Automatically returns wipers to the with temperature. stop position when the wiper switch is turned off. SENSOR, SPEED TRANSISTOR Uses magnetic impulses to open A solidstate device typically used as and close a switch to create a signal an electronic relay; stops or passes for activation of other components. current depending on the voltage (Reed Switch Type) applied at ”base”. SHORT PIN WIRES Used to provide an unbroken Wires are always drawn as connection within a junction block. (1) NOT straight lines on wiring CONNECTED diagrams. Crossed wires (1) without a black dot at the junction are SOLENOID not joined; An electromagnetic coil which forms crossed wires (2) withaamagnetic field when current flows, (2) SPLICED black dot or octagonal ( ) to move a plunger, etc. mark at the junction are spliced (joined) connections.,

F RELAY LOCATIONS

[Engine Compartment] (H/B) Engine Control Module Fusible Link Block Skid Control ECU with Actuator Engine Room R/B Engine Room J/B Engine Room R/B No.2 (S/D) Engine Control Module Fusible Link Block Skid Control ECU with Actuator Engine Room R/B Engine Room J/B Engine Room R/B No.2,

F

[Instrument Panel] (H/B) Power Steering ECU Transponder Key ECU Theft Warning ECU Front Fog Light Relay Fuse Block Running Light Relay ACC Cut Relay J/B No.6 Main Body

ECU

Instrument Panel J/B Shift Lock Control ECU Transponder Key Airbag Sensor J/B No.5 Amplifier A/C Amplifier Assembly Center (S/D) Power Steering ECU Transponder Key ECU Theft Warning ECU Fuse Block Running Light Relay ACC Cut Relay J/B No.6 Main Body

ECU

Instrument Panel J/B Shift Lock Control ECU Front Fog Light Relay Transponder Key Airbag Sensor J/B No.5 Amplifier A/C Amplifier Assembly Center,

F RELAY LOCATIONS

[Body] (5–Door) Occupant Classification ECU Door Control Receiver (3–Door) Occupant Classification ECU Door Control Receiver,

F

(4–Door) Occupant Classification ECU Door Control Receiver,

F RELAY LOCATIONS

1 : Engine Room R/B

Engine Compartment Left (See Page 20)

: Engine Room J/B * 1:H-LP LH/H-LP LO LH * 2:H-LP RH/H-LP LO RH * 3:30A HTR SUB1 (for High Current) * 4:30A RDI (for High Current) * 5:40A HTR (for High Current) * 6:50A ABS1/VSC1 (for High Current) * 7:50A EPS (for High Current) * 8:40A HTR SUB2 (for High Current) * 9:FAN NO.2 Relay * 10:ST Relay53HTR SUB1 *10 *9 *3 2 Relay2124112*1 2 10A155*4 *2 EFI 2 10A 1 UnitA120A23312*512HAZ *6 2 10A 1 HORN ECTS 1 10A2210A 11 2 ALT-S *7 2 7.5A 1 ECU-B 2 7.5A112DOME *8 2 15A 1 AM2 1 15A212ST 2 30A 1 1E 1D11(from Engine Room (from Engine Room Main Wire) Main Wire) Wire Color : B Wire Color : W Unit B ABS2/VSC2 2 30A 1 EFI2 2 10A 1,

F

2 1A53647587(from Engine Room 8 Main Wire) 2 1B4557688(from Engine Room Main Wire) 1C (from Engine Room Main Wire) Unit A,

F RELAY LOCATIONS

[Engine Room R/B and Engine Room J/B Inner Circuit]

Unit A

1 1A EFI Relay1241A 20A EFI 3 1A 2 1A 5 1A HORN Relay1281A 10A HORN 7 1A 6 1A 1 1B IG2 Relay1241B 15A AM2 3 1B 2 1B 5 1B FAN NO.1 Relay 8 1B 7 1B 6 1B 1 1C,

F

1 2

Unit B 130A ABS2/VSC2

1 2 30A HTR SUB11230A RDI1240A HTR1250A ABS1/VSC11250A EPS1211E 1 40A HTR SUB21210A H-LP LH/H-LP LO LH1210A H-LP RH/H-LP LO RH1210A HAZ1210A ETCS127.5A ALT-S127.5A ECU-B1215A DOME1211D 1 30A ST,

F RELAY LOCATIONS

2 : Engine Room R/B No.2 Engine Compartment Right (See Page 20) HTR SUB2 Relay H-LP/AMT Relay2133512HTR SUB3 Relay,

Memo

,

F RELAY LOCATIONS

: Instrument Panel J/B Lower Finish Panel (See Page 21) 14131211109816151413121110976543218765432119 1 20 2 21 3 22 4 23 5 4B (from Instrument (from Instrument 24 6 25 7 Panel Wire) Panel Wire) 268918 8 17 27 9 4D 4C 7 166 15 28 10 5 14 29 11 4 13 30 12 3 12 2 11 31 13 1 10 32 14 33 15 (from Instrument 34 16 1 16 1 19 35 17 2 17 2 207654321Panel Wire) 3 18 3 218765432136 18 4 19 4 22 141312111098161514131211109520 5 23 4H 6 21 6 247 25 (from Engine Room 7 22 8 26 Main Wire) 8 23 9 27 189117 9 24 10 28 178218 17 1 10 25 11 29 167319 18 2 15642016 1 11 26 19 34A 12 30 145521 20 4172622 21 5 18 3 134723 22 6 19 4 12 27 13 31 123824 23 7 20 5 13 28 14 32 11 2 24 8 21 6 14 29 15 33 101925 22 7 15 30 16 34 10 26 4E 25 9 17 35 11 27 26 10 23 8 18 36 12 28 27 11 249428 12 25 10 3 26 1113213 294114 30 29 1315 14 27 125131 30 16 32 31 15 28 1326232 16 29 14 30 15 2 (from Instrument3211Panel Wire)(from Floor Wire) 11876544J43144K1125876546253543321(from Instrument (from Roof Wire) 2 2 Panel Wire) 30A POWER (for High Current) 4F12330A DEF45678(for High Current) (from Instrument Panel Wire) 4L 4G IG 1 Relay 1 HTR Relay 1 FLASH Relay (from Engine Room Main Wire) (from Engine Room Main Wire),

F

Main Body ECU 1112 4M789101112 101112131415161718678910 4Q 121110987678910111213 131211109876123456123456789123451234554321654321(from Instrument (from Instrument Panel Wire) Panel Wire) 4S 4P12345678912345678910 (from Instrument (from Instrument Panel Wire) Panel Wire),

F RELAY LOCATIONS

: Instrument Panel J/B Lower Finish Panel (See Page 21) * 1:10A TAIL (H/B, S/D *3) 7.5A PANEL 2 (*4) * 2:10A TAIL (*4) * 3:Cold Area Spec., w/ Engine Immobiliser System, w/ ABS, w/ Rear Window Defogger, w/ Door Lock Control, w/ Daytime Running Light, w/ Remote Control Mirror, w/ Air Conditioning * 4:Except H/B, S/D *3 *1 7.5A PANEL1 7.5A 25A A/C

WIP

15A RR WIP 20A 15A RL DOOR WSH 20A 10A RR DOOR ECU-IG 10A GAUGE 15A 7.5A CIG OBD2 7.5A 10A ACC

STOP

10A 25A ID/UP/MIR HTR D/L 15A FR FOG *2 7.5A 25A IGN AM1 7.5A

MET

,

Memo

,

F RELAY LOCATIONS

[Instrument Panel J/B Inner Circuit] * 1:H/B, S/D *3 * 2:Except *1 * 3:Cold Area Spec., w/ Engine Immobiliser System, w/ ABS, w/ Rear Window Defogger, w/ Door Lock Control, w/ Daytime Running Light, w/ Remote Control Mirror, w/ Air Conditioning 10 4A 29 4A 15 4B T-LP Relay 7.5A PANEL2 (*2) 33 10A TAIL (*1) 4B 1 4G 10 4E (*1) (*1) 15 4E 7.5A PANEL1 6 4P 3 4E (*1) 2 4Q 9 4S (*1) 7 4P 13 4B 8 4Q 8 4S 8 4P 7 4C 9 4P 3 4P 6 4Q 4 4P 10 4P 5 4P 9 4Q 5 4K 7 4Q 12 4B 18 4S 17 4A 24 4E PWR Relay 2 4H1221 4B 11 4H 30A POWER 9 4A 1 4A 12 4A 20A RL DOOR 25 4B 19 4A 20A RR DOOR 4 4E 10 4H 12 4C 6 4K 3 4J 10A ID/UP/MIR HTR DEF Relay 11 4M 17 4B1224F 35 4B 30A DEF 12 4Q 4 4Q 10A TAIL 4 4M (*2) (*2) 13 4Q 23 4B 25A D/L 2 4J 8 4E 13 4E 2 4A 12 4D 25A AM1 1 4F (Cont. Next Page),

F

(Cont'd) 30 4E 10A STOP 14 4E 18 4B 17 4E 7.5A OBD2 5 4S 28 4E 2 4M 12 4E 8 4M 7 4M 6 4M 1 4K 15A FR FOG 15 4A 9 4M 1 4S 5 4M 2 4E3574F 1 4L1254Q 10 4B 31 4B HTR Relay 6 4D 16 4S 15 4S 28 LR IG 4A 19 4B 32 4B +B EL 11 4S 12 4S ER LL 27 4A8717 4S EHW GND 14 4B 5 4D 13 4S FLASH Relay 19 4E 11 4C 7 4S 1 4C Noise Filter 24 4B 9 4C5310A ECU-IG 3 4K 13 4A32122 4B 4F 30 4A IG 1 Relay 36 4B 23 4E 25A WIP 1 4H 20 4E 14 4S 15A WSH 2 4B 32 4E 10 4D 10A GAUGE 2 4P 1 4P (Cont. Next Page),

F RELAY LOCATIONS

[Instrument Panel J/B Inner Circuit] (Cont'd) 15A RR WIP 25 4A 11 4Q 10 4Q 1 4Q 29 4B 10 4S 7.5A A/C 10 4M 8 4F 25 4E 1 4J C/OPN Relay 11 4B 8 4A 1 4D 5 4E 9 4B 15 4C 21 4E 7.5A IGN 27 4B 4 4F 16 4E 7.5A MET 1 4M 12 4M 5 4F 15A CIG 3 4Q 7.5A ACC 4 4S 6 4S 14 4D (Cont. Next Page),

F

(Cont'd) 9 4E 4 4K 16 4C 21 19 13 2514534 4B ACC TRLY PWS HAZ GND1 ALTB IG 16 4B 4 4J 14 4C 10 4C PCTY 24 4A 14 4H 6 4C 10 26 5 4H UL1 DCTY 21 4A 2 4K 26 4E 27 4E ILE 5 4A 11 4E RRCY 20 4A 13 4H 2 4S 4 4H L1 30 4B 3 4A Main Body ECU 12 4H 17 4H BECU 3 4D 8 4H ACT+ 18 4E 8 4C HORN 28 4B 8 4D 7 4D 26 4B 6 4E 4 4D KSW 4 4C 2 4D 15 4H 2 4C 6 4H 24 16 5 4C PKB UL2 22 4A 9 4D 18 4H 7 4A BCTY (H/B) 9 4H LGCY (S/D) 3 1 4E ACT- 4 4A 7 4E 18 4A 3 4S 16 4H 31 4E L2 7 4H,

F RELAY LOCATIONS

: J/B No.5 Left Kick Panel (See Page 21) D1266255B5441331(from Front Door LH Wire) 133145A4552662(from Instrument Panel Wire),

F

[J/B No.5 Inner Circuit] 1 5A 1 5B 2 5A 2 5B 3 5A 3 5B 4 5A 4 5B 5 5A 5 5B 6 5A 6 5B D1,

F RELAY LOCATIONS

: J/B No.6 Right Kick Panel (See Page 21) D2266256B5441331(from Front Door RH Wire) 133146A4552662(from Instrument Panel Wire),

F

[J/B No.6 Inner Circuit] 1 6A 1 6B 2 6A 2 6B 3 6A 3 6B 4 6A 4 6B 5 6A 5 6B 6 6A 6 6B D2,

F RELAY LOCATIONS Fusible Link Block Near the Battery (See Page 20)

Battery 120A ALT 60A MAIN (for High Current) (for High Current) C30 (from Engine Wire) Wire Color : B,

F

Battery A28 A27 Black111221(from Engine Room (from Engine Room Main Wire) Main Wire),

F RELAY LOCATIONS

[Fusible Link Block Inner Circuit] A27(B), A28(A), C30(C) Fusible Link Block

C A

Battery B 120A ALT

B

60A MAIN,

F Fuse Block Near the Instrument Panel J/B (See Page 21)

ACC2 1 7.5A 2,

G ELECTRICAL WIRING ROUTING Position of Parts in Engine Compartment

[H/B] A21 A3 A23 A28 A27 A10 A9 A1 A2 A7 A11 B1 B8 B4 A15 B3 B13 B11 B6 A6 A25 A4 B12 A22 B7 A5 A24 B9 A18 A8 B5 B2 A12 A14 B10A1Turn Signal Lamp (Front Side RH) B 1 Turn Signal Lamp (Front RH) A 2 Turn Signal Lamp (Front Side LH) B 2 HornA3A/C Pressure SensorB3Parking Lamp (RH) A 4 Rear Washer MotorB4Headlamp (RH) A 5 Windshield Washer MotorB5Ambient Temp. SensorA6Airbag Sensor (Front RH) B 6 Headlamp (LH) A 7 Speed Sensor (Front RH) B 7 Parking Lamp (LH) A 8 Cooling Fan MotorB8Turn Signal Lamp (Front LH) A 9 Windshield Wiper MotorB9Fog Lamp (Front RH) A10 Brake Fluid Level Warning SW B10 Fog Lamp (Front LH) A 11 Speed Sensor (Front LH) B 11 Side Marker Lamp (Front RH) A12 Airbag Sensor (Front LH) B12 Side Marker Lamp (Front LH) A14 Radiator Fan Resistor B13 Junction Connector A15 Skid Control ECU with Actuator A18 Engine Hood Courtesy SW A21 Engine Control Module A22 Water Level Warning SW A23 Security Horn A24 Junction Connector A25 Junction Connector A27 Fusible Link Block A28 Fusible Link Block,

G Position of Parts in Engine Compartment

[H/B] C25 C4 C20 C11 C5 C12 C13 C6 C14 C7 C30 C23 C3 C26 C19 C22 C24 C21 P1 C29 C10 C28 C9 C27 C16 C2 C8 C1 C15 C18 C17C1Starter C17 Throttle Body AssemblyC2Crankshaft Position Sensor C18 Camshaft Position SensorC3VSV (Purge) C19 Engine Coolant Temp. SensorC4Fuel Injector (No.1) C20 Engine Control ModuleC5Fuel Injector (No.2) C21 Speed SensorC6Fuel Injector (No.3) C22 Back–Up Lamp SWC7Fuel Injector (No.4) C23 Air Fuel Ratio Sensor (Bank 1 Sensor 1) C 8 A/C Compressor C24 Camshaft Timing Oil Control ValveC9Generator C25 Noise Filter C10 Generator C26 Mass Air Flow Meter C11 Ignition Coil (No.1) C27 Park/Neutral Position SW C12 Ignition Coil (No.2) C28 Electronically Controlled Transmission Solenoid C13 Ignition Coil (No.3) C29 Speed Sensor (Turbine) C14 Ignition Coil (No.4) C30 Fusible Link Block C15 Starter C16 Engine Oil Pressure SWP1Knock Control Sensor (Bank 1),

G ELECTRICAL WIRING ROUTING Position of Parts in Engine Compartment

[S/D] A21 A23 A28 A27 A10 A15 A9 A7 A11 B14 B15 B4 B13 A22 B6 A5 A25 B9 A24 A6 A3 A18 A8 B2 A12 B5 A14 B10A3A/C Pressure SensorB2HornA5Windshield Washer MotorB4Headlamp (RH) A 6 Airbag Sensor (Front RH) B 5 Ambient Temp. SensorA7Speed Sensor (Front RH) B 6 Headlamp (LH) A 8 Cooling Fan MotorB9Fog Lamp (Front RH) A 9 Windshield Wiper Motor B10 Fog Lamp (Front LH) A10 Brake Fluid Level Warning SW B13 Junction Connector A 11 Speed Sensor (Front LH) B14 Turn Signal, Side Marker and Parking Lamp (RH) A12 Airbag Sensor (Front LH) B15 Turn Signal, Side Marker and Parking Lamp (LH) A14 Radiator Fan Resistor A15 Skid Control ECU with Actuator A18 Engine Hood Courtesy SW A21 Engine Control Module A22 Water Level Warning SW A23 Security Horn A24 Junction Connector A25 Junction Connector A27 Fusible Link Block A28 Fusible Link Block,

G Position of Parts in Engine Compartment

[S/D] C4 C11 C20 C5 C12 C13 C6 C14 C7 C30 C25 C24 C23 C9 C26 C10 C3 C8 C18 C2 C22 C21 C16 C1 C15 C17 C19 C29 C27 C28C1Starter C17 Throttle Body AssemblyC2Crankshaft Position Sensor C18 Camshaft Position SensorC3VSV (Purge) C19 Engine Coolant Temp. SensorC4Fuel Injector (No.1) C20 Engine Control ModuleC5Fuel Injector (No.2) C21 Speed SensorC6Fuel Injector (No.3) C22 Back–Up Lamp SWC7Fuel Injector (No.4) C23 Air Fuel Ratio Sensor (Bank 1 Sensor 1) C 8 A/C Compressor C24 Camshaft Timing Oil Control ValveC9Generator C25 Noise Filter C10 Generator C26 Mass Air Flow Meter C11 Ignition Coil (No.1) C27 Park/Neutral Position SW C12 Ignition Coil (No.2) C28 Electronically Controlled Transmission Solenoid C13 Ignition Coil (No.3) C29 Speed Sensor (Turbine) C14 Ignition Coil (No.4) C30 Fusible Link Block C15 Starter C16 Engine Oil Pressure SWP1Knock Control Sensor (Bank 1),

G ELECTRICAL WIRING ROUTING Position of Parts in Instrument Panel

[H/B] c1 b1 A19 A26 A17 E10 Q1 Q2 V1 W2 W1 E4 E3 E1 A13 A16 A20 E9 E8 E2 J8 J9 E6 E5 A13 Stop Lamp SWQ1Airbag Squib (Front Passenger’s Airbag Assembly) A16 Clutch Start SWQ2Airbag Squib (Front Passenger’s Airbag Assembly) A17 PTC Heater A19 Power Steering ECUV1Spiral Cable A20 Accelerator Position Sensor Steering Pad SW A26 Junction ConnectorW1Airbag Squib (Steering Wheel Pad) E 1 Blower SW Spiral CableE2A/C Thermistor No.1W2Airbag Squib (Steering Wheel Pad) E 3 Blower Resistor Spiral CableE4Blower MotorE5A/C SWb1Power Steering ECUE6Rear Window Defogger SW Power Steering MotorE8A/C AmplifierE9A/C Amplifierc1Power Steering ECU E10 Junction Connector Power Steering Torque SensorJ8Airbag Sensor Assembly CenterJ9Airbag Sensor Assembly Center,

G Position of Parts in Instrument Panel

[H/B] D24 D31 D25 D23 D7 D36 D37 D2 D27 D39 D1 D38 D35 D34 D32 D26 D8 D18 D10 D44 D11 D33 D74 D43 D42 D29 D9 D45 D13 D41 D19 D5 D6 D15 D46 D40 D12 D4 D3 D28 D16 D14 D20 D22 D30 D21 D75D1Combination Meter D26 Theft Warning ECUD2Combination Meter D27 Passenger Seat Belt Warning LampD3Spiral Cable D28 Oxygen Sensor (Bank 1 Sensor 2) D 4 Headlamp Dimmer SW Assembly D29 Light Control RheostatD5Windshield Wiper SW Assembly D30 Door Lock Control SWD6Windshield Wiper SW Assembly D31 Power Steering ECUD7Hazard Warning Signal SW D32 Antenna AmplifierD8Ignition SW D33 Main Body ECUD9Running Light Relay D34 Junction Connector D10 Radio Receiver Assembly D35 Junction Connector D11 Radio Receiver Assembly D36 Junction Connector D12 Outer Mirror SW D37 Junction Connector D13 Key Interlock Solenoid D38 Junction Connector D14 Cigarette Lighter or Power Outlet D39 Junction Connector D15 Data Link Connector 3 D40 Junction Connector D16 Airbag Sensor Assembly Center D41 Junction Connector D18 Spiral Cable D42 Junction Connector D19 Unlock Warning SW D43 Fuse Block D20 A/T Shift Lever Illumination D44 Diode (Starter) D21 Parking Brake SW D45 ACC Cut Relay D22 Shift Lock Control ECU D46 Front Fog Light Relay D23 Transponder Key ECU D74 Radio Receiver Assembly D24 Transponder Key Amplifier D75 Stereo Jack Adapter D25 Security Indicator Lamp,

G ELECTRICAL WIRING ROUTING Position of Parts in Instrument Panel

[S/D] A13 A16 V1 c1 b1 A19 E9 A17 E8 E10 E2 E1 E6 Q1 Q2 E5 E3 E4 A29 W1 A20 W2 J8 J9 A13 Stop Lamp SWQ1Airbag Squib (Front Passenger’s Airbag Assembly) A16 Clutch Start SWQ2Airbag Squib (Front Passenger’s Airbag Assembly) A17 PTC Heater A19 Power Steering ECUV1Cruise Control SW A20 Accelerator Position Sensor Spiral Cable A29 Cruise Control Clutch SW Steering Pad SWE1Blower SWW1Airbag Squib (Steering Wheel Pad) E 2 A/C Thermistor No.1 Spiral CableE3Blower ResistorW2Airbag Squib (Steering Wheel Pad) E 4 Blower Motor Spiral CableE5A/C SWE6Rear Window Defogger SWb1Power Steering ECUE8A/C Amplifier Power Steering MotorE9A/C Amplifier E10 Junction Connectorc1Power Steering ECU Power Steering Torque SensorJ8Airbag Sensor Assembly CenterJ9Airbag Sensor Assembly Center,

G Position of Parts in Instrument Panel

[S/D] D13 D31 D25 D23 D9 D11 D36 D76 D37 D1 D77 D35 D34 D39 D38 D10 D74 D32 D26 D8 D24 D19 D44 D42 D33 D5 D43 D6 D45 D75 D41 D20 D22 D21 D15 D29 D46 D40 D12 D4 D3 D18 D28 D16 D14D1Combination Meter D28 Oxygen Sensor (Bank 1 Sensor 2) D 3 Spiral Cable D29 Light Control RheostatD4Headlamp Dimmer SW Assembly D31 Power Steering ECUD5Windshield Wiper SW Assembly D32 Antenna AmplifierD6Windshield Wiper SW Assembly D33 Main Body ECUD8Ignition SW D34 Junction ConnectorD9Running Light Relay D35 Junction Connector D10 Radio Receiver Assembly D36 Junction Connector D11 Radio Receiver Assembly D37 Junction Connector D12 Outer Mirror SW D38 Junction Connector D13 Key Interlock Solenoid D39 Junction Connector D14 Cigarette Lighter or Power Outlet D40 Junction Connector D15 Data Link Connector 3 D41 Junction Connector D16 Airbag Sensor Assembly Center D42 Junction Connector D18 Spiral Cable D43 Fuse Block D19 Unlock Warning SW D44 Diode (Starter) D20 A/T Shift Lever Illumination D45 ACC Cut Relay D21 Parking Brake SW D46 Front Fog Light Relay D22 Shift Lock Control ECU D74 Radio Receiver Assembly D23 Transponder Key ECU D75 Stereo Jack Adapter D24 Transponder Key Amplifier D76 Combination Meter D25 Security Indicator Lamp D77 Hazard Warning Signal SW D26 Theft Warning ECU,

G ELECTRICAL WIRING ROUTING Position of Parts in Body

[5–Door] U1 F6 F4 K1 F2 F1 K2 U4 U5 F5 X1 M1 H1 H2 H3 O1 H4 G2 N1 G1 N4 G4 N3 G5 Z1 G6 N2 L1 Y1 I1 I4 I2 U3 U2 I3 a1 M2F1Power Window SW (Front RH) L 1 License Plate LampF2Outer Rear View Mirror (RH) F 4 Power Window Regulator Motor (Front RH) M 1 Center Stop LampF5Door Lock Assembly (Front Passenger’s Side) M 2 Rear Window DefoggerF6Speaker (Front Door RH) N 1 Rear Wiper Motor AssemblyG1Power Window Master SWN2Back Door Courtesy SWG2Outer Rear View Mirror (LH) N 3 Back Door Lock AssemblyG4Power Window Regulator Motor (Front LH) N 4 Back Door Position SWG5Door Lock Assembly (Driver’s Side) G 6 Speaker (Front Door LH) O 1 Rear Window DefoggerH1Power Window SW (Rear RH) U 1 Occupant Classification ECUH2Power Window Regulator Motor (Rear RH) U 2 Occupant Classification Sensor (Front LH) H 3 Door Lock Assembly (Rear RH) U 3 Occupant Classification Sensor (Rear LH) H 4 Speaker (Rear RH) U 4 Occupant Classification Sensor (Front RH) U 5 Occupant Classification Sensor (Rear RH) I 1 Power Window SW (Rear LH) I 2 Power Window Regulator Motor (Rear LH) X 1 Side Airbag Squib (RH) I 3 Door Lock Assembly (Rear LH) I 4 Speaker (Rear LH) Y 1 Side Airbag Squib (LH) K 1 Map LampZ1Speed Sensor (Rear RH) K 2 Room Lamp (Center) a 1 Speed Sensor (Rear LH),

G Position of Parts in Body

[5–Door] J24 J11 J31 J23 J1 J20 J16 J22 J32 J14 J3 J13 J30 J10 J2 J21 J17 J15 J33 J25 J12 J5 J29 J28 J4J1Door Courtesy SW (Front RH) J 20 Pretensioner (RH) J 2 Door Courtesy SW (Front LH) J 21 Pretensioner (LH) J 3 Rear Combination Lamp (RH) J 22 Curtain Shield Airbag Squib (RH) J 4 Rear Combination Lamp (LH) J 23 Curtain Shield Airbag Squib (LH) J 5 Fuel Suction Pump and Gage Assembly J 24 Occupant Classification ECU J 10 Front Seat Inner Belt (Driver’s Side) J 25 Canister Pump Module J 11 Front Seat Inner Belt Assembly (Front RH) J 28 Junction Connector J 12 Room Lamp (Luggage) J 29 Junction Connector J 13 Door Control Receiver J 30 Diode (Room Lamp) J 14 Airbag Sensor (Rear RH) J 31 Noise Filter J 15 Airbag Sensor (Rear LH) J 32 Door Courtesy SW (Rear RH) J 16 Side Airbag Sensor (RH) J 33 Door Courtesy SW (Rear LH) J 17 Side Airbag Sensor (LH),

G ELECTRICAL WIRING ROUTING Position of Parts in Body

[3–Door] K1 F2 F1 K2 F4 F6 U4 U5 F5 X1 M1 M2 U1 G5 O1 G2 N1 G1 N3 G4 N2 G6 Z1 L1 Y1 U2 U3 a1 N4F1Power Window SW (Front RH) N 1 Rear Wiper Motor AssemblyF2Outer Rear View Mirror (RH) N 2 Back Door Courtesy SWF4Power Window Regulator Motor (Front RH) N 3 Back Door Lock AssemblyF5Door Lock Assembly (Front Passenger’s Side) N 4 Back Door Position SWF6Speaker (Front Door RH) O 1 Rear Window DefoggerG1Power Window Master SWG2Outer Rear View Mirror (LH) U 1 Occupant Classification ECUG4Power Window Regulator Motor (Front LH) U 2 Occupant Classification Sensor (Front LH) G 5 Door Lock Assembly (Driver’s Side) U 3 Occupant Classification Sensor (Rear LH) G 6 Speaker (Front Door LH) U 4 Occupant Classification Sensor (Front RH) U 5 Occupant Classification Sensor (Rear RH) K 1 Map LampK2Room Lamp (Center) X 1 Side Airbag Squib (RH) L 1 License Plate LampY1Side Airbag Squib (LH) M 1 Center Stop LampZ1Speed Sensor (Rear RH) M 2 Rear Window Defoggera1Speed Sensor (Rear LH),

G Position of Parts in Body

[3–Door] J24 J11 J23 J31 J20 J16 J26 J14 J22 J3 J10 J2 J21 J17 J27 J15 J13 J12 J25 J30 J5 J29 J28 J4 J1J1Door Courtesy SW (Front RH) J 20 Pretensioner (RH) J 2 Door Courtesy SW (Front LH) J 21 Pretensioner (LH) J 3 Rear Combination Lamp (RH) J 22 Curtain Shield Airbag Squib (RH) J 4 Rear Combination Lamp (LH) J 23 Curtain Shield Airbag Squib (LH) J 5 Fuel Suction Pump and Gage Assembly J 24 Occupant Classification ECU J 10 Front Seat Inner Belt (Driver’s Side) J 25 Canister Pump Module J 11 Front Seat Inner Belt Assembly (Front RH) J 26 Speaker (Rear RH) J 12 Room Lamp (Luggage) J 27 Speaker (Rear LH) J 13 Door Control Receiver J 28 Junction Connector J 14 Airbag Sensor (Rear RH) J 29 Junction Connector J 15 Airbag Sensor (Rear LH) J 30 Diode (Room Lamp) J 16 Side Airbag Sensor (RH) J 31 Noise Filter J 17 Side Airbag Sensor (LH),

G ELECTRICAL WIRING ROUTING Position of Parts in Body

[4–Door] G2 Y1 F6 F4 K1 F2 F1 K2 F7 I3 X1 F5 H1 H2 H3 O1 G6 G4 G1 G7 G5 I1 I2 a1 U2 U3 U1 U4 U5 Z1F1Power Window SW (Front RH) K 1 Map LampF2Outer Rear View Mirror (RH) K 2 Room Lamp (Center) F 4 Power Window Regulator Motor (Front RH) F 5 Door Lock Assembly (Front Passenger’s Side) O 1 Rear Window DefoggerF6Speaker (Front Door RH) F 7 Door Lock Control SW (Front Passenger’s Side) U 1 Occupant Classification ECUU2Occupant Classification Sensor (Front LH) G 1 Power Window Master SWU3Occupant Classification Sensor (Rear LH) G 2 Outer Rear View Mirror (LH) U 4 Occupant Classification Sensor (Front RH) G 4 Power Window Regulator Motor (Front LH) U 5 Occupant Classification Sensor (Rear RH) G 5 Door Lock Assembly (Driver’s Side) G 6 Speaker (Front Door LH) X 1 Side Airbag Squib (RH) G 7 Door Lock Control SW (Driver’s Side) Y 1 Side Airbag Squib (LH) H 1 Power Window SW (Rear RH) H 2 Power Window Regulator Motor (Rear RH) Z 1 Speed Sensor (Rear RH) H 3 Door Lock Assembly (Rear RH) a 1 Speed Sensor (Rear LH) I 1 Power Window SW (Rear LH) I 2 Power Window Regulator Motor (Rear LH) I 3 Door Lock Assembly (Rear LH),

G Position of Parts in Body

[4–Door] J23 J22 J44 J38 J1 J12 J13 J32 J45 J34 J11 J41 J24 J43 J2 J36 J10 J42 J21 J17 J33 J15 J20 J29 J28 J5 J25 J16 J35 J39 J30 J40 J14 J37J1Door Courtesy SW (Front RH) J 28 Junction ConnectorJ2Door Courtesy SW (Front LH) J 29 Junction ConnectorJ5Fuel Suction Pump and Gage Assembly J 30 Diode (Room Lamp) J 10 Front Seat Inner Belt (Driver’s Side) J 32 Door Courtesy SW (Rear RH) J 11 Front Seat Inner Belt Assembly (Front RH) J 33 Door Courtesy SW (Rear LH) J 12 Room Lamp (Luggage) J 34 Rear Combination Lamp (RH) J 13 Door Control Receiver J 35 Rear Combination Lamp (LH) J 14 Airbag Sensor (Rear RH) J 36 License Plate Lamp (RH) J 15 Airbag Sensor (Rear LH) J 37 License Plate Lamp (LH) J 16 Side Airbag Sensor (RH) J 38 Speaker (Rear RH) J 17 Side Airbag Sensor (LH) J 39 Speaker (Rear LH) J 20 Pretensioner (RH) J 40 High Mounted Stop Light J 21 Pretensioner (LH) J 41 High Mounted Stop Light J 22 Curtain Shield Airbag Squib (RH) J 42 Door Lock Assembly (Luggage) J 23 Curtain Shield Airbag Squib (LH) J 43 Door Lock Assembly (Luggage) J 24 Occupant Classification ECU J 44 Rear Window Defogger J 25 Canister Pump Module J 45 Noise Filter,

G ELECTRICAL WIRING ROUTING

: Location of Connector Joining Wire Harness and Wire Harness : Location of Ground Points [H/B] Engine Room Main Wire Sensor Wire CA2 Engine Room CA1 No.2 Wire BA1 A1 Engine Wire A2 C1 C2 B1 CP1,

G

: Location of Connector Joining Wire Harness and Wire Harness : Location of Ground Points [S/D] Engine Room Main Wire Sensor Wire CA2 CA1 Engine Room No.2 Wire BA1 A1 Engine Wire A2 B1 C1 C2 CP1,

G ELECTRICAL WIRING ROUTING

: Location of Connector Joining Wire Harness and Wire Harness [H/B] AD1 AD5 AA2 AA1 DE1 Instrument Panel DQ1 Instrument Panel Wire Wire Assembly Roof Wire Instrument Panel AE1 No.2 Wire ED1 Front Door RH Wire AJ1 JD2 FD2 AD4 FD1 JD1 Floor Wire Front Door LH Wire GD1 GD2 AD3 AD2 Engine Room Main Wire : Location of Ground Points D3 A3 D2 D1,

G

: Location of Connector Joining Wire Harness and Wire Harness [S/D] AE1 AD5 ED1 AA1 DE1 Instrument Panel DQ1 Instrument Panel Wire Wire Assembly Roof Wire Instrument Panel AD1 No.2 Wire AD4 Front Door RH Wire JD3 AJ1 FD2 JD2 FD1 JD1 Floor Wire Front Door LH Wire GD2 GD1 AD3 AD2 AA2 Engine Room Main Wire : Location of Ground Points D3 A3 D2 D1,

G ELECTRICAL WIRING ROUTING

: Location of Connector Joining Wire Harness and Wire Harness : Location of Ground Points [5–Door] IJ1 Front Door JX1 MJ1 HJ1 Seat Airbag Rear Door RH Wire RH Wire No.1 Wire J1 Rear Window No.1 Wire Roof Wire O1 Front Door ZJ1 LH Wire Back Door No.2 Wire JY1 N1 Seat Airbag MN1 LH Wire Skid Control Sensor RH Wire Back Door No.1 Wire Rear Door No.2 Front Seat Skid Control J2 Luggage Room Floor Wire Wire RH Wire aJ1 Sensor LH Wire LJ1 No.2 Wire,

G

: Location of Connector Joining Wire Harness and Wire Harness : Location of Ground Points [3–Door] Seat Airbag Front Door JX1 MJ1 Seat Airbag J1 LH Wire RH Wire RH Wire Rear Window No.1 Wire O1 Roof Wire ZJ1 Front Door LH Wire Back Door No.2 Wire N1 MN1 Skid Control Sensor RH Wire Back Door No.1 Wire Front Seat Skid Control J2 Luggage Room JY1 Floor Wire RH Wire aJ1 Sensor LH Wire LJ1 No.2 Wire,

G ELECTRICAL WIRING ROUTING

: Location of Connector Joining Wire Harness and Wire Harness : Location of Ground Points [4–Door] Front Door JX1 Seat Airbag HJ1 Rear Door No.1 RH Wire RH Wire Wire Rear Roof Wire WindowNo.1 Wire Front Door O1 LH Wire ZJ1 Floor Wire J1 Skid Control Sensor RH Wire Seat Airbag Rear Door Skid Control Front Seat J2 IJ1 LH Wire JY1 No.2 Wire aJ1 Sensor LH Wire RH Wire,

SYSTEM CIRCUITS H

2007 YARIS

ELECTRICAL WIRING DIAGRAM SYSTEM CIRCUITS

Page ABS .154 Air Conditioning .238 Audio System .222 Back–Up Light .140 Charging .78 Cigarette Lighter .220 Combination Meter .226 Cooling Fan .234 Cruise Control .102 Data Link Connector 3 .112 Door Lock Control .184 Electronically Controlled Transmission and A/T Indicator .96 Engine Control .84 Engine Immobiliser System .110 EPS .174 Front Fog Light .146 Front Wiper and Washer .208 Headlight .120 Horn .144 Ignition .80 Illumination .134 Interior Light .128 Key Reminder .150 Light Reminder .150 Multiplex Communication System (CAN) .116 Power Outlet .220 Power Source .68 Power Window .178 Rear Window Defogger .216 Rear Wiper and Washer .212 Remote Control Mirror .218 Seat Belt Warning .168 Shift Lock .214 SRS .159 Starting .74 Stop Light .142 Taillight .134 Theft Deterrent .200 Turn Signal and Hazard Warning Light .124 Wireless Door Lock Control .192,

Power Source B

40A HTR SUB2 30A ABS2/VSC2B112121E 50A EPS 30A HTR SUB1121250A ABS1/VSC1 30A RDI1212

W

40A HTR12C10 Generator 7. 5A ALT–S1121D

B

1 15A DOME1230A ST121C1A1B2B7. 5A ECU–B1210A ETCS1210A HAZ1210A H–LP LH/H–LP LO LH Battery12L10A H–LP RH/H–LP LO RH12

B

120A ALT B

B

60A MAIN W

W

A27(B), A28(A), C30(C) Fusible Link Block

L

, B B EFI Relay 20A EFI 10A EFI2124B4B121A AA1 1 10A HORN1215A AM2W1121C

Y

ACC2WY4AM1 IG11GGR 5 AM2 IG26P31B 2 1B 4 1B 1 1B ST27BD8 Ignition SW 14 AA2 5 AD4 3 AD2 4 AD2

W

L L A1 W–BPPPWWIG2 Relay GR GR,

Power Source

BBYY

W

GG17. 5A ACC22BD43 Fuse Block 8 4S2315A CIG 13 4B14L57. 5A ACC 4F 7. 5A IGN 18 AD4WW47. 5A MET 4F L 13

ACCR

A21 Engine Control ModuleLPGGP

W

D45 W ACC Cut Relay, T–LP RelayB110A TAIL 4G ∗ 1 : H/B, S/D ∗3 (∗1) (∗1) (∗1) (∗1) ∗ 2 : Except ∗1 7. 5A PANEL1 ∗ 3 : Cold Area Spec. , w/ Engine Immobiliser System, (∗1) (∗1) (∗1) (∗1) w/ ABS, w/ Rear Window Defogger, 30A DEF DEF Relay w/ Door Lock Control, 1 2 10A ID/UP/MIR HTR w/ Daytime Running Light, w/ Remote Control Mirror, w/ Air Conditioning 15A FR FOG 7. 5A OBD2 25A D/LY14F 10A STOP 25A AM1G34F 10A TAIL4W4M (∗2) (∗2) (∗2) 30A POWER B1 PWR Relay12B1 T1 Light OFF Control 20A RL DOOR SW Tail Head 20A RR DOOR T1 IG 1 Relay5310A ECU–IG G (∗2) 2 1 25A WIP 15A WSH 10 7. 5A PANEL2 7. 5A PANEL1 4E 17 4E 7 4M (∗2) (∗2) (∗2) 10A GAUGE 15A RR WIP 7. 5A A/C 1 6A D1 D2 W–B W–B D4 Headlamp Dimmer SW Assembly,

Power Source

: Parts Location Code See Page Code See Page Code See Page 46 (H/B) 47 (H/B) 51 (H/B) A21 C10 D8 48 (S/D) 49 (S/D) 53 (S/D) 43, 46 (H/B) 42, 47 (H/B) 45, 51 (H/B) A27 B C30 C D43 43, 48 (S/D) 42, 49 (S/D) 45, 53 (S/D) 43, 46 (H/B) 51 (H/B) 51 (H/B) A28 A D4 D45 43, 48 (S/D) 53 (S/D) 53 (S/D) : Relay Blocks Code See Page Relay Blocks (Relay Block Location) 1 24 Engine Room R/B (Engine Compartment Left) : Junction Block and Wire Harness Connector Code See Page Junction Block and Wire Harness (Connector Location) 1A 1B 25 1C Engine Room Main Wire and Engine Room J/B (Engine Compartment Left) 1D 1E 4B 30 Engine Room Main Wire and Instrument Panel J/B (Lower Finish Panel) 4E 30 Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel) 4F 4G 30 Engine Room Main Wire and Instrument Panel J/B (Lower Finish Panel) 4M 31 Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel) 4S 6A 40 Instrument Panel Wire and J/B No.6 (Right Kick Panel) : Connector Joining Wire Harness and Wire Harness Code See Page Joining Wire Harness and Wire Harness (Connector Location) 62 (H/B) AA1 63 (S/D) Engine Room Main Wire and Engine Room Main Wire (Instrument Panel Left) 62 (H/B) AA2 63 (S/D) 62 (H/B) AD2 63 (S/D) Engine Room Main Wire and Instrument Panel Wire (Instrument Panel Left) 62 (H/B) AD4 63 (S/D) : Ground Points Code See Page Ground Points Location 60 (H/B) A1 Left Suspension Tower 61 (S/D) 62 (H/B) D1 Left Kick Panel 63 (S/D) 62 (H/B) D2 Right Kick Panel 63 (S/D),

Memo

,

Starting

(BAT) 30A

ST

5 2

ST

Relay31111A25 Junction Connector 13 14 12 10 CA1 9 CA1

BR

1BA5BLC27 2 Park/NeutralMPPosition SW

N

C1(A), C15(B) Starter 4 10 CA2 Battery GR21Y(∗1) Y 3 A25 Junction (∗2) Connector A1

B

VVWW–BYB(∗2) (∗2) A16 Clutch Start SWWWB(∗1) (∗1) GR BR (∗1), (BAT) ∗ 1 : A/T ∗ 2 : M/T 15A AM2 5 AM2 IG2 B ST27B11B D8 Ignition SW 4 AD2 9 AD4 14A1STSW D44 Diode (Starter) GR STA STAR 2 48 A 52B8CA1 12 AA2 5 AA2 1 AD4

BR

7 5 D36 Junction Connector 10 AD4 13 AA2

Y GR

A21(A), C20(B) Engine Control Module

BR

Y GROOOOBSB B,

Starting

: Parts Location Code See Page Code See Page Code See Page 50 (H/B) C1 A 49 (S/D) 51 (H/B) A16 D8 52 (S/D) 47 (H/B) 53 (S/D) C15 B 46 (H/B) 49 (S/D) 51 (H/B) A21 A D36 48 (S/D) 47 (H/B) 53 (S/D) C20 B 46 (H/B) 49 (S/D) 51 (H/B) A25 D44 48 (S/D) 47 (H/B) 53 (S/D) C27 C1 A 47 (H/B) 49 (S/D) : Relay Blocks Code See Page Relay Blocks (Relay Block Location) 1 24 Engine Room R/B (Engine Compartment Left) : Junction Block and Wire Harness Connector Code See Page Junction Block and Wire Harness (Connector Location) 1B 25 Engine Room Main Wire and Engine Room J/B (Engine Compartment Left) : Connector Joining Wire Harness and Wire Harness Code See Page Joining Wire Harness and Wire Harness (Connector Location) 62 (H/B) AA2 Engine Room Main Wire and Engine Room Main Wire (Instrument Panel Left) 63 (S/D) 62 (H/B) AD2 63 (S/D) Engine Room Main Wire and Instrument Panel Wire (Instrument Panel Left) 62 (H/B) AD4 63 (S/D) 60 (H/B) CA1 61 (S/D) Engine Wire and Engine Room Main Wire (Engine Compartment Left) 60 (H/B) CA2 61 (S/D) : Ground Points Code See Page Ground Points Location 60 (H/B) A1 Left Suspension Tower 61 (S/D),

Memo

,

Charging

(BAT) (IG) (IG) ∗ 1 : w/ Daytime Running Light ∗ 2 : w/o Daytime Running Light114M 19 4B1AALT ALT CHG– 24 5091B(H/B) 1 C (S/D) 7 AE1 13 14 SB (∗1) 15 CA1 5 CA1 15 AD3 1 CA1 7 AA2

B

4 CA1 C9(A), C10(B) 1B3A1AGenerator4A2ABMSLIG IC Regulator C30 Battery Fusible Link Block 120A ALTPPPE9 A/C AmplifierPPC20 Engine Control ModuleWWD39 7. 5A ALT–S Junction ConnectorLG(∗1) (∗1) D9 Running Light Relay 7. 5A MET ChargeLLLLB(∗2) D1(A), D2(B), D76(C) Combination Meter 10A GAUGE G G, : Parts Location Code See Page Code See Page Code See Page 47 (H/B) 42, 47 (H/B) D9 53 (S/D) C9 A C30 49 (S/D) 42, 49 (S/D) 51 (H/B) D39 47 (H/B) 51 (H/B) 53 (S/D) C10 B D1 A 49 (S/D) 53 (S/D) D76 C 53 (S/D) 47 (H/B) D2 B 51 (H/B) 50 (H/B) C20 E9 49 (S/D) D9 51 (H/B) 52 (S/D) : Relay Blocks Code See Page Relay Blocks (Relay Block Location) 1 24 Engine Room R/B (Engine Compartment Left) : Junction Block and Wire Harness Connector Code See Page Junction Block and Wire Harness (Connector Location) 4B 30 Engine Room Main Wire and Instrument Panel J/B (Lower Finish Panel) 4M 31 Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel) : Connector Joining Wire Harness and Wire Harness Code See Page Joining Wire Harness and Wire Harness (Connector Location) 62 (H/B) AA2 Engine Room Main Wire and Engine Room Main Wire (Instrument Panel Left) 63 (S/D) 62 (H/B) AD3 Engine Room Main Wire and Instrument Panel Wire (Instrument Panel Left) 63 (S/D) 62 (H/B) AE1 Engine Room Main Wire and Instrument Panel No.2 Wire (Instrument Panel Left) 63 (S/D) 60 (H/B) CA1 Engine Wire and Engine Room Main Wire (Engine Compartment Left) 61 (S/D),

Ignition

(BAT)

GR

D8 15A Ignition SW AM2 5 AM2 IG26PST2 5 AD4 4 AD2 R 14 AA2 11 CA1

R

2 1B 1 1B 4 1B IG2 Relay 3 1B A1PP

GR

W–BRRC25 Noise Filter,

R

R R

LG

C11 C12 C13 C14 Ignition Coil Ignition Coil Ignition Coil Ignition Coil 1 (No. 1) 1 (No. 2) 1 (No. 3) 1 (No. 4) +B +B +B +B GND IGT IGF IGF IGT2 GND IGF GND IGT3 IGF GND IGT4432234243243YYW–B W–B 85 81 84 83 82 IGT1 IGF1 IGT2 IGT3 IGT4 C20 Engine Control Module C1 W–B W–B BR

W

YYYR

O

W–B Y LG W–B

G

L R W–B

LG

,

Ignition

: Parts Location Code See Page Code See Page Code See Page 47 (H/B) C13 49 (S/D) 47 (H/B) C11 C25 49 (S/D) 47 (H/B) 49 (S/D) C14 47 (H/B) 49 (S/D) 51 (H/B) C12 D8 49 (S/D) 47 (H/B) 53 (S/D) C20 C13 47 (H/B) 49 (S/D) : Junction Block and Wire Harness Connector Code See Page Junction Block and Wire Harness (Connector Location) 1B 25 Engine Room Main Wire and Engine Room J/B (Engine Compartment Left) : Connector Joining Wire Harness and Wire Harness Code See Page Joining Wire Harness and Wire Harness (Connector Location) 62 (H/B) AA2 Engine Room Main Wire and Engine Room Main Wire (Instrument Panel Left) 63 (S/D) 62 (H/B) AD2 63 (S/D) Engine Room Main Wire and Instrument Panel Wire (Instrument Panel Left) 62 (H/B) AD4 63 (S/D) 60 (H/B) CA1 Engine Wire and Engine Room Main Wire (Engine Compartment Left) 61 (S/D) : Ground Points Code See Page Ground Points Location 60 (H/B) A1 Left Suspension Tower 61 (S/D) 60 (H/B) C1 Engine Block Left 61 (S/D),

Memo

,

Engine Control

(BAT) (BAT) 20A 15A EFI AM222EFI IG2 5 AM2 IG2 6 Relay Relay ST2 D8 1 1A 4 1A 3 1A 2 1A 3 1B 2 1B 4 1B 1 1B Ignition SW 14 AA2 4 AD2 5 AD4 11 CA111112222

L P GR SB GR B Y

A1

Y B

W–B W–B

GR

W–B W–B SB LG C4 Fuel Injector (No. 1) P P GRRRRC5 Fuel Injector (No. 2)

GR

P BR C6 GR Fuel Injector (No. 3)

R

C7 Fuel Injector (No. 4) P P, (IG) (BAT) 7. 5A 10A IGN STOP 18 4B C/OPN Relay 27 4B 9 4B 5 4E 11 4B 8 4A32A13 Stop Lamp SW41A21(A), C20(B) Engine Control Module 35 A 36 A ST1– STP FC IGSW # 40 # 30 # 20 # 10 MREL BATT7A28 A 105 B 106 B 107 B 108 B 44 A 20 A

M

12 AD4

L P GR SB GR

BBBB

Y

J1

P R V B

W–B W–B B Pump J5 Fuel Suction Pump and Gage Assembly

V R L P GR

Y P SBGB

GR Y

,

Engine Control

(BAT) (BAT) 15A 10A DOME ETCS112313 4B1484S 2 24 AA2 18 AD4 A21(A), C20(B) 14 A 52 B 48 A Engine Control Module 13 A 96 B 97B3ASTSW STAR STA ACCR ETHW THW +BM +B2 VPMP VCPP PPMP EPPM MPMP1A42 A 70 B 71 B 94 B 34 A 15 CA2 16 CA2 17 CA2 14 CA2 6 AA1 10 AA1 9 AA1 3 AA1 5 AA1 10A EFI2 4 AJ1 1 AJ1 7 AJ1 6 AJ1 5 AJ1 2 AJ1 3 AJ19843216VLVB VGND VCC VOUT SGND MTRB MGNDBB4AA1

M

Canister Pressure Sensor Vent Valve Leak Detection Pump

B

C2BBBIgnition SW

O

Park/Neutral Position SW (A/T) Clutch Start SW (M/T) B B

BR

J25 Canister Pump Module

L

VBB

P

PPVVVVGGLLLLLWD45 ACC Cut RelayOOOO

P

VVLPC19 BR BR BR Engine Coolant Temp. Sensor BR GR GR, ∗ 1 : H/B, S/D ∗3 (BAT) ∗ 2 : Except ∗14 4M ∗ 3 : Cold Area Spec. , w/ Engine Immobiliser System, w/ ABS, w/ Rear Window Defogger, 10A w/ Door Lock Control, T–LP TAIL Relay w/ Daytime Running Light, w/ Remote Control Mirror, 1 w/ Air Conditioning B1 10A B1 T1

TAIL

Light OFF Control SW Tail Head 1 4G 15 4B 10 4E T1 A21(A), C20(B) Engine Control Module 31 A

ELS

+B IMI IMO EOM PRG THA E2G VG ETHA2A11 A 10A9A49 B 65 B 116 B 118 B 88B8AD4 17 AD4 7 AD4 13 12 114235EFIO EFII EGND THA E2G VG E2 +B D23 1 C26 Transponder Key ECU Mass Air Flow MeterBV1V12VBBAA2 CA1B9B5BBAA2 AD5 A28 Fusible Link BlockBB120A ALT (∗1) (∗1) WWG(∗1) (∗1) O O (∗2) BR BR

G

(∗2) V L D4 C3 Headlamp Dimmer SW Assembly VSV (Purge) B P

LG W

(∗2)

GR O

,

Engine Control

85 B 84 B 83 B 82 B 81 B 21 A 22 A IGT1 IGT2 IGT3 IGT4 IGF1 FAN FAN2 HA1A A1A– A1A+ HT1B EX1B 109 B 113 B 112 B A21(A), C20(B) 47 B 87 B Engine Control Module 5 CA2 4 CA2143HA1A A1A– A1A+ 4 AD5 3 AD5 +B 2 C23 Air Fuel Ratio Sensor (Bank 1 Sensor 1) 1 4 HT1B E2 +B OX1B23

W B

(Shielded)

B

BGW(Shielded)

O LG G

Ignition Coils

V LG Y O

FAN NO. 1 Relay

LG

FAN NO. 2 Relay D28 Oxygen Sensor (Bank 1 Sensor 2) B LG LG LG W GR GR GR, (BAT) 30A

DEF

11 4M A20 Accelerator Position Sensor

DEF

Relay 10A ID/UP/ MIR HTR VCP2 VPA2 EPA2 VCPA VPA EPA1324658AD3 A21(A), C20(B) Engine Control Module 33 A 58 A 56 A 60 A 57 A 55 A 59 A ELS3 VCP2 VPA2 EPA2 VCPA VPA EPA OX1B KNK1 EKNK NE+ NE– G2+ 64 B 110 B 111 B 122 B 121 B 99B2CA2 3 CA2 1 CP1 2 CP1121AD5 2 AD521

W

(Shielded) C1 (Shielded) (Shielded) (Shielded) WWG(Shielded) WRVVKnock Control Sensor (Bank 1) B G

W

BR (Shielded)

L L

C2 Crankshaft Position Sensor BRPP

B

(Shielded)

R W

C18 Camshaft Position Sensor G

B

,

Engine Control

C17 Throttle Body Assembly E2 VC VTA VTA2 M+ M– 356421A21(A), C20(B) 91 B 67 B 115 B 114 B 42 B 41 B 63 B Engine Control Module ETA VCTA VTA1 VTA2 M+ M– GE01 OC1+ OC1– EC E02 E1 ME01 E01 E04 E03 ALT 100 B 123 B 32 A 44 B 104 B 43 B 45 B 46 B 86 B 50 B

M

C9 Generator A1 C1 C2 BR V C24 Camshaft Timing Oil Control Valve

W R Y GR

W–B (Shielded)

G B R W BR BR BR

W–B W–B W–B

P

, A21(A), C20(B) Engine Control Module TC TACH SPD CANL CANH W 27 A 15A8A49 A 41 A 24 A D16 Airbag Sensor Assembly Center 23 4B 26 4B 16 AD4 CANL CANH 15 AD4 17 AD3 22 13 13 AD4 12 4D 8 4C 15 1984D41 Junction Connector 22 11 13 9 TC TAC 22 11 D42 Junction Connector D15 187BData Link Connector 3

G W SB

P P LG LG SBVWWW

W B

YLLBB,

Engine Control

(IG) (BAT) (IG) 7. 5A 7. 5A 10A MET ECU–B ECU–IG 1 4M 1 30 4B 24 4B 2 4S 25 AA2 A25 Junction Connector D1(A), D2(B), D76(C) 1 A Combination Meter2A11 CA2 5V IC IG+ SI SE32

CPU

CAN Controller 12 CA2 13 CA2 CAN I/F I/F I/F 6 AA2 23 AA24B(H/B) 20 A 21 A 24 A 16 A 17A4C(S/D)

B

11 AD3

G W SB

D3 A1 Malfunction Indicator Lamp

B L G L W L BR

Tachometer

SB

Speedometer

P

PPPW–B W–B W–BBBBC21 Speed Sensor, System Outline 1. Electronic Fuel Injection It controls to have appropriate fuel injection according to the basic injection time. The basic injection time is calculated to fit the engine condition and is corrected with signals from various sensors. 2. Electronic Spark Advance Appropriate ignition is conducted according to the basic ignition timing which is calculated to fit the engine condition after correcting it with signals from various sensors. 3. Electronic Throttle Control System–intelligent It controls to have appropriate throttle opening according to the throttle opening calculated to fit the engine condition after correcting it with signals from various sensors. 4. Variable Valve Timing–intelligent It improves engine output, reduces exhaust gas and improves fuel consumption by varying the phase of the intake camshaft in accordance with the engine condition. 5. Electric Fan Control It controls the switching ON/OFF and fan speed of the cooling fan according to the coolant temperature and air conditioner’s condition. 6. Fuel Pump Control It turns ON/OFF the fuel pump according to the starter signal and engine speed signal. It stops the fuel pump operation according to signals from the airbag sensor assembly center. 7. Air Conditioning Cut–Off Control It reduces load of the air conditioner’s compressor in acceleration in order to secure the drivability. 8. Canister Purge Control It controls the purge flow volume of the canister according to the coolant temperature and driving condition. 9. Cranking Hold Control It continues to supply electricity to the starter between the start of cranking and the engine start in order to prevent the engine start failure by the key’s switching off just before the engine’s complete explosion. 10. Oxygen Sensor Control It switches ON/OFF the oxygen sensor according to the coolant temperature and driving condition. 11. Diagnosis It realizes accurate and detailed diagnosis of a failure such as calling the SAE specified diagnosis code data and active test by using the diagnosis tool. 12. Fail–Safe When the engine control module detects abnormality in signals of the sensors, it stops or continues to control the engine by using the standard values in the engine control module.,

Engine Control

: Parts Location Code See Page Code See Page Code See Page 50 (H/B) 47 (H/B) D15 53 (S/D) A13 C17 52 (S/D) 49 (S/D) 51 (H/B) D16 50 (H/B) 47 (H/B) 53 (S/D) A20 C18 52 (S/D) 49 (S/D) 51 (H/B) D23 46 (H/B) 47 (H/B) 53 (S/D) A21 A C19 48 (S/D) 49 (S/D) 51 (H/B) D28 46 (H/B) 47 (H/B) 53 (S/D) A25 C20 B 48 (S/D) 49 (S/D) 51 (H/B) D41 43, 46 (H/B) 47 (H/B) 53 (S/D) A28 C21 43, 48 (S/D) 49 (S/D) 51 (H/B) D42 47 (H/B) 47 (H/B) 53 (S/D) C2 C23 49 (S/D) 49 (S/D) 51 (H/B) D45 47 (H/B) 47 (H/B) 53 (S/D) C3 C24 49 (S/D) 49 (S/D) D76 C 53 (S/D) 47 (H/B) 47 (H/B) 55 (5–Door) C4 C26 49 (S/D) 49 (S/D) J5 57 (3–Door) 47 (H/B) 51 (H/B) 59 (4–Door) C5 D1 A 49 (S/D) 53 (S/D) 55 (5–Door) 47 (H/B) D2 B 51 (H/B) J25 57 (3–Door) C6 49 (S/D) 51 (H/B) 59 (4–Door) D4 47 (H/B) 53 (S/D) 47 (H/B) C7 P1 49 (S/D) 51 (H/B) 49 (S/D) D8 47 (H/B) 53 (S/D) C9 49 (S/D) D15 51 (H/B) : Relay Blocks Code See Page Relay Blocks (Relay Block Location) 1 24 Engine Room R/B (Engine Compartment Left) : Junction Block and Wire Harness Connector Code See Page Junction Block and Wire Harness (Connector Location) 1A 25 Engine Room Main Wire and Engine Room J/B (Engine Compartment Left) 1B 4A 30 Floor Wire and Instrument Panel J/B (Lower Finish Panel) 4B 30 Engine Room Main Wire and Instrument Panel J/B (Lower Finish Panel) 4C 4D 30 Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel) 4E 4G 30 Engine Room Main Wire and Instrument Panel J/B (Lower Finish Panel) 4M 31 Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel) 4S, : Connector Joining Wire Harness and Wire Harness Code See Page Joining Wire Harness and Wire Harness (Connector Location) 62 (H/B) AA1 63 (S/D) Engine Room Main Wire and Engine Room Main Wire (Instrument Panel Left) 62 (H/B) AA2 63 (S/D) 62 (H/B) AD2 63 (S/D) 62 (H/B) AD3 63 (S/D) Engine Room Main Wire and Instrument Panel Wire (Instrument Panel Left) 62 (H/B) AD4 63 (S/D) 62 (H/B) AD5 63 (S/D) 62 (H/B) AJ1 Engine Room Main Wire and Floor Wire (Instrument Panel Left) 63 (S/D) 60 (H/B) CA1 61 (S/D) Engine Wire and Engine Room Main Wire (Engine Compartment Left) 60 (H/B) CA2 61 (S/D) 60 (H/B) CP1 Engine Wire and Sensor Wire (Engine Compartment Center) 61 (S/D) : Ground Points Code See Page Ground Points Location 60 (H/B) A1 Left Suspension Tower 61 (S/D) 60 (H/B) C1 61 (S/D) Engine Block Left 60 (H/B) C2 61 (S/D) 62 (H/B) D3 Instrument Panel Reinforcement Left 63 (S/D) 64 (5–Door) Right Rear Quarter Panel J1 65 (3–Door) 66 (4–Door) Lower Back Panel Right,

ECT and A/T Indicator

(BAT) (IG) (BAT) 20A 7. 5A 10A EFI IGN STOP 9 4B 27 4B 18 4B

EFI

Relay 1 1A 4 1A 3 1A 2 1A32A13 Stop Lamp SW41A21(A), C20(B) 35 A 36 A Engine Control Module 52 B 48 A ST1– STP STAR STA IGSW MREL +B2 +B BATT 28 A 44A1A2A20 A A1

Y B

W–B W–B

GR R

YPRGB

GR B B O

Park/Neutral Position SW Y BR, A20 Accelerator Position Sensor VCP2 VPA2 EPA2 VCPA VPA EPA1324652296 B 97 B 125 B 124 B 58 A 56 A 60 A 57 A 55 A 59 A ETHW THW NT+ NT– VCP2 VPA2 EPA2 VCPA VPA EPA A21(A), C20(B) Engine Control Module NE+ NE– EC E02 E1 ME01 E01 E04 E03 122 B 121 B 32 A 44 B 104 B 43 B 45 B 46 B 86 B C1 A1 C1 C2

P

BR (Shielded) L P

L

C19 C2 Engine Coolant Temp. Sensor Crankshaft Position SensorPBC29 Speed Sensor (Turbine)

G

W–B

W B L W BR BR B BR R

W–B W–B W–B G,

ECT and A/T Indicator

A21(A), C20(B) Engine Control Module TC TACH SPD CANL CANH 27 A 15A8A49 A 41 A 23 4B 26 4B 16 AD4 15 AD4 13 AD4 12 4D 8 4C 15 4 D41 Junction Connector 22 11 13 9 TC TAC 22 11 D42 Junction Connector D15 18 7 Data Link Connector 3

G W SB

P P LG LG SBVWWWYLL, (BAT) (IG) 10A 10A ETCS GAUGE

G

1 19 4B21CA1

RB G

PL RL NL DL 2L LL61973824 AA2 L 14 CA1 A21(A), C20(B) Engine Control Module3A73 B 53 B 54 B 55 B 74 B 56 B +BMPRN2LDS1 S2 SLU+ SLU– SLT+ SLT– ST THO1 ETHO ODMS 79 B 78 B 57 B 77 B 76 B 75 B 80 B 72 B 95 B 26 A 22 AA2 14 AD3 2 AD3 5 104938216S1 S2 SLU+(H/B) SLU– SLT+ SLT– ST THO E2 SL(S/D)

NSSD

Transmission Control SW AT3 C28 Electronically Controlled Transmission SolenoidGGWWSB SB W SBBLLG P GR GR C27 Park/Neutral Position SW BRORGGRGR W SB Y GROYGOBVOOLLLLD22 Shift Lock Control ECU,

ECT and A/T Indicator

(BAT) (IG) (IG) 7. 5A 7. 5A 10A ECU–B MET ECU–IG114M 24 4B A25 25 AA2 Junction Connector 30 4B 11 CA2 2 4S D121Combination Meter IG+ SI SE 5V IC32LED Driver 12 CA2 13 CA2

CPU

CAN Controller 6 AA2 23 AA2 CAN I/F I/F I/F 20 21 24 16 17 11 AD3

G W SB

D3 A1LLL

B G P

(S/D) (S/D)

W R

(S/D) (S/D)

N

(S/D) (S/D)

BR

Tachometer (

D

S/D) (S/D)

SB

Speedometer (S/D) (S/D)

P

(S/D) L (S/D) PPPW–B W–B W–BBBBC21 Speed Sensor, : Parts Location Code See Page Code See Page Code See Page 50 (H/B) C19 49 (S/D) 51 (H/B) A13 D1 52 (S/D) 47 (H/B) 53 (S/D) C20 B 50 (H/B) 49 (S/D) 51 (H/B) A20 D15 52 (S/D) 47 (H/B) 53 (S/D) C21 46 (H/B) 49 (S/D) 51 (H/B) A21 A D22 48 (S/D) 47 (H/B) 53 (S/D) C27 46 (H/B) 49 (S/D) 51 (H/B) A25 D41 48 (S/D) 47 (H/B) 53 (S/D) C28 47 (H/B) 49 (S/D) 51 (H/B) C2 D42 49 (S/D) 47 (H/B) 53 (S/D) C29 C19 47 (H/B) 49 (S/D) : Relay Blocks Code See Page Relay Blocks (Relay Block Location) 1 24 Engine Room R/B (Engine Compartment Left) : Junction Block and Wire Harness Connector Code See Page Junction Block and Wire Harness (Connector Location) 1A 25 Engine Room Main Wire and Engine Room J/B (Engine Compartment Left) 4B 30 Engine Room Main Wire and Instrument Panel J/B (Lower Finish Panel) 4C 4D Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel) 4M 4S : Connector Joining Wire Harness and Wire Harness Code See Page Joining Wire Harness and Wire Harness (Connector Location) 62 (H/B) AA2 Engine Room Main Wire and Engine Room Main Wire (Instrument Panel Left) 63 (S/D) 62 (H/B) AD3 63 (S/D) Engine Room Main Wire and Instrument Panel Wire (Instrument Panel Left) 62 (H/B) AD4 63 (S/D) 60 (H/B) CA1 61 (S/D) Engine Wire and Engine Room Main Wire (Engine Compartment Left) 60 (H/B) CA2 61 (S/D) : Ground Points Code See Page Ground Points Location 60 (H/B) A1 Left Suspension Tower 61 (S/D) 60 (H/B) C1 61 (S/D) Engine Block Left 60 (H/B) C2 61 (S/D) 62 (H/B) D3 Instrument Panel Reinforcement Left 63 (S/D),

Cruise Control

(BAT) (IG) (BAT) 20A 7. 5A 10A EFI IGN STOP 9 4B 27 4B 18 4B

EFI

Relay 1 1A 4 1A 3 1A 2 1A32A13 Stop Lamp SW41A21(A), C20(B) 35 A 36 A Engine Control Module ST1– STP IGSW MREL +B2 +B BATT 28 A 44A1A2A20 A A1

Y B

W–B W–B

GR R

YPRGB

GR B B Y

, A20 Accelerator Position Sensor VCP2 VPA2 EPA2 VCPA VPA EPA13246558 A 56 A 60 A 57 A 55 A 59 A VCP2 VPA2 EPA2 VCPA VPA EPA A21(A), C20(B) Engine Control Module TC TACH EC E02 E1 ME01 E01 E04 E03 27 A 15 A 32 A 44 B 104 B 43 B 45 B 46 B 86 B 23 4B 13 AD4 12 4D 13 9 TC TAC D15 Data Link Connector 3 A1 C1 C2PPLG LG W–B

W B L W BR BR B BR R

W–B W–B W–B G,

Cruise Control

(BAT) 10A

ETCS

C17 Throttle Body Assembly E2 VC VTA VTA2 M+ M– 35642124 AA2 A21(A), C20(B) 3 A 91 B 67 B 115 B 114 B 42 B 41 B 63 B Engine Control Module +BM ETA VCTA VTA1 VTA2 M+ M– GE01 CCS SPD CANL CANH 40A8A49 A 41A6AD4 26 4B 16 AD4 15 AD4 8 4C 15 4 D41 Junction2A1AD3(A), V1(B) Connector ECC CCS Spiral 22 11 Cable4B3BD34 Junction MAIN Connector 22 11 D42 6 Junction Connector +RES 1876AD2 –SET

G CANCEL W

13 CA1 V1(B) Cruise Control SW SB C1 GR GR BR BR BR BR

V W Y

L L GR (Shielded)

G R

SB V

BR

WWWYLL, (IG) (IG) 10A 10A ECU–IG GAUGE 24 4B 19 4B B 21 16BG(M/T) (M/T) (A/T) A25 Junction 1 Connector21CA1

D G

2 (A/T)

L

L 14 (A/T)

L

CA1 (M/T) A21(A), C20(B) Engine Control Module 56 B

D

S1 S2 SLU+ SLU– SLT+ SLT– ST THO1 ETHO 79 B 78 B 57 B 77 B 76 B 75 B 80 B 72 B 95B5104938216S1 S2 SL SLU– SLT+ SLT– ST THO E2 C28 Electronically Controlled Transmission SolenoidGGWWSB SB W SB (A/T) B L (A/T) LG P (A/T) A29 BR O Cruise Control (A/T) Clutch SWGG(A/T) GR W (A/T) Y GR (A/T) O Y (A/T) C27 Park/Neutral Position SWOB(A/T),

Cruise Control

(BAT) (IG) (IG) 7. 5A 7. 5A 10A ECU–B MET ECU–IG114M 24 4B A25 25 AA2 Junction Connector 30 4B 11 CA2 2 4S D1 Combination Meter21IG+ SI SE 5V IC32LED Driver 12 CA2 13 CA2

CPU

CAN Controller 6 AA2 23 AA2 CAN I/F I/F I/F 20 21 24 16 17 11 AD3

G W SB

D3 A1

G W

LLL

BR

SB B

CRUISE P

PPPW–B W–B W–BBBBC21 Speed Sensor, System Outline The cruise control system is a constant vehicle speed controller in which control of the switch on the instrument panel makes it possible to automatically adjust the opening of the engine throttle valve without depressing of the accel pedal. 1. Set Operation When the CRUISE SW is turned on and the SET SW is pushed with the vehicle speed within the set limit (Approx. 40 km/h, 25 mph to 200 km/h, 124 mph), a signal is input to TERMINAL CCS of the engine control module, and the vehicle speed at the time the SET SW is released is memorized in the ECU as the set speed. 2. Set Speed Control During cruise control driving, the ECU compares the set speed memorized in the ECU with the actual vehicle speed input into TERMINAL SPD of the engine control module from the combination meter, and controls the throttle body assembly to maintain the set speed. When the actual speed is lower than the set speed, the ECU causes the current to the throttle control motor to flow from TERMINAL M+ of the engine control module to TERMINAL 2 of the throttle body assembly to TERMINAL 1 to TERMINAL M– of the engine control module. As a result, the motor in the throttle control motor is rotated to open the throttle valve to increase the vehicle speed. When the actual driving speed is higher than the set speed, the current to the throttle body assembly flows from TERMINAL M– of the ECU to TERMINAL 1 of the throttle control motor to TERMINAL 2 to TERMINAL M+ of the engine control module. This causes the motor in the throttle body assembly to rotate to close the throttle valve to decrease the vehicle speed. 3. Coast Control During cruise control driving, while the –SET SW is on, the throttle control motor is rotated to close the throttle valve and decrease the driving speed. The vehicle speed when the –SET SW is turned off is memorized, and the vehicle continues at the new set speed. 4. Accel Control During cruise control driving, while the +RES SW is turned on, the throttle control motor is rotated to open the throttle valve and increase the driving speed. The vehicle speed when the +RES SW is turned off is memorized and the vehicle continues at the new set speed. 5. Resume Control If the vehicle speed is approximately 40 km/h (25 mph) or above after canceling the set speed with the CANCEL SW, pushing the +RES SW will cause the vehicle to resume the speed set before the cancellation. 6. Manual Cancel Mechanism If any of the following signals is input during cruise control travelling, the cruise control is cancelled. ∗ Depressing the clutch pedal (Cruise control clutch SW off). ”Signal is not input to TERMINAL D of the ECU” (M/T) ∗ Placing the shift lever to positions except ”D” position (Park/Neutral position SW except ”D” position) (A/T) ∗ Pushing the CANCEL SW (CANCEL SW on). ”Signal input to TERMINAL CCS of the ECU” ∗ Pushing the CRUISE SW off ”signal input to TERMINAL CCS of the ECU”. ∗ Depressing the brake pedal (Stop light SW on) 7. Tap–Up Control Function When the difference between the actual vehicle speed and the set speed is less than 5 km/h (3 mph), the set speed can be increased 1.6 km/h (1 mph) each time by operating the +RES SW quickly within 0.6 seconds. 8. Tap–Down Control Function When the difference between the actual vehicle speed and the set speed is less than 5 km/h (3 mph), the set speed can be lowered 1.6 km/h (1 mph) each time by operating the –SET SW quickly within 0.6 seconds. 9. Auto Cancel Function A) If any of the following operating conditions occurs during cruise control operation, the set speed is erased and the cruise control is released, (CRUISE SW turns off). When this occurs, the ignition SW must be turned off once before the CRUISE SW will turn on. ∗ When abnormality is found in the stop light SW input circuit. ∗ When abnormality is found in the cancel circuit. B) If any of the following operating conditions occurs during cruise control operation, the set speed is erased and the cruise control is released. (CRUISE SW turn off). When this occurs, the cancel state is cleared as the CRUISE SW will turn on again. ∗ When abnormality is found in electronic throttle parts. ∗ Open circuit in the stop light SW. ∗ Momentary interruption of vehicle speed signal. ∗ Short circuit in the stop light SW.,

Cruise Control

10. Overdrive Control Function The overdrive control may be cancelled if the vehicle travels on the slope during cruise control travelling. After the overdrive control has been cancelled it is decided that the slope is finished, the vehicle returns to the overdrive control mode again. : Parts Location Code See Page Code See Page Code See Page A13 52 (S/D) C20 B 49 (S/D) D15 53 (S/D) A20 52 (S/D) C21 49 (S/D) D34 53 (S/D) A21 A 48 (S/D) C27 49 (S/D) D41 53 (S/D) A25 48 (S/D) C28 49 (S/D) D42 53 (S/D) A29 52 (S/D) D1 53 (S/D) V1 B 52 (S/D) C17 49 (S/D) D3 A 53 (S/D) : Relay Blocks Code See Page Relay Blocks (Relay Block Location) 1 24 Engine Room R/B (Engine Compartment Left) : Junction Block and Wire Harness Connector Code See Page Junction Block and Wire Harness (Connector Location) 1A 25 Engine Room Main Wire and Engine Room J/B (Engine Compartment Left) 4B 30 Engine Room Main Wire and Instrument Panel J/B (Lower Finish Panel) 4C 4D Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel) 4M 4S : Connector Joining Wire Harness and Wire Harness Code See Page Joining Wire Harness and Wire Harness (Connector Location) AA2 63 (S/D) Engine Room Main Wire and Engine Room Main Wire (Instrument Panel Left) AD2 AD3 63 (S/D) Engine Room Main Wire and Instrument Panel Wire (Instrument Panel Left) AD4 CA1 61 (S/D) Engine Wire and Engine Room Main Wire (Engine Compartment Left) CA2 : Ground Points Code See Page Ground Points Location A1 61 (S/D) Left Suspension Tower C1 61 (S/D) Engine Block Left C2 D3 63 (S/D) Instrument Panel Reinforcement Left,

Memo

,

Engine Immobiliser System

(BAT) (IG) 7. 5A 7. 5A ECU–B IGN 1 21 4E D24 Transponder Key Amplifier A21 Transponder Key Coil Engine Control Module 25 AA2 30 4B IMI IMO EOM VC5 CODE TXCT AGND 11 109145712 4H 11A8AD4 17 AD4 7 AD42B1213 12 11 14 1545+B IG EFIO EFII EGND VC5 CODE TXCT AGND GND IND KSW CTY D 16 8 D23379Transponder Key ECU

LG

(S/D) 4 4C 6 4C 21 17 D35 Junction LG 16 Connector (S/D) 20 D35 2 Junction 7 4D 21 4A Connector D25 Security 3 4S Indicator Lamp11D19 J2 Unlock Door Courtesy SW Warning SW (Front LH) 7 4E62

SIL

D40 Junction Connector D15 11 Data Link Connector336A 1 5A D2 D1 W–BLPLLD36(A), D37(B) Junction Connector W–B W–B W–B LG R (H/B) WWOOW–BYOBR BRRB

P G

LOWV

GR

, : Parts Location Code See Page Code See Page Code See Page 46 (H/B) 51 (H/B) 51 (H/B) A21 D24 D37 B 48 (S/D) 53 (S/D) 53 (S/D) 51 (H/B) 51 (H/B) 51 (H/B) D15 D25 D40 53 (S/D) 53 (S/D) 53 (S/D) 51 (H/B) 51 (H/B) 55 (5–Door) D19 D35 53 (S/D) 53 (S/D) J2 57 (3–Door) 51 (H/B) 51 (H/B) 59 (4–Door) D23 D36 A 53 (S/D) 53 (S/D) : Relay Blocks Code See Page Relay Blocks (Relay Block Location) 1 24 Engine Room R/B (Engine Compartment Left) : Junction Block and Wire Harness Connector Code See Page Junction Block and Wire Harness (Connector Location) 4A 30 Floor Wire and Instrument Panel J/B (Lower Finish Panel) 4B 30 Engine Room Main Wire and Instrument Panel J/B (Lower Finish Panel) 4C 4D 4E Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel) 4H 4S 31 5A 38 Instrument Panel Wire and J/B No.5 (Left Kick Panel) 6A 40 Instrument Panel Wire and J/B No.6 (Right Kick Panel) : Connector Joining Wire Harness and Wire Harness Code See Page Joining Wire Harness and Wire Harness (Connector Location) 62 (H/B) AA2 Engine Room Main Wire and Engine Room Main Wire (Instrument Panel Left) 63 (S/D) 62 (H/B) AD4 Engine Room Main Wire and Instrument Panel Wire (Instrument Panel Left) 63 (S/D) : Ground Points Code See Page Ground Points Location 62 (H/B) D1 Left Kick Panel 63 (S/D) 62 (H/B) D2 Right Kick Panel 63 (S/D),

Data Link Connector 3

(BAT) 7. 5A W OBD2 J24 D23 WOccupant Transponder Classification Key ECU ECU SB 5 4S

W

D DIAL927149 41 CANL CANH CANL CANH 7 JD2 SIL TS TC TACH 2 11 27 15 D34(A), D35(B) Junction 12 A Connector 13 A 21 B 20 B 13 AD4 31 4E 3 4S 23 4B 7 4E 12 4D 16 7 12 13 9 BAT SIL TS TC TAC CG SG CANL CANH45D15 14 6 BR Data Link Connector 3 (∗1) 5 A D34(A) Junction Connector6A

BR

(∗1) 6 AD2

V

13 CA1

W

D1 D2 C1 W–B W–B SB W–BLWBR BR BR W (∗2) G G D31 Power Steering ECUOP

LG W

A21 Engine Control ModuleVPPLG LG, ∗ 1 : w/ Cruise Control ∗ 2 : w/o Cruise ControlWW

W SB W

L D33 Main Body ECU

Y

CANL CANH 22 23 W 165415 11 22 D42 7 18 Junction Connector 20 21 CANH CANL D1 Combination Meter

W L

VVWW

W R SB W

GYWW,

Data Link Connector 3 W

D16 Airbag Sensor 16 Assembly Center

SIL Y

CANH CANL W 13 22 D41 22 11 8 19 Junction Connector 154314 6 17 1 12 16 AD4 15 AD4 1 DE1 10 DE1 11 AD4 2 AD42365TX+ TX– CANH CANL E8 A15 A/C Amplifier Skid Control ECU with Actuator

W L V W

WWWLLY

V W

VVBWWWWGGWW, : Parts Location Code See Page Code See Page Code See Page 46 (H/B) 51 (H/B) 51 (H/B) A15 D23 D41 48 (S/D) 53 (S/D) 53 (S/D) 46 (H/B) 51 (H/B) 51 (H/B) A21 D31 D42 48 (S/D) 53 (S/D) 53 (S/D) 51 (H/B) 51 (H/B) 50 (H/B) D1 D33 E8 53 (S/D) 53 (S/D) 52 (S/D) 51 (H/B) 51 (H/B) 55 (5–Door) D15 D34 A 53 (S/D) 53 (S/D) J24 57 (3–Door) 51 (H/B) 51 (H/B) 59 (4–Door) D16 D35 B 53 (S/D) 53 (S/D) : Junction Block and Wire Harness Connector Code See Page Junction Block and Wire Harness (Connector Location) 4B 30 Engine Room Main Wire and Instrument Panel J/B (Lower Finish Panel) 4D 4E Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel) 4S 31 : Connector Joining Wire Harness and Wire Harness Code See Page Joining Wire Harness and Wire Harness (Connector Location) 62 (H/B) AD2 63 (S/D) Engine Room Main Wire and Instrument Panel Wire (Instrument Panel Left) 62 (H/B) AD4 63 (S/D) 60 (H/B) CA1 Engine Wire and Engine Room Main Wire (Engine Compartment Left) 61 (S/D) 62 (H/B) DE1 Instrument Panel Wire and Instrument Panel No.2 Wire (Instrument Panel Center) 63 (S/D) 62 (H/B) JD2 Floor Wire and Instrument Panel Wire (Instrument Panel Left) 63 (S/D) : Ground Points Code See Page Ground Points Location 60 (H/B) C1 Engine Block Left 61 (S/D) 62 (H/B) D1 Left Kick Panel 63 (S/D) 62 (H/B) D2 Right Kick Panel 63 (S/D),

Multiplex Communication System – CAN

D33 D31 Main Body ECU Power Steering ECU CANL CANH CANH CANL 22 2317

Y W

165415 11 22 D42 7 18 Junction Connector 20 21 CANH CANL D1 Combination Meter

W R SB W

GYWW, D16 Airbag Sensor Assembly Center CANH CANL 13 22

Y W

D41 22 11 8 19 Junction Connector 154314 6 17 1 12 16 AD4 15 AD4 1 DE1 10 DE1 11 AD4 2 AD4 49 41 6 142365CANL CANH CANH CANL TX+ TX– CANH CANL A21 D15 E8 A15 Engine Control Module Data Link Connector 3 A/C Amplifier Skid Control ECU with ActuatorWWWLLY

V W

VVBWWWGGWW,

Multiplex Communication System – CAN

: Parts Location Code See Page Code See Page Code See Page 46 (H/B) D15 53 (S/D) 51 (H/B) A15 D41 48 (S/D) 51 (H/B) 53 (S/D) D16 46 (H/B) 53 (S/D) 51 (H/B) A21 D42 48 (S/D) 51 (H/B) 53 (S/D) D31 51 (H/B) 53 (S/D) 50 (H/B) D1 E8 53 (S/D) 51 (H/B) 52 (S/D) D33 D15 51 (H/B) 53 (S/D) : Connector Joining Wire Harness and Wire Harness Code See Page Joining Wire Harness and Wire Harness (Connector Location) 62 (H/B) AD4 Engine Room Main Wire and Instrument Panel Wire (Instrument Panel Left) 63 (S/D) 62 (H/B) DE1 Instrument Panel Wire and Instrument Panel No.2 Wire (Instrument Panel Center) 63 (S/D),

Memo

,

Headlight

(BAT) (BAT) 10A 10A H–LP RH/ H–LP LH/ H–LP LO RH H–LP LO LH2211GR(∗3) GR(∗4) 3 BA1 6 BA1 V(∗4) L(∗3) 3 3 GR(∗3) B4 B6 Headlamp (RH) Headlamp (LH) 2121

BR L

7 BA1 4 BA1 2 BA1 5 BA1 34 4B 16 4B L(∗3) GR(∗3) 16 4C 4 4J L(∗4)

P

(∗2) P(∗2) SB D39 Junction987Connector HU HL 5 P(∗1)

SB

B1 T1 RF (H) ED HU HL (ED) ED OFF Flash Tail Low Head High RF ED D4 12 11 Headlamp Dimmer SWLLAssembly W–B 12 17 W–B BR(∗1) 4E 4E D1 Light Control SW GRGG(∗1) BBPBR Dimmer SW

L

(∗4)

L

(∗3) GR GRVG(∗3)

BR

(∗1), (BAT) ∗ 1 : w/ Daytime Running Light ∗ 2 : w/o Daytime Running Light 7. 5A ∗ 3 : w/ H–LP/AMT Relay ECU–B ∗ 4 : w/o H–LP/AMT Relay GR(∗3) GR(∗3) GR(∗4) V(∗4) L(∗3) L(∗3) GR(∗3) L7LAD5 25 AA2 (∗1 ∗3) (∗1 ∗3) 228AA2 30 4B51H–LP/AMT Relay 20 AD3 2 4S 12 4H3214 B (H/B) 14 C (S/D) 2A22L(∗4) 17 4B 11 B 13 B (H/B) 11 C 13 C (S/D) 35 4B 3 4J P(∗2) P(∗1) SB SB 1 D40 18 B ( ) JunctionD37 B Connector Junction Connector 16 B 17BL(∗1 ∗3) P(∗1) L P(∗1) BR(∗1) BR(∗1) A1 D1(A), D2(B), D76(C) Combination Meter Beam GR GR

L

Head (USA) PLLLL(∗1)

P

(∗1) W–B (∗3)

L

(∗4) Y V (∗3) V(∗4),

Headlight

(BAT) (IG) ∗ 1 : w/ Daytime Running Light ∗ 3 : w/ H–LP/AMT Relay 15A 10A FR FOG ECU–IG 9 4M 7 4S D4 Headlamp Dimmer SW Assembly LFG BFG Fog Light SW OFF25D46 Front Front Fog Light Relay LFG BFG43138B9BD9 16 Running Light Relay 12 FOG IG DRL +B H HI E PKB CHG– 137821194B54C 12 11A24C 6 AD5 15 AD3 7 AA2L1(∗1 ∗3) P(∗1) 4 CA1 P(∗1) BR(∗1)

L

A1LO(∗1 ∗3)

Y R

(∗1) D36(A), D37(B) Junction Connector

V

PRV(∗1)

BR

(∗1) W–B W–B Y LG D21 Parking Brake SWLLLLGGR R D39 D37(B) C9 Junction Junction Connector Generator Connector, : Parts Location Code See Page Code See Page Code See Page 46 (H/B) 51 (H/B) D37 B 53 (S/D) B4 D4 48 (S/D) 53 (S/D) 51 (H/B) D39 46 (H/B) 51 (H/B) 53 (S/D) B6 D9 48 (S/D) 53 (S/D) 51 (H/B) D40 47 (H/B) 51 (H/B) 53 (S/D) C9 D21 49 (S/D) 53 (S/D) 51 (H/B) D46 51 (H/B) 51 (H/B) 53 (S/D) D1 A D36 A 53 (S/D) 53 (S/D) D76 C 53 (S/D) D2 B 51 (H/B) D37 B 51 (H/B) : Relay Blocks Code See Page Relay Blocks (Relay Block Location) 1 24 Engine Room R/B (Engine Compartment Left) 2 28 Engine Room R/B No.2 (Engine Compartment Right) : Junction Block and Wire Harness Connector Code See Page Junction Block and Wire Harness (Connector Location) 4B 30 Engine Room Main Wire and Instrument Panel J/B (Lower Finish Panel) 4C 4E 4H Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel) 4J 4M 4S : Connector Joining Wire Harness and Wire Harness Code See Page Joining Wire Harness and Wire Harness (Connector Location) 62 (H/B) AA2 Engine Room Main Wire and Engine Room Main Wire (Instrument Panel Left) 63 (S/D) 62 (H/B) AD3 63 (S/D) Engine Room Main Wire and Instrument Panel Wire (Instrument Panel Left) 62 (H/B) AD5 63 (S/D) 60 (H/B) BA1 Engine Room No.2 Wire and Engine Room Main Wire (Engine Compartment Left) 61 (S/D) 60 (H/B) CA1 Engine Wire and Engine Room Main Wire (Engine Compartment Left) 61 (S/D) : Ground Points Code See Page Ground Points Location 60 (H/B) A1 Left Suspension Tower 61 (S/D) 62 (H/B) D1 Left Kick Panel 63 (S/D),

Turn Signal and Hazard Warning Light

(IG) (BAT) 10A 10A GAUGE HAZ 32 4B14IG +B FLASH Relay LR LL2331 4B 14 4B 28 4A 27 4A4A3A1A2A3B5B2A(S/D) 2 A (S/D) 3 B (H/B) 3 B (H/B) 1111116A(S/D) 6 A (S/D) 22226B(H/B) 6 B (H/B) 2 2 W–B B1 A1 J1 J2 W–B G (S/D) (S/D) Turn B14 Turn Signal, Side Marker and A24(A), B13(B) Parking Lamp (RH) Junction Connector W–B W–BGG(H/B) (H/B) B1 Turn Signal Lamp (Front RH)

G

W–B LG (H/B) (S/D) (S/D) Turn B15 R Turn Signal, Side Marker and Parking Lamp (LH) W–B LG LG (H/B) (H/B) B8 Turn Signal Lamp (Front LH) W–B W–B LG (H/B) (H/B) (H/B) A2 Turn Signal Lamp (Front Side LH) W–B G (H/B) (H/B) A1 Turn Signal Lamp (Front Side RH) W–B Y Turn J3(B), J34(A) Rear Combination Lamp (RH) W–B LG Turn J4(B), J35(A) Rear Combination Lamp (LH),

E

E TR TL

RH LH

TR TL D465Headlamp Dimmer SW Assembly 12 4S 11 4S 28 4E65ER EL FLASH Relay EHW GND8716 4S 13 4S 17 4S 7 4M 17 4E 15B8B(H/B) 15 A (S/D) 15C8C(S/D) 4 B (H/B) 4 A (S/D) 1 B (H/B) 24A36A 5 6A 1 6A D3 D2 D1 Turn RH

BR

Turn LH BR LG D1(A), D2(B), D76(C) Combination Meter Turn Signal SW D40 D7(B), D77(A) Junction Hazard Warning Connector Signal SW W–B W–B W–B B

V

W–B B W–B W–B W–B,

Turn Signal and Hazard Warning Light

: Parts Location Code See Page Code See Page Code See Page A1 46 (H/B) B15 48 (S/D) D76 C 53 (S/D) A2 46 (H/B) 51 (H/B) D77 A 53 (S/D) D1 A 46 (H/B) 53 (S/D) 55 (5–Door) A24 A J3 B 48 (S/D) D2 B 51 (H/B) 57 (3–Door) B1 46 (H/B) 51 (H/B) 55 (5–Door) D4 J4 B B8 46 (H/B) 53 (S/D) 57 (3–Door) 46 (H/B) D7 B 51 (H/B) J34 A 59 (4–Door) B13 B 48 (S/D) 51 (H/B) J35 A 59 (4–Door) D40 B14 48 (S/D) 53 (S/D) : Relay Blocks Code See Page Relay Blocks (Relay Block Location) 1 24 Engine Room R/B (Engine Compartment Left) : Junction Block and Wire Harness Connector Code See Page Junction Block and Wire Harness (Connector Location) 4A 30 Floor Wire and Instrument Panel J/B (Lower Finish Panel) 4B 30 Engine Room Main Wire and Instrument Panel J/B (Lower Finish Panel) 4E 30 4M Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel) 4S 6A 40 Instrument Panel Wire and J/B No.6 (Right Kick Panel) : Ground Points Code See Page Ground Points Location A1 60 (H/B) Left Suspension Tower 60 (H/B) B1 Radiator Support Left 61 (S/D) 62 (H/B) D1 Left Kick Panel 63 (S/D) 62 (H/B) D2 Right Kick Panel 63 (S/D) 62 (H/B) D3 Instrument Panel Reinforcement Left 63 (S/D) 64 (5–Door) Right Rear Quarter Panel J1 65 (3–Door) 66 (4–Door) Lower Back Panel Right 64 (5–Door) Left Rear Quarter Panel J2 65 (3–Door) 66 (4–Door) Lower Back Panel Left,

Memo

,

Interior Light

(BAT) 15A

DOME

D33(A) Main Body ECU 13 4B BCTY(H/B) LGCY(S/D) 5 4K 4 4P 7 4A

BR

(S/D)

BR

(H/B) 1B6B5B110 A 12 MJ12A12 JD1 2 15 MN123221

O P

W–B W–B2312N1 J2 K1 Map LampLLLW–B K2 Room Lamp (Center) W–B On Off L

P

Door GR GR L J12 D38(A), D39(B) Room Lamp (Luggage) Junction Connector

SB W

J30 J28(A), J29(B) Diode (Room Lamp) Junction Connector W–B Courtesy BR BR (H/B) (H/B) (H/B) N2 Back Door Courtesy SW W–B Courtesy BR (S/D) (S/D) J42 Door Lock Assembly (Luggage), (ACC) (BAT) 7. 5A 25A ACC D/L D33(A) 21 4 Main Body ECU ACC ALTB ILE GND1 KSW CANH CANL71923 A 22A74D 2 4K 1 4K 17 4E 5 16 D42 Junction Connector 7 18

P

W–B

W

1 5A

G

D1 D1

P

W–B W–B W–B W–B Y D19 Unlock Warning SWGRWW,

Interior Light

(BAT) 7. 5A ECU–B L 25LLAA2 30 4B 2 4S D33(A) Main Body ECU 6

BECU

DCTY PCTY RRCY 26 20 22 21 4A 24 4A 20 4A 5 4A

Y

(∗3) 1111Y(∗3) G(∗3) L(∗3) WWGG

R

J2 Door Courtesy SW (Front LH)

L

J1 Door Courtesy SW (Front RH)

L

(∗3)

L

(∗4) J32 Door Courtesy SW (Rear RH)

G

(∗3)

G

(∗4) J33 Door Courtesy SW (Rear LH), ∗ 1 : S/D w/ Tachometer ∗ 2 : S/D w/o Tachometer, H/B (IG) ∗ 3 : S/D ∗5 ∗ 4 : H/B, S/D Except ∗5 ∗ 5 : Cold Area Spec. , 7. 5A w/ Engine Immobiliser System, MET w/ ABS, w/ Rear Window Defogger, w/ Door Lock Control, w/ Daytime Running Light, w/ Remote Control Mirror, 1 4MLLw/ Air Conditioning D1(A), D76(C) Combination Meter2A1ALED Driver

CPU

CAN Controller CAN I/F 22 C 20 C 21 C 21 A 20 A 24A5JD2 2 JD2 3 JD2 Y(∗3) G(∗3) L(∗3)

W G

D3

Y

(∗3) Door (∗ () Rear LH)G 1 (∗1) (∗3) Door ∗ (( ) Rear RH)L 1 (∗1) (∗3)

W G

(∗ ) Door2 (∗2) Door (∗ ) Graphic1 (∗1) B Door ∗ (( ) Front LH)BR 1 (∗1) Door ∗ (Front RH)( 1) (∗1) Door ∗ (Luggage)( 1) (∗1),

Interior Light

: Parts Location Code See Page Code See Page Code See Page 51 (H/B) J1 59 (4–Door) J30 59 (4–Door) D1 A 53 (S/D) 55 (5–Door) 55 (5–Door) J32 51 (H/B) J2 57 (3–Door) 59 (4–Door) D19 53 (S/D) 59 (4–Door) 55 (5–Door) J33 51 (H/B) 55 (5–Door) 59 (4–Door) D33 A 53 (S/D) J12 57 (3–Door) J42 59 (4–Door) 51 (H/B) 59 (4–Door) 54 (5–Door) D38 A 53 (S/D) 55 (5–Door) K1 56 (3–Door) 51 (H/B) J28 A 57 (3–Door) 58 (4–Door) D39 B 53 (S/D) 59 (4–Door) 54 (5–Door) 51 (H/B) 55 (5–Door) K2 56 (3–Door) D42 53 (S/D) J29 B 57 (3–Door) 58 (4–Door) D76 C 53 (S/D) 59 (4–Door) 54 (5–Door) N2 55 (5–Door) 55 (5–Door) 56 (3–Door) J1 J30 57 (3–Door) 57 (3–Door) : Relay Blocks Code See Page Relay Blocks (Relay Block Location) 1 24 Engine Room R/B (Engine Compartment Left) : Junction Block and Wire Harness Connector Code See Page Junction Block and Wire Harness (Connector Location) 4A 30 Floor Wire and Instrument Panel J/B (Lower Finish Panel) 4B 30 Engine Room Main Wire and Instrument Panel J/B (Lower Finish Panel) 4D 30 Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel) 4E 4K 30 Roof Wire and Instrument Panel J/B (Lower Finish Panel) 4M 4P 31 Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel) 4S 5A 38 Instrument Panel Wire and J/B No.5 (Left Kick Panel) : Connector Joining Wire Harness and Wire Harness Code See Page Joining Wire Harness and Wire Harness (Connector Location) 62 (H/B) AA2 Engine Room Main Wire and Engine Room Main Wire (Instrument Panel Left) 63 (S/D) 62 (H/B) JD1 63 (S/D) Floor Wire and Instrument Panel Wire (Instrument Panel Left) JD2 63 (S/D) 64 (5–Door) MJ1 Back Door No.1 Wire and Floor Wire (Left Rear Quarter Panel) 65 (3–Door) 64 (5–Door) MN1 Back Door No.1 Wire and Back Door No.2 Wire (Back Door Panel Center) 65 (3–Door), : Ground Points Code See Page Ground Points Location 62 (H/B) D1 Left Kick Panel 63 (S/D) 62 (H/B) D3 Instrument Panel Reinforcement Left 63 (S/D) J2 66 (4–Door) Lower Back Panel Left 64 (5–Door) N1 Back Door Panel Center 65 (3–Door),

Taillight and Illumination B

(BAT) 1 4G (∗1) A28 Fusible Link Block 10A TAIL T–LP Relay (∗1) (∗1) 4 4M 9 4S 19

TRLY

Main Body ECU

G

13 (∗2) B1 B1 T1 Light OFF Control SW Tail

G

Head (S/D) T1 G 10 (S/D) G G (∗2) (S/D)

G

(S/D) 434322W–B (S/D) ∗ 1 : H/B, S/D ∗3 ∗ 2 : Except ∗1 ∗ 3 : Cold Area Spec. , w/ Engine Immobiliser System, w/ ABS, w/ Rear Window Defogger, 4 6A w/ Door Lock Control, w/ Daytime Running Light, w/ Remote Control Mirror, D2 w/ Air Conditioning D4 Headlamp Dimmer SW Assembly 120A ALT

W

(∗2) W–B (∗1)

W

(∗1) (∗1) (∗1) (∗1) (∗1)

G

(S/D) Side Marker W–B G (S/D) (S/D) Parking B14 Turn Signal, Side Marker and Parking Lamp (RH)

G

(S/D) Side Marker W–B G (S/D) (S/D) Parking B15 Turn Signal, Side Marker and Parking Lamp (LH), (∗1) 10A TAIL(∗1) 7. 5A PANEL2(∗2) 10 4E 33 4B 10 4A 29 4A

G

(S/D) G GR (∗2) 10 A 11 A 12A9B10B7B8B

G

(S/D) 4 LJ1

G

(S/D)

G

(S/D)

G

(S/D) 4 A (S/D) 4 A (S/D) 4 B (H/B) 4 B (H/B) 221122211221116A(S/D) 6 A (S/D) 6 B (H/B) 6 B (H/B) 9 LJ1 W–B W–B W–B (S/D) W–B 8 BA1 (S/D) A1 B1 J1 J2 W–B G (H/B) (H/B) B11 Side Marker Lamp (Front RH) G (∗2) W–B W–B W–B G (H/B) (H/B) B12 Side Marker Lamp (Front LH) W–B W–B G (H/B) (H/B) B3 Parking Lamp (RH) W–BGP(H/B) (H/B) B7 A24(A), B13(B) Parking Lamp (LH) Junction Connector Tail W–B GR J3(B), J34(A) Rear Combination Lamp (RH) Tail W–B W–BGGJ4(B), J35(A) Rear Combination Lamp (LH) W–B W–BGG(H/B) (H/B) (H/B) (H/B) L1 License Plate Lamp W–B G (S/D) (S/D) J36 License Plate Lamp (RH) W–B G (S/D) (S/D) J37 License Plate Lamp (LH),

Taillight and Illumination BR V

(IG) 6 4Q 10 4P 7. 5A 7. 5A PANEL1 MET 7 4P 1 4M 2 4Q 9 4Q SB(H/B) R(H/B) R(H/B)

R

(S/D) G 5 DE1 13 E10 20 Junction Connector 19 21 22 16 B (H/B) 16 C (S/D) 1 A 14A255

W

(S/D) 146

R

Illumination I/F 8 DE1 I/F

CPU

I/F 11 108924 A 15A7AE10 Junction Connector

GR Y

D3 Tail (Canada)

G

Pointer

B

BR DialGR

Y GR

D1(A), D2(B), D76(C) Combination Meter LGLGE1 Blower SW W GR E6 Rear Window Defogger SWWBE5 A/C SWRWR(S/D) (S/D) D77 Hazard Warning Signal SW,

BR

(IG)

V

10A

GAUGE

1 4P8B9B11 B SB(H/B) 2 A R(H/B) 3 7 ILL+ 5 10 T IG D29 ILL– Light Control Rheostat22210A2ILL+ DIM ILL– ILL– RV RL TCE15B42983

W

(S/D)

R

9 15 A

LG

16 B 17 B 18 B 20 B 16 A 18 A

GR Y

W–B 3 6A 3 6A D2WWR(H/B) (H/B) D7 D38(A), D39(B) Hazard Warning Signal SW Junction Connector W SB (H/B) (H/B) D30 Door Lock Control SWWGD20 A/T Shift Lever IlluminationGGVD10(A), D11(B) Radio Receiver Assembly D38(A), D39(B) Junction Connector W–BWB(H/B) (H/B) (H/B) D40 Junction Connector D27 Passenger Seat Belt Warning Lamp LG BRWOD36(A), D37(B) Junction Connector

Y

W–B SB,

Taillight and Illumination

: Parts Location Code See Page Code See Page Code See Page 46 (H/B) D10 A 53 (S/D) D77 53 (S/D) A24 A 48 (S/D) 51 (H/B) 50 (H/B) D11 B E1 43, 46 (H/B) 53 (S/D) 52 (S/D) A28 43, 48 (S/D) 51 (H/B) 50 (H/B) D20 E5 B3 46 (H/B) 53 (S/D) 52 (S/D) B7 46 (H/B) D27 51 (H/B) 50 (H/B) E6 B11 46 (H/B) 51 (H/B) 52 (S/D) D29 B12 46 (H/B) 53 (S/D) 50 (H/B) E10 46 (H/B) D30 51 (H/B) 52 (S/D) B13 B 48 (S/D) 51 (H/B) 55 (5–Door) D36 A J3 B B14 48 (S/D) 53 (S/D) 57 (3–Door) B15 48 (S/D) 51 (H/B) 55 (5–Door) D37 B J4 B 51 (H/B) 53 (S/D) 57 (3–Door) D1 A 53 (S/D) 51 (H/B) J34 A 59 (4–Door) D38 A D2 B 51 (H/B) 53 (S/D) J35 A 59 (4–Door) 51 (H/B) 51 (H/B) J36 59 (4–Door) D4 D39 B 53 (S/D) 53 (S/D) J37 59 (4–Door) D7 51 (H/B) D40 51 (H/B) 54 (5–Door) L1 D10 A 51 (H/B) D76 C 53 (S/D) 56 (3–Door) : Junction Block and Wire Harness Connector Code See Page Junction Block and Wire Harness (Connector Location) 4A 30 Floor Wire and Instrument Panel J/B (Lower Finish Panel) 4B 30 Engine Room Main Wire and Instrument Panel J/B (Lower Finish Panel) 4E 30 Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel) 4G 30 Engine Room Main Wire and Instrument Panel J/B (Lower Finish Panel) 4M 4P 31 Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel) 4Q 4S 6A 40 Instrument Panel Wire and J/B No.6 (Right Kick Panel) : Connector Joining Wire Harness and Wire Harness Code See Page Joining Wire Harness and Wire Harness (Connector Location) 60 (H/B) BA1 Engine Room No.2 Wire and Engine Room Main Wire (Engine Compartment Left) 61 (S/D) 62 (H/B) DE1 Instrument Panel Wire and Instrument Panel No.2 Wire (Instrument Panel Center) 63 (S/D) 64 (5–Door) LJ1 Luggage Room No.2 Wire and Floor Wire (Luggage Room Left) 65 (3–Door), : Ground Points Code See Page Ground Points Location 60 (H/B) A1 Left Suspension Tower 61 (S/D) 60 (H/B) B1 Radiator Support Left 61 (S/D) 62 (H/B) D2 Right Kick Panel 63 (S/D) 62 (H/B) D3 Instrument Panel Reinforcement Left 63 (S/D) 64 (5–Door) Right Rear Quarter Panel J1 65 (3–Door) 66 (4–Door) Lower Back Panel Right 64 (5–Door) Left Rear Quarter Panel J2 65 (3–Door) 66 (4–Door) Lower Back Panel Left,

Back–Up Light

(IG) 10A

GAUGE

19 4B 1 CA1 J28(A), J29(B) 9 B Junction Connector 10A9A5A(S/D) 5 A (S/D) 221B(H/B) 1 B (H/B) C22 Back–Up Lamp SW RB RL

R

116A(S/D) 6 A (S/D) 6 B (H/B) 6 B (H/B) 30 4A 3 CA1 22 4B J1 J2RG(M/T) (M/T) GGG(A/T) R R (A/T) C27 Park/Neutral Position SW

R

W–B R Back–Up J3(B), J34(A) Rear Combination Lamp (RH) W–B BR Back–Up J4(B), J35(A) Rear Combination Lamp (LH), : Parts Location Code See Page Code See Page Code See Page 47 (H/B) 55 (5–Door) 57 (3–Door) C22 J4 B J29 B 49 (S/D) 57 (3–Door) 59 (4–Door) 47 (H/B) 55 (5–Door) J34 A 59 (4–Door) C27 49 (S/D) J28 A 57 (3–Door) J35 A 59 (4–Door) 55 (5–Door) 59 (4–Door) J3 B 57 (3–Door) J29 B 55 (5–Door) : Junction Block and Wire Harness Connector Code See Page Junction Block and Wire Harness (Connector Location) 4A 30 Floor Wire and Instrument Panel J/B (Lower Finish Panel) 4B 30 Engine Room Main Wire and Instrument Panel J/B (Lower Finish Panel) : Connector Joining Wire Harness and Wire Harness Code See Page Joining Wire Harness and Wire Harness (Connector Location) 60 (H/B) CA1 Engine Wire and Engine Room Main Wire (Engine Compartment Left) 61 (S/D) : Ground Points Code See Page Ground Points Location 64 (5–Door) Right Rear Quarter Panel J1 65 (3–Door) 66 (4–Door) Lower Back Panel Right 64 (5–Door) Left Rear Quarter Panel J2 65 (3–Door) 66 (4–Door) Lower Back Panel Left,

Stop Light

∗ 1 : S/D LED Type (BAT) ∗ 2 : S/D Bulb Type 10A

STOP

18 4B A13 Stop Lamp SW

O

(S/D)

O

12 4B (H/B) 10 MJ1 12 4A2A(∗1) 1 B (H/B) 1 J28(A), J29(B) 3 B Junction Connector4B1A(∗1) 2 B (H/B) 23A4A1A(S/D) 1 A (S/D) 5 B (H/B) 5 B (H/B) 6 A (S/D) 6 A (S/D) 11 MJ16B(H/B) 6 B (H/B) W–B(H/B) W–B(S/D) W–B J2 J1 J4(B), J35(A) Rear Combination Lamp (LH) W–B W–BVVGBStop J3(B), J34(A) Rear Combination Lamp (RH) W–BOO(S/D) Stop

O

(H/B) W–B (H/B)

O

(∗1) M1(B), J41(A) W–B Center Stop Lamp (∗1) W–B O (∗2) (∗2) J40 Center Stop Lamp, : Parts Location Code See Page Code See Page Code See Page 50 (H/B) 55 (5–Door) J34 A 59 (4–Door) A13 52 (S/D) J28 A 57 (3–Door) J35 A 59 (4–Door) 55 (5–Door) 59 (4–Door) J40 59 (4–Door) J3 B 57 (3–Door) 55 (5–Door) J41 A 59 (4–Door) 55 (5–Door) J29 B 57 (3–Door) 54 (5–Door) J4 B M1 B 57 (3–Door) 59 (4–Door) 56 (3–Door) : Junction Block and Wire Harness Connector Code See Page Junction Block and Wire Harness (Connector Location) 4A 30 Floor Wire and Instrument Panel J/B (Lower Finish Panel) 4B 30 Engine Room Main Wire and Instrument Panel J/B (Lower Finish Panel) : Connector Joining Wire Harness and Wire Harness Code See Page Joining Wire Harness and Wire Harness (Connector Location) 64 (5–Door) MJ1 Back Door No.1 Wire and Floor Wire (Left Rear Quarter Panel) 65 (3–Door) : Ground Points Code See Page Ground Points Location 64 (5–Door) Right Rear Quarter Panel J1 65 (3–Door) 66 (4–Door) Lower Back Panel Right 64 (5–Door) Left Rear Quarter Panel J2 65 (3–Door) 66 (4–Door) Lower Back Panel Left,

Horn

(BAT) 10A

HORN HORN

Relay 7 1A 8 1A 28 4B 17 AA2 18 4E 1 BA18AHO D3(A), V1(B), (C) Spiral Cable2B(S/D) 1 C (H/B) 1 B2 Horn V1(B), (C) Horn Steering Pad SW

SW

W B LGGGG, : Parts Location Code See Page Code See Page Code See Page 46 (H/B) 51 (H/B) B 52 (S/D) B2 D3 A V1 48 (S/D) 53 (S/D) C 50 (H/B) : Junction Block and Wire Harness Connector Code See Page Junction Block and Wire Harness (Connector Location) 1A 25 Engine Room Main Wire and Engine Room J/B (Engine Compartment Left) 4B 30 Engine Room Main Wire and Instrument Panel J/B (Lower Finish Panel) 4E 30 Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel) : Connector Joining Wire Harness and Wire Harness Code See Page Joining Wire Harness and Wire Harness (Connector Location) 62 (H/B) AA2 Engine Room Main Wire and Engine Room Main Wire (Instrument Panel Left) 63 (S/D) 60 (H/B) BA1 Engine Room No.2 Wire and Engine Room Main Wire (Engine Compartment Left) 61 (S/D),

Front Fog Light

D4 Headlamp Dimmer SW Assembly LFG BFG Fog Light SW OFF Front LFG BFG43

Y

D9 FOG Running Light Relay H HI7816 4C 1762D40 Junction 4 4J Connector 16711298RF HU HL B1 T1 RF (H) ED HU HL (ED) ED OFF Flash Tail Low Head High

ED

D4 11 Headlamp Dimmer SW Assembly W–B 12 17 W–B 4E 4E D1 Light Control SWLPO(∗1) (∗1) (∗1) D37 Junction Connector

BR

(∗1) D39 Dimmer SW Junction Connector

GR

(∗1)

P

(∗1) SB W (∗2) (∗2), (BAT) ∗ 1 : w/ Daytime Running Light 15A ∗ 2 : w/o Daytime Running Light FR FOG 9 4M25D46 Front Fog Light Relay13YR7AD27B(H/B) 7 C (S/D) 6 A A24(A), B13(B) Junction Connector2B1B22B10 B9 24 A Fog Lamp (Front LH) Fog Lamp (Front RH) 1 1 D3 B1

V

(H/B) Front ( FogBR S/D) (S/D) R V D1(A), D2(B), D76(C) Combination Meter W–B W–BRRW–B R,

Front Fog Light

: Parts Location Code See Page Code See Page Code See Page 46 (H/B) 51 (H/B) D37 53 (S/D) A24 A D1 A 48 (S/D) 53 (S/D) 51 (H/B) D39 46 (H/B) D2 B 51 (H/B) 53 (S/D) B9 48 (S/D) 51 (H/B) 51 (H/B) D4 D40 46 (H/B) 53 (S/D) 53 (S/D) B10 48 (S/D) 51 (H/B) 51 (H/B) D9 D46 46 (H/B) 53 (S/D) 53 (S/D) B13 B 48 (S/D) D37 51 (H/B) D76 C 53 (S/D) : Junction Block and Wire Harness Connector Code See Page Junction Block and Wire Harness (Connector Location) 4C 4E 30 Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel) 4J 4M 31 : Connector Joining Wire Harness and Wire Harness Code See Page Joining Wire Harness and Wire Harness (Connector Location) 62 (H/B) AD2 Engine Room Main Wire and Instrument Panel Wire (Instrument Panel Left) 63 (S/D) : Ground Points Code See Page Ground Points Location 60 (H/B) B1 Radiator Support Left 61 (S/D) 62 (H/B) D1 Left Kick Panel 63 (S/D) 62 (H/B) D3 Instrument Panel Reinforcement Left 63 (S/D),

Memo

,

Front Fog Light

D4 Headlamp Dimmer SW Assembly LFG BFG Fog Light SW OFF Front LFG BFG43

Y

D9 FOG Running Light Relay H HI7816 4C 1762D40 Junction 4 4J Connector 16711298RF HU HL B1 T1 RF (H) ED HU HL (ED) ED OFF Flash Tail Low Head High

ED

D4 11 Headlamp Dimmer SW Assembly W–B 12 17 W–B 4E 4E D1 Light Control SWLPO(∗1) (∗1) (∗1) D37 Junction Connector

BR

(∗1) D39 Dimmer SW Junction Connector

GR

(∗1)

P

(∗1) SB W (∗2) (∗2), (BAT) ∗ 1 : w/ Daytime Running Light 15A ∗ 2 : w/o Daytime Running Light FR FOG 9 4M25D46 Front Fog Light Relay13YR7AD27B(H/B) 7 C (S/D) 6 A A24(A), B13(B) Junction Connector2B1B22B10 B9 24 A Fog Lamp (Front LH) Fog Lamp (Front RH) 1 1 D3 B1

V

(H/B) Front ( FogBR S/D) (S/D) R V D1(A), D2(B), D76(C) Combination Meter W–B W–BRRW–B R,

Front Fog Light

: Parts Location Code See Page Code See Page Code See Page 46 (H/B) 51 (H/B) D37 53 (S/D) A24 A D1 A 48 (S/D) 53 (S/D) 51 (H/B) D39 46 (H/B) D2 B 51 (H/B) 53 (S/D) B9 48 (S/D) 51 (H/B) 51 (H/B) D4 D40 46 (H/B) 53 (S/D) 53 (S/D) B10 48 (S/D) 51 (H/B) 51 (H/B) D9 D46 46 (H/B) 53 (S/D) 53 (S/D) B13 B 48 (S/D) D37 51 (H/B) D76 C 53 (S/D) : Junction Block and Wire Harness Connector Code See Page Junction Block and Wire Harness (Connector Location) 4C 4E 30 Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel) 4J 4M 31 : Connector Joining Wire Harness and Wire Harness Code See Page Joining Wire Harness and Wire Harness (Connector Location) 62 (H/B) AD2 Engine Room Main Wire and Instrument Panel Wire (Instrument Panel Left) 63 (S/D) : Ground Points Code See Page Ground Points Location 60 (H/B) B1 Radiator Support Left 61 (S/D) 62 (H/B) D1 Left Kick Panel 63 (S/D) 62 (H/B) D3 Instrument Panel Reinforcement Left 63 (S/D),

Memo

,

ABS

(IG) 7. 5A

MET

1 4M1ALED Driver

CPU

CAN Controller CAN I/F2B(H/B) 24 A 20 A 21A2C(S/D) 7 18 11 22

TC

18 AD3 11 224115 12 19 AA2 W 12 4D

G

Park/Neutral Position SW 1 23 4B 15 AD4 16 AD4 27 A 41 A 49 A 73 B 53 B 54 B 55 B 74 B TC CANH CANLPRN2LA1 D3 A21(A), C20(B) Engine Control Module BRAKE (USA) Brake (Canada) W–BVVVA10 Brake Fluid Level Warning SW

BR

P P D15 Data Link Connector3LL

ABS

YGBWWWWRD41 D42 (A/T) Junction Junction Connector Connector R D1(A), D2(B), D76(C) (A/T) Combination Meter

SB

(A/T)

G

(A/T)

V

(A/T), (IG) (BAT) (BAT) (BAT) 10A 10A 30A 50A ECU–IG STOP ABS2/ ABS1/VSC2 VSC12224 4B 18 4B11A13 Stop Lamp SW A11 A7 Speed Sensor Speed Sensor (Front LH) (Front RH) 12 4B21211AA1 8 AA1 7 AA1 21 4B 25 109831 30 1 23 IG1 STP FL+ FL– FR+ FR– +BS +BM A15 Skid Control ECU with Actuator CANL CANH RL– RL+ RR– RR+ GND1 GND25612 11 34 33 2 24 2 AD4 11 AD4 11 AJ1 10 AJ1 9 AJ1 8 AJ1

W G

2 aJ1 1 aJ1 2 ZJ1 1 ZJ1 BR12WBR12Wa1 Z1 Speed Sensor Speed Sensor (Rear LH) (Rear RH) A2 A25 Junction ConnectorWBBB

G

GGBBBRYYGLLPLG LGVWWW–B W–B W–B B B,

ABS

System Outline 1. Speed Sensor Detects the wheel speed of each of four wheels. 2. Skid Control ECU Based on signals from the sensors, it judges the vehicle driving condition and sends the brake control signal to the brake actuator. 3. ABS Warning Light Lights up to alert the driver when the ECU detects a malfunction in the ABS system and stopps the system. 4. Brake Warning Light Lights up simultaneously with the ABS warning light to alert the driver when the ECU detects a malfunction not only in the ABS but also in the EBD. Single light–up of the brake warning light alerts the driver when the ECU detects a malfunction in the brake system. 5. Engine Control Computer Sends signals such as park/neutral position SW, TC switch, etc., to the skid control ECU with actuator. : Parts Location Code See Page Code See Page Code See Page 46 (H/B) A21 A 48 (S/D) D41 53 (S/D) A7 48 (S/D) 46 (H/B) 51 (H/B) A25 D42 46 (H/B) 48 (S/D) 53 (S/D) A10 48 (S/D) 47 (H/B) D76 C 53 (S/D) C20 B 46 (H/B) 49 (S/D) 54 (5–Door) A11 48 (S/D) 51 (H/B) Z1 56 (3–Door) D1 A 50 (H/B) 53 (S/D) 58 (4–Door) A13 52 (S/D) D2 B 51 (H/B) 54 (5–Door) 46 (H/B) 51 (H/B) a1 56 (3–Door) A15 D15 48 (S/D) 53 (S/D) 58 (4–Door) A21 A 46 (H/B) D41 51 (H/B) : Relay Blocks Code See Page Relay Blocks (Relay Block Location) 1 24 Engine Room R/B (Engine Compartment Left) : Junction Block and Wire Harness Connector Code See Page Junction Block and Wire Harness (Connector Location) 4B 30 Engine Room Main Wire and Instrument Panel J/B (Lower Finish Panel) 4D 30 Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel) 4M 31, : Connector Joining Wire Harness and Wire Harness Code See Page Joining Wire Harness and Wire Harness (Connector Location) 62 (H/B) AA1 63 (S/D) Engine Room Main Wire and Engine Room Main Wire (Instrument Panel Left) 62 (H/B) AA2 63 (S/D) 62 (H/B) AD3 63 (S/D) Engine Room Main Wire and Instrument Panel Wire (Instrument Panel Left) 62 (H/B) AD4 63 (S/D) 62 (H/B) AJ1 Engine Room Main Wire and Floor Wire (Instrument Panel Left) 63 (S/D) 64 (5–Door) ZJ1 65 (3–Door) Skid Control Sensor RH Wire and Floor Wire (Quarter Wheel House Panel RH) 66 (4–Door) 64 (5–Door) aJ1 65 (3–Door) Skid Control Sensor LH Wire and Floor Wire (Quarter Wheel House Panel LH) 66 (4–Door) : Ground Points Code See Page Ground Points Location 60 (H/B) A1 61 (S/D) Left Suspension Tower 60 (H/B) A2 61 (S/D) 62 (H/B) D3 Instrument Panel Reinforcement Left 63 (S/D),

Memo

,

SRS

NOTICE: When inspecting or repairing the SRS, perform service in accordance with the following precautionary instructions and the procedure, and precautions in the Repair Manual applicable for the model year. Malfunction symptoms of the SRS are difficult to confirm, so the DTCs become the most important source of information when troubleshooting. When troubleshooting the SRS, always inspect the DTCs before disconnecting the battery. Work must be started more than 90 seconds after the ignition SW is turned to the ”LOCK” position and the negative (–) terminal cable is disconnected from the battery. (The SRS is equipped with a back–up power source so that if work is started within 90 seconds from disconnecting the negative (–) terminal cable of the battery, the SRS may deploy.) When the negative (–) terminal cable is disconnected from the battery, the memory of the clock and audio system will be cleared. So before starting work, make a record of the contents in the audio memory system. When work is finished, reset the audio systems as they were before and adjust the clock. Some vehicles have power tilt steering, power telescopic steering, power seat and power outside rear view mirror which are all equipped with memory function. However, it is not possible to make a record of these memory contents. So when the work is finished, it will be necessary to explain it to your customer, and ask the customer to adjust the features and reset the memory. To avoid erasing the memory in each system, never use a back–up power supply from outside the vehicle. Before repair, remove the airbag sensor if shocks are likely to be applied to the sensor during repair. Do not expose the following parts directly to hot air or flame; Even in cases of a minor collision where the SRS does not deploy, the following parts should be inspected; Never use SRS parts from another vehicle. When replacing parts, replace with new parts. For the purpose of reuse, never disassemble and repair the following parts. If the following parts have been dropped, or have cracks, dents and other defects in their case, bracket, and connector, replace with new one. Use a volt/ohmmeter with high impedance (10 kΩ/V minimum) for troubleshooting electrical circuits of the system. Information labels are attached to the periphery of the SRS components. Follow the instructions of the notice. After work on the SRS is completed, check the SRS warning light. If the vehicle is equipped with a mobile communication system, refer to the precaution in the IN section of the Repair Manual. ∗ Steering wheel pad ∗ Front passenger airbag assembly ∗ Side airbag assembly ∗ Curtain shield airbag assembly ∗ Seat belt pretensioner ∗ Center airbag sensor assembly ∗ Front airbag sensor assembly ∗ Side airbag sensor assembly ∗ Rear airbag sensor assembly,

SRS

(IG) 7. 5A

IGN

16 4E A6 A12 Airbag Sensor Airbag Sensor (Front RH) (Front LH) +SR –SR +SL –SL21211AD1 2 AD1 3 AD1 4 AD1 D16(A), J8(C), J9(B) 21 A Airbag Sensor Assembly Center 29 A 27 A 30 A 28 A IG2 +SR –SR +SL –SL E2 E1 PD+ PD– PP+ PP– P+ P– P2+ P2– 26 A 25A2C1C4B5B4A3A1A2A14 4E 30 4E 1 DQ1 2 DQ1 3 DQ1 4 DQ1 17 4E21212A1A2B1BJ21 J20 Q1(A), Q2(B) Pretensioner Pretensioner Airbag Squib (LH) (RH) (Front Passenger' s Airbag Assembly) D1 W–B B W–B W–B Y–B

Y

Y–BWW

Y

B B Y–R Y–BWWY–G Y Y–B Y–RBBYY–G, J15 J14 Airbag Sensor (Rear LH) Airbag Sensor (Rear RH) BCL+ BCL– BCR+ BCR– 21211212BCL+ BCL– J17 BCR+ BCR– J16 Side Airbag Sensor (LH) Side Airbag Sensor (RH) BBL+ BBL– BBR+ BBR– 4343D16(A), J8(C), J9(B) 8 C 15C8B11 B Airbag Sensor Assembly Center BBD+ BBD– BBP+ BBP– SFP+ SFP– SFD+ SFD– ICP+ ICP– ICD+ ICD– 7B6B9C10C9B10B7C6C2JX1 1 JX1 2 JY1 1 JY121211212X1 Y1 J22 J23 Side Airbag Squib (RH) Side Airbag Squib (LH) Curtain Shield Airbag Curtain Shield Squib (RH) Airbag Squib (LH) Y–B Y–RRRYY Y–BLBY–B Y–B YYYYRBY–BLR

Y

Y–B,

SRS

(IG) (IG) D33 D1 Main Body ECU Combination Meter 7. 5A 10A MET GAUGE CANL CANH 1 4M 15 4S 22 23 LED Driver

CPU

CAN Controller Y (S/D) CAN I/F 1 21 20 24 18 7 D42 Junction Connector 5 16 22 11 Y(H/B) 22 11 D41 Junction Connector 19 8 BR 22 A 13 A CANL CANH D+ D– D2+ D2– 5A6A8A7AD16(A), J8(C), J9(B) Airbag Sensor Assembly Center1A2A4A3AD+ D– D2+ D2– D18(A), W1(B), W2(C) Spiral Cable2B1B2C1CW1(B), W2(C) Airbag Squib (Steering Wheel Pad)

W

Y–B

R Y

Y–R B Y–G Airbag

R W

WWWBYG

BR Y

(H/B), J24(A), U1(B) D77 Occupant Classification ECU Hazard Warning Signal SW Passenger' s Seat Belt/Airbag Indicator (ON/OFF) IG+ P–AB PAON FSR+ FSR– 6 1098A4A

Y

(S/D) D27 Passenger Seat Belt Warning Lamp Passenger' s Seat Belt/Airbag Indicator (ON/OFF) IG+ P–AB PAON65114 4S 3 4E Y(H/B) 32 4E 15 4E W

BR

D16(A), J8(C), J9(B) Airbag Sensor Assembly Center 17 A 23 A 12 B 13 B 16 A P–AB PAON FSP+ FSP– SIL DSP+ DSP– DBE+ DBE– 14 C 13 C 11 C 12C2143LSP+ LSP– LBE+ LBE– J10 Front Seat Inner Belt (Driver' s Side) D3 Y–R

R

(S/D)

Y

(H/B)

Y

B R (H/B)

G

G GR (H/B)

GR

(S/D)

R

GR GRYY

W BR

,

SRS

J24(A), U1(B) Occupant Classification ECU DIA GND BSW BGND SVC1 SIG1 SGD1 SVC3 SIG3 SGD32A3A9A5A11B7B1B5B9B3B7JD221123123RBE+ RBE– SVC1 SIG1 SGD1 SVC3 SIG3 SGD3 J11 U2 U3 12 A Front Seat Inner Belt Occupant Classification Occupant Classification Assembly (Front RH) Sensor (Front LH) Sensor (Rear LH) 20B34S 15 4A W 31 4E 7 4E 17 4E

SIL

D15 Data Link Connector 3 D1LOGGD34(A), D35(B) Junction Connector W–B W–B

O P R SB G GR Y W

, J24(A), U1(B) Occupant Classification ECU (IG) (BAT) 7. 5A 7. 5A IGN ECU–B SVC2 SIG2 SGD2 SVC4 SIG4 SGD4 +B IG 12B8B2B6B10B4B1A7A214D16JD2 1 JD2 25 AA2123123SVC2 SIG2 SGD2 SVC4 SIG4 SGD4

O

30 4B U4 U5 8 D36 Occupant Classification Occupant Classification Sensor (Front RH) Sensor (Rear RH) JunctionConnector 12 4H

P W L O V R BR

V V

O

L L,

SRS

System Outline ∗ The system reaches an ignition judgment to deploy the following device based on the signals received from the front airbag sensor and deceleration sensor. – Driver Airbag – Front Passenger Airbag – Seat Belt Pretensioner ∗ The system reaches an ignition judgment to deploy the following device based on the signals received from the side airbag sensors. – Side Airbags – Curtain Shield Airbags ∗ The dual–stage SRS airbag system has been used for the driver and front passenger airbags. This system controls the optimal airbag inflation by judging the extent of impact, seat position (driver seat) and whether or not the seat belt is fastened(driver seat) and infomation from the Front Passenger Occupant Classification System. ∗ The front passenger occupant classification system judges whether the front passenger seat is occupied by an adult or child (with child seat) or is unoccupied, according to the load applied to the front passenger seat and whether the seat belt is buckled. Based on the results, it restricts the deployment of the front passenger airbag, front passenger side airbag, and front passenger seat belt pretensioner. In addition, the system informs the driver of the result of the judgment through the use of the AIRBAG ON/OFF indicator lights. ∗ The airbag sensor assembly transmits a signal to the engine control module in order to stop the fuel pump. ∗ The Airbag sensor assembly transmits a signal to the main body ECU in order to release the door lock. : Parts Location Code See Page Code See Page Code See Page 46 (H/B) 57 (3–Door) J24 A 59 (4–Door) A6 J10 48 (S/D) 59 (4–Door) 50 (H/B) Q1 A 46 (H/B) 55 (5–Door) 52 (S/D) A12 48 (S/D) J11 57 (3–Door) 50 (H/B) Q2 B 51 (H/B) 59 (4–Door) 52 (S/D) D1 53 (S/D) 55 (5–Door) 54 (5–Door) 51 (H/B) J14 57 (3–Door) U1 B 56 (3–Door) D15 53 (S/D) 59 (4–Door) 58 (4–Door) 51 (H/B) 55 (5–Door) 54 (5–Door) D16 A 53 (S/D) J15 57 (3–Door) U2 56 (3–Door) 51 (H/B) 59 (4–Door) 58 (4–Door) D18 A 53 (S/D) 55 (5–Door) 54 (5–Door) D27 51 (H/B) J16 57 (3–Door) U3 56 (3–Door) 51 (H/B) 59 (4–Door) 58 (4–Door) D33 53 (S/D) 55 (5–Door) 54 (5–Door) 51 (H/B) J17 57 (3–Door) U4 56 (3–Door) D34 A 53 (S/D) 59 (4–Door) 58 (4–Door) 51 (H/B) 55 (5–Door) 54 (5–Door) D35 B 53 (S/D) J20 57 (3–Door) U5 56 (3–Door) 51 (H/B) 59 (4–Door) 58 (4–Door) D36 53 (S/D) 55 (5–Door) 50 (H/B) W1 B 51 (H/B) J21 57 (3–Door) 52 (S/D) D41 53 (S/D) 59 (4–Door) 50 (H/B) W2 C 51 (H/B) 55 (5–Door) 52 (S/D) D42 53 (S/D) J22 57 (3–Door) 54 (5–Door) D77 53 (S/D) 59 (4–Door) X1 56 (3–Door) 50 (H/B) 55 (5–Door) 58 (4–Door) J8 C 52 (S/D) J23 57 (3–Door) 54 (5–Door) 50 (H/B) 59 (4–Door) Y1 56 (3–Door) J9 B 52 (S/D) 55 (5–Door) 58 (4–Door) J24 A J10 55 (5–Door) 57 (3–Door), : Relay Blocks Code See Page Relay Blocks (Relay Block Location) 1 24 Engine Room R/B (Engine Compartment Left) : Junction Block and Wire Harness Connector Code See Page Junction Block and Wire Harness (Connector Location) 4A 30 Floor Wire and Instrument Panel J/B (Lower Finish Panel) 4B 30 Engine Room Main Wire and Instrument Panel J/B (Lower Finish Panel) 4D 4E 30 4H Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel) 4M 4S : Connector Joining Wire Harness and Wire Harness Code See Page Joining Wire Harness and Wire Harness (Connector Location) 62 (H/B) AA2 Engine Room Main Wire and Engine Room Main Wire (Instrument Panel Left) 63 (S/D) 62 (H/B) AD1 Engine Room Main Wire and Instrument Panel Wire (Instrument Panel Left) 63 (S/D) 62 (H/B) DQ1 Instrument Panel Wire and Instrument Panel Wire Assembly (Instrument Panel Right) 63 (S/D) 62 (H/B) JD2 Floor Wire and Instrument Panel Wire (Instrument Panel Left) 63 (S/D) 64 (5–Door) JX1 65 (3–Door) Floor Wire and Seat Airbag RH Wire (Front Seat RH) 66 (4–Door) 64 (5–Door) JY1 65 (3–Door) Floor Wire and Seat Airbag LH Wire (Front Seat LH) 66 (4–Door) : Ground Points Code See Page Ground Points Location 62 (H/B) D1 Left Kick Panel 63 (S/D) 62 (H/B) D3 Instrument Panel Reinforcement Left 63 (S/D),

Seat Belt Warning

(IG) (IG) (IG) D1(A), D2(B), D76(C) Combination Meter 7. 5A 7. 5A 10A IGN MET GAUGE 16 4E 1 4M 15 4S LED Driver

CPU

CAN Controller Y (S/D) CAN I/F1A21 A 20 A 24A9B(H/B) 9 C (S/D)

O

(S/D) 18 7 D42 Junction Connector 22 11 Y(H/B) 22 11 O(H/B) D41 Junction Connector BR 19 8 D16(A), J8(C), J9(B) 21 A 22 A 13 A Airbag Sensor Assembly Center IG2 CANL CANH E2 E1 DSP+ DSP– DBE+ DBE– 26 A 25 A 14 C 13 C 11 C 12 C 14 4E 30 4E214317 4E LSP+ LSP– LBE+ LBE– J10 Front Seat Inner Belt (Driver' s Side) D1 W–B B W–B W–B

B

Driver' s Seat Belt Y–RWWWBYG

Y BR G O

(H/B)

R Y

(H/B), J24(A), U1(B) Occupant Classification ECU D77 FSR+ FSR– Hazard Warning Signal SW8A4APassenger' s Seat Belt/Airbag Indicator (ON/OFF) IG+ PBEW P–AB PAON6810 9

Y

(S/D) D27 Passenger Seat Belt Warning Lamp Passenger' s Seat Belt/Airbag Indicator (ON/OFF) IG+ PBEW P–AB PAON6351

O

(S/D) 14 4S 3 4E Y(H/B) O(H/B) 32 4E 15 4E W

BR

17 A 23 A 12 B 13 B 16 A P–AB PAON FSP+ FSP– SIL D16(A), J8(C), J9(B) Airbag Sensor Assembly Center D3

O

(S/D)

R

(S/D)

Y

(H/B)

O

(H/B) B R (H/B) G GR (H/B)

GR

(S/D) GR GRYY

W BR

,

Seat Belt Warning

J24(A), U1(B) Occupant Classification ECU DIA GND BSW BGND SVC1 SIG1 SGD1 SVC3 SIG3 SGD32A3A9A5A11B7B1B5B9B3B7JD221123123RBE+ RBE– SVC1 SIG1 SGD1 SVC3 SIG3 SGD3 J11 U2 U3 12 A Front Seat Inner Belt Occupant Classification Occupant Classification Assembly (Front RH) Sensor (Front LH) Sensor (Rear LH) 20B34S 15 4A W 31 4E 7 4E 17 4E

SIL

D15 Data Link Connector 3 D1LOGGD34(A), D35(B) Junction Connector W–B W–B

O P R SB G GR Y W

, J24(A), U1(B) Occupant Classification ECU (IG) (BAT) 7. 5A 7. 5A IGN ECU–B SVC2 SIG2 SGD2 SVC4 SIG4 SGD4 +B IG 12B8B2B6B10B4B1A7A214D16JD2 1 JD2 25 AA2123123SVC2 SIG2 SGD2 SVC4 SIG4 SGD4

O

30 4B U4 U5 8 D36 Occupant Classification Occupant Classification Sensor (Front RH) Sensor (Rear RH) JunctionConnector 12 4H

P W L O V R BR

V V

O

L L,

Seat Belt Warning

: Parts Location Code See Page Code See Page Code See Page 51 (H/B) 51 (H/B) J24 A 59 (4–Door) D1 A D42 53 (S/D) 53 (S/D) 54 (5–Door) D2 B 51 (H/B) D76 C 53 (S/D) U1 B 56 (3–Door) 51 (H/B) D77 53 (S/D) 58 (4–Door) D15 53 (S/D) 50 (H/B) 54 (5–Door) J8 C 51 (H/B) 52 (S/D) U2 56 (3–Door) D16 A 53 (S/D) 50 (H/B) 58 (4–Door) J9 B D27 51 (H/B) 52 (S/D) 54 (5–Door) 51 (H/B) 55 (5–Door) U3 56 (3–Door) D34 A 53 (S/D) J10 57 (3–Door) 58 (4–Door) 51 (H/B) 59 (4–Door) 54 (5–Door) D35 B 53 (S/D) 55 (5–Door) U4 56 (3–Door) 51 (H/B) J11 57 (3–Door) 58 (4–Door) D36 53 (S/D) 59 (4–Door) 54 (5–Door) 51 (H/B) 55 (5–Door) U5 56 (3–Door) D41 J24 A 53 (S/D) 57 (3–Door) 58 (4–Door) : Relay Blocks Code See Page Relay Blocks (Relay Block Location) 1 24 Engine Room R/B (Engine Compartment Left) : Junction Block and Wire Harness Connector Code See Page Junction Block and Wire Harness (Connector Location) 4A 30 Floor Wire and Instrument Panel J/B (Lower Finish Panel) 4B 30 Engine Room Main Wire and Instrument Panel J/B (Lower Finish Panel) 4D 4E 30 4H Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel) 4M 4S : Connector Joining Wire Harness and Wire Harness Code See Page Joining Wire Harness and Wire Harness (Connector Location) 62 (H/B) AA2 Engine Room Main Wire and Engine Room Main Wire (Instrument Panel Left) 63 (S/D) 62 (H/B) JD2 Floor Wire and Instrument Panel Wire (Instrument Panel Left) 63 (S/D) : Ground Points Code See Page Ground Points Location 62 (H/B) D1 Left Kick Panel 63 (S/D) 62 (H/B) D3 Instrument Panel Reinforcement Left 63 (S/D),

Memo

,

EPS

(IG) (IG) 7. 5A 10A MET ECU–IG 1 4M 24 4B A25 Junction Connector D1 Combination Meter 1 11 CA2 LED Driver

CPU

C21 CAN Controller 1 Speed Sensor I/F I/F IG+ CAN I/F SI SE 24 21 20 16 173212 CA2 13 CA2 8 4C 8 4D 11 AD3 6 AA2 23 AA2

P G G W

D3 A1 Speedometer

BR W G

P/S

B

G SB

P

PPBBBW–B W–B W–B, (BAT) 50A

EPS

7 4S 1 D15 Data Link Connector 3 SIL TS 7 12 7 4E 3 4S c1(D) Power Steering Torque Sensor8B20B1A13 A

M

6B1A2B11B1C2C6D5D7D8DIG PIG SIL TS M1 M2 TRQV TRQ1 TRQ2 TRQG SPD CANH CANL PGND5B1B7BA19(A), D31(B), b1(C), c1(D) 2 A Power Steering ECU 19A415 D36(A) D42 Junction Junction Connector Connector 20A718

G G W

A3LRD36(A), D37(B) Junction Connector

R W

POLD34(A), D35(B) Junction Connector G SB LG b1(C) Power Steering MotorWW

R B R W Y

W–B B,

EPS

System Outline ∗ In order to reduce driver’s steering force, the assist current is calculated from the torque sensor signal and vehicle speed signal of the meter or CAN communication to output to the motor. ∗ When abnormality occurs in the system, the assist is prohibited by shutting off the power source relay and motor relay in ECU, and the warning light (P/S) in the meter is lit up. : Parts Location Code See Page Code See Page Code See Page 50 (H/B) D15 53 (S/D) 51 (H/B) A19 A D37 B 52 (S/D) 51 (H/B) 53 (S/D) D31 B 46 (H/B) 53 (S/D) 51 (H/B) A25 D42 48 (S/D) 51 (H/B) 53 (S/D) D34 A 47 (H/B) 53 (S/D) 50 (H/B) C21 b1 C 49 (S/D) 51 (H/B) 52 (S/D) D35 B 51 (H/B) 53 (S/D) 50 (H/B) D1 c1 D 53 (S/D) 51 (H/B) 52 (S/D) D36 A D15 51 (H/B) 53 (S/D) : Relay Blocks Code See Page Relay Blocks (Relay Block Location) 1 24 Engine Room R/B (Engine Compartment Left) : Junction Block and Wire Harness Connector Code See Page Junction Block and Wire Harness (Connector Location) 4B 30 Engine Room Main Wire and Instrument Panel J/B (Lower Finish Panel) 4C 4D 30 4E Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel) 4M 4S : Connector Joining Wire Harness and Wire Harness Code See Page Joining Wire Harness and Wire Harness (Connector Location) 62 (H/B) AA2 Engine Room Main Wire and Engine Room Main Wire (Instrument Panel Left) 63 (S/D) 62 (H/B) AD3 Engine Room Main Wire and Instrument Panel Wire (Instrument Panel Left) 63 (S/D) 60 (H/B) CA2 Engine Wire and Engine Room Main Wire (Engine Compartment Left) 61 (S/D) : Ground Points Code See Page Ground Points Location 60 (H/B) A1 Left Suspension Tower 61 (S/D) 62 (H/B) A3 Left Cowl Top Side Panel 63 (S/D) 62 (H/B) D3 Instrument Panel Reinforcement Left 63 (S/D),

Memo

,

Power Window

(BAT) (BAT) (IG) A28 7. 5A Fusible ECU–B Link Block 10A ECU–IG 1 4G

PWR

Relay 25 AA2 1 13 5 20A 20A PWS IG RL RR 30A DOOR DOOR POWER Main Body ECU 2 BECU DCTY 6 26 17 4E 1 4A 19 4A 2 4H 11 4H 30 4B 21 4A

GR SB SB L

D1LLW–B W–B

SB SB L

GR B 120A ALT

L R

J 2 Door Courtesy SW (Front LH), ∗ 1 : w/ Rear Power Window ( ) ( ) ∗ 2 : w/o Rear Power WindowG1 A , B Power Window Master SWBUDDU6A16 A 15A4A3A(∗1) 15 B 16 B 18 B 12 B 10 B (∗2) 2 GD2 11 GD2 10 GD212

M

G4 Power Window Regulator Motor (Front LH) 11 FD2 10 FD2

GR

SB SB SB SB

L

2 FD252L3F1 Power Window SW (Front RH) 4121

M

F4 Power Window Regulator Motor (Front RH) GR GR

L

R UpWWWPPP

G

Down

G R

,

Power Window

∗ 1 : w/ Rear Power Window ( ) ( ) ∗ 2 : w/o Rear Power WindowG1 A , B Power Window Master SWUDUDE12 A 13 A 10 A 18A1A(∗1) 7 B (∗2) 8 GD2 9 GD2 17 GD2 18 GD2 11 JD1 10 JD1 2 JD1 1 JD1 2 IJ1 3 IJ1 2 HJ1 3 HJ1

SB SB

1 IJ1511HJ151SB 3 SB342421212MMI2 H2 Power Window Regulator Power Window Regulator Motor (Rear LH) Motor (Rear RH) 3 5B D1

SB

Y UpRYYYGBBB

B

Down I1 Power Window SW (Rear LH)

SB

Y UpRRRRGGGG

B

Down H1 Power Window SW (Rear RH) W–B, System Outline 1. Manual Up–and–Down Function During IG ON, one step operation upward (Pull) or downward (Push) of the door switch makes the door glass move upward or downward. Manual operation of the power window master switch for each window can control operation of each window remotely from the driver’s seat. The door glass stops at the position when the switch is released. 2. One–Touch Auto Down Function During IG ON, two step operation downward (Push) of the master switch of the driver’s door glass makes the driver’s door glass move automatically downward to the full–open position. The auto operation to either direction can be suspended by one step operation to the opposite side from the operating direction. 3. Power Window Jam Protection Function If a foreign object gets jammed in the window during the manual operation, the door glass automatically goes down by about 50mm (or for about one second). If the door glass opening is less than 200mm after the move, the glass goes down to reach about 200mm of the opening (or for about 5 seconds). 4. Window Lock All the power window operations except driver’s side are disabled when the window lock switch of the power window master switch is pressed on. 5. Fail Mode LED Blinking Self–diagnosis switches it to the fail mode and the indicator light (LED) in the switch knob blinks to inform the user under the following conditions. ∗ When abnormality is found in the hall IC that detects the position, speed and direction of the door glass. ∗ When there is larger difference than the predetermined one between the position information that the hall IC detects and the position information that the power window switch memorizes. : Parts Location Code See Page Code See Page Code See Page 43, 46 (H/B) A 58 (4–Door) H2 58 (4–Door) A28 43, 48 (S/D) 54 (5–Door) 54 (5–Door) G1 I1 54 (5–Door) B 56 (3–Door) 58 (4–Door) F1 56 (3–Door) 58 (4–Door) 54 (5–Door) I2 58 (4–Door) 54 (5–Door) 58 (4–Door) 54 (5–Door) G4 56 (3–Door) 55 (5–Door) F4 56 (3–Door) 58 (4–Door) J2 57 (3–Door) 58 (4–Door) 54 (5–Door) 59 (4–Door) H1 54 (5–Door) 58 (4–Door) G1 A 56 (3–Door) H2 54 (5–Door) : Relay Blocks Code See Page Relay Blocks (Relay Block Location) 1 24 Engine Room R/B (Engine Compartment Left) : Junction Block and Wire Harness Connector Code See Page Junction Block and Wire Harness (Connector Location) 4A 30 Floor Wire and Instrument Panel J/B (Lower Finish Panel) 4B 30 Engine Room Main Wire and Instrument Panel J/B (Lower Finish Panel) 4E 30 Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel) 4G 30 Engine Room Main Wire and Instrument Panel J/B (Lower Finish Panel) 4H 30 Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel) 5B 38 Front Door LH Wire and J/B No.5 (Left Kick Panel),

Power Window

: Connector Joining Wire Harness and Wire Harness Code See Page Joining Wire Harness and Wire Harness (Connector Location) 62 (H/B) AA2 Engine Room Main Wire and Engine Room Main Wire (Instrument Panel Left) 63 (S/D) 62 (H/B) FD2 Front Door RH Wire and Instrument Panel Wire (Right Kick Panel) 63 (S/D) 62 (H/B) GD2 Front Door LH Wire and Instrument Panel Wire (Left Kick Panel) 63 (S/D) 64 (5–Door) HJ1 Rear Door No.1 Wire and Floor Wire (Right Center Pillar) 66 (4–Door) 64 (5–Door) IJ1 Rear Door No.2 Wire and Floor Wire (Left Center Pillar) 66 (4–Door) 62 (H/B) JD1 Floor Wire and Instrument Panel Wire (Instrument Panel Left) 63 (S/D) : Ground Points Code See Page Ground Points Location 62 (H/B) D1 Left Kick Panel 63 (S/D),

Memo

,

Door Lock Control

D33(A) (BAT) (BAT) (IG) (ACC) Main Body ECU 7. 5A 25A 10A 7. 5A ECU–B D/L ECU–IG ACC ACC IG ALTB BECU KSW 2 21546930 4B 7 4D L 25 L AA2 1 5A D1 W–B Y D19 Unlock Warning SW, D33(A) Main Body ECU DCTY GND1 LSWP UL2 L2 ACT– ACT+ 2615A16 143221 4A 17 4E 1 4S 15 4H 16 4H 18 4H 8 4H 17 JD1 9 FD1 8 FD1 7 FD1 20 FD1 10 FD175614LSSR UL L UL L

M E

8 F5 Door Lock Assembly (Front Passenger' s Side) W–B (S/D) W–B (S/D) W–B (H/B) 1 6B 6 6B 3 6A D1 D2

R

J2 Door Courtesy SW (Front LH) W–B W–B (S/D) Unlock W–B DetectionLLUnlockGGBR O LockPPOO,

Door Lock Control

D33(A) Main Body ECU LSWD UL3 ACTD 21 A 14A2AN3 Back Door Lock Assembly

M

1274H 17 4H 3 4A 4 4A 7 MN1 6 MN1 8 MJ1 9 MJ1 J28(A), J29(B) 9 GD1 8 GD1 7 GD1 20 GD1 10 GD18B2BJunction Connector7B1B810914LSSR UL L UL L 11A5A12A6A

M

8 HJ1 9 HJ1 8 IJ1 9 IJ1E41417G5 L UL Unlock Unlock L UL Door Lock Assembly (Driver' s Side) Detection DetectionMMELSSR E LSSR H39696I3 Door Lock Door Lock Assembly Assembly (Rear RH) (Rear LH) 12 HJ1 13 HJ1 12 IJ1 13 IJ1 W–B (S/D) O(S/D) W–B W–B (S/D) (S/D) W–B W–B (H/B) (H/B) W–B Unlock W–B DetectionLLUnlockGYBR BR Lock P SBOWGR GR GRPPPW–B W–B (S/D) (S/D)

L

O O (S/D) (S/D)

Y

W–B W–B SB (S/D) (S/D) O O (S/D) (S/D) GR GR GR B GR (H/B) (H/B) (H/B) PPPBP(H/B) (H/B) (H/B), D33(A) Main Body ECU LSR L1 UL1 24 A 12 10 ∗ 1 : w/ Rear Power Window ∗ 2 : w/o Rear Power Window ∗ 3 : w/ Power Window ∗ 4 : S/D w/o Power Window 10 4C 11 4E 4 4H 5 4H 8 JD2 O(S/D) BR(S/D) 5 GD1 6 GD1 6 FD1 5 FD12A9A(∗1) 23451B9B(∗2) 32LUL L UL

E

464

E

1 A (∗1) 7 B (∗2) D40 Junction Connector O(S/D) W–B (S/D) W–B (H/B) W–B 1 5B 3 5B 4 5B D1OO(S/D) (S/D) Unlock O (S/D) W–B (S/D)

BR

Lock (S/D) F7 Door Lock Control SW (Front Passenger' s Side) Unlock G (H/B) W–B W–B (H/B) (H/B)

BR

Lock (H/B) D30 Door Lock Control SW G1(A), (B) Power Window Master SW BR LG Lock (∗3) W–B (∗3) UnlockOO(∗3) G7 Door Lock Control SW (Driver' s Side) Lock BR (∗4) W–B (∗4)

O

Unlock (∗4),

Door Lock Control

D33(A) Main Body ECU CANL CANH 22 A 23 A 16 5 D42 Junction Connector 22 11 22 11 D41 Junction Connector 19 8 22 A 13 A CANL CANH D16(A), J8(C) Airbag Sensor Assembly Center DSP+ DSP– DBE+ DBE– 14 C 13 C 11 C 12C2143LSP+ LSP– LBE+ LBE– J10 Front Seat Inner Belt (Driver' s Side) Y–RWWW

Y G

RBYR, System Outline 1. Manual Lock & Unlock Function All the doors (Including the back door) are locked or unlocked by operating the door lock control switch (For manual operation) to ’lock’ or ’unlock’ side. 2. Door Key–Linked Lock & Unlock Function All the doors (Including the back door) are locked or unlocked by operating the key plate to ’lock’ or ’unlock’ side after inserting the key plate into driver’s door key cylinder. 3. Key Confinement Prevention Function To prevent the key confinement in the cabin, it controls not to lock the doors with the door lock control switch (For manual operation or for key–linked) or the door lock knob when the key plate is inserted in the ignition key cylinder with the driver’s door open. : Parts Location Code See Page Code See Page Code See Page 51 (H/B) F7 58 (4–Door) 50 (H/B) D16 A J8 C 53 (S/D) 54 (5–Door) 52 (S/D)

A

51 (H/B) G1 58 (4–Door) 55 (5–Door) D19 53 (S/D) B 56 (3–Door) J10 57 (3–Door) D30 51 (H/B) 54 (5–Door) 59 (4–Door) 51 (H/B) G5 56 (3–Door) 55 (5–Door) D33 A 53 (S/D) 58 (4–Door) J28 A 57 (3–Door) D40 51 (H/B) G7 58 (4–Door) 59 (4–Door) 51 (H/B) 54 (5–Door) 55 (5–Door) D41 H3 53 (S/D) 58 (4–Door) J29 B 57 (3–Door) 51 (H/B) 54 (5–Door) 59 (4–Door) D42 I3 53 (S/D) 58 (4–Door) 54 (5–Door) N3 54 (5–Door) 55 (5–Door) 56 (3–Door) F5 56 (3–Door) J2 57 (3–Door) 58 (4–Door) 59 (4–Door) : Relay Blocks Code See Page Relay Blocks (Relay Block Location) 1 24 Engine Room R/B (Engine Compartment Left) : Junction Block and Wire Harness Connector Code See Page Junction Block and Wire Harness (Connector Location) 4A 30 Floor Wire and Instrument Panel J/B (Lower Finish Panel) 4B 30 Engine Room Main Wire and Instrument Panel J/B (Lower Finish Panel) 4C 4D 4E Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel) 4H 4S 31 5A 38 Instrument Panel Wire and J/B No.5 (Left Kick Panel) 5B 38 Front Door LH Wire and J/B No.5 (Left Kick Panel) 6A 40 Instrument Panel Wire and J/B No.6 (Right Kick Panel) 6B 40 Front Door RH Wire and J/B No.6 (Right Kick Panel),

Door Lock Control

: Connector Joining Wire Harness and Wire Harness Code See Page Joining Wire Harness and Wire Harness (Connector Location) 62 (H/B) AA2 Engine Room Main Wire and Engine Room Main Wire (Instrument Panel Left) 63 (S/D) 62 (H/B) FD1 Front Door RH Wire and Instrument Panel Wire (Right Kick Panel) 63 (S/D) 62 (H/B) GD1 Front Door LH Wire and Instrument Panel Wire (Left Kick Panel) 63 (S/D) 64 (5–Door) HJ1 Rear Door No.1 Wire and Floor Wire (Right Center Pillar) 66 (4–Door) 64 (5–Door) IJ1 Rear Door No.2 Wire and Floor Wire (Left Center Pillar) 66 (4–Door) JD1 63 (S/D) Floor Wire and Instrument Panel Wire (Instrument Panel Left) JD2 64 (5–Door) MJ1 Back Door No.1 Wire and Floor Wire (Left Rear Quarter Panel) 65 (3–Door) 64 (5–Door) MN1 Back Door No.1 Wire and Back Door No.2 Wire (Back Door Panel Center) 65 (3–Door) : Ground Points Code See Page Ground Points Location 62 (H/B) D1 Left Kick Panel 63 (S/D) 62 (H/B) D2 Right Kick Panel 63 (S/D),

Memo

,

Wireless Door Lock Control

D33(A) (BAT) (BAT) (IG) (ACC) Main Body ECU 7. 5A 25A 10A 7. 5A ECU–B D/L ECU–IG ACC BCTY(H/B) ACC IG ALTB BECU KSW LGCY(S/D) 2 21546923 30 4B 7 4D 7 4A L 25 L AA26B5B12 MJ1 15 MN1 1 5A D1 N1 W–B Y D19 Unlock Warning SW W–B Courtesy BR BR BR SB (H/B) (H/B) (H/B) (H/B) (H/B) N2 J29(B) Back Door Courtesy SW Junction Connector, D33(A) Main Body ECU DCTY PCTY RRCY LSWP ACT– ACT+ 26 20 225A3221 4A 24 4A 20 4A 5 4A 18 4H 8 4H 9 FD1 20 FD1 10 FD11111714LSSR UL L

M

3 JD2 2 JD2E8F5 Door Lock Assembly (Front Passenger' s Side) 21 20 5 JD2 ∗ 1 : S/D ∗3 ∗ 2 : H/B, S/D Except ∗3 ∗ 3 : Cold Area Spec. , w/ Engine Immobiliser System, w/ ABS, w/ Rear Window Defogger, w/ Door Lock Control, w/ Daytime Running Light, 1 6B w/ Remote Control Mirror, w/ Air Conditioning D2

R

J2 Door Courtesy SW (Front LH)

L

J1 Door Courtesy SW (Front RH) L L (∗1) (∗1)

L

(∗2) J32 Door Courtesy SW (Rear RH) YGG(∗1) (∗1) (∗1) D76 G Combination (∗2) Meter J33 Door Courtesy SW (Rear LH)

Y

(∗1) Unlock W–B DetectionLLPPOO,

Wireless Door Lock Control

D33(A) Main Body ECU LSWD ACTD 21A2AN3 Back Door Lock Assembly

M

1 2 17 4H 3 4A 4 4A 7 MN1 6 MN1 8 MJ1 9 MJ1 J28(A), J29(B) 9 GD1 20 GD1 10 GD18B2BJunction Connector7B1B814LSSR UL L 11A5A12A6A

M

8 HJ1 9 HJ1 8 IJ1 9 IJ1E41417G5 L UL Unlock Unlock L UL Door Lock Assembly Detection Detection (Driver' s Side) MMELSSR E LSSR H39696I3 Door Lock Door Lock Assembly Assembly (Rear RH) (Rear LH) 12 HJ1 13 HJ1 12 IJ1 13 IJ1 O(S/D) W–B(S/D) 1 5B D1 Unlock W–B DetectionLLPSBOWGR GR GRPPPW–B W–B (S/D) (S/D)

L

O O (S/D) (S/D) W–B W–B SB (S/D) (S/D) O O (S/D) (S/D) GR GR GR B GR (H/B) (H/B) (H/B) PPPBP(H/B) (H/B) (H/B), ( ) ∗ 4 : w/ Theft Deterrent SystemD33 A Main Body ECU LSR SRX STX HAZ GND1 ILE 24 A 18 A 19 A 2517

EHW

FLASH Relay 1 4S 17 4E 1 4K 2 4K 8 JD2

L

17 JD1 24 25 BRK+ BRK– 1 D26 Theft Warning ECU32O(S/D) W–B(S/D) D1OO(S/D) (S/D)

P

(∗4)

O

(∗4) W–B W–B (S/D) (S/D) W–B W–B W–B K2 Room Lamp (Center) W–B On Off L

P

Door

P

,

Wireless Door Lock Control

D33(A) Main Body ECU (BAT) 15A

DOME

PRG RDA 17 A 16A213 4B 5 4K 4 4PL1B8A16 JD1 15 JD1 14 JD1325PRG RDA +B

GND

J13 1 Door Control Receiver W–B (H/B) 7 MJ1 8 MN1 N1 J2WWW–BBRR(H/B) (H/B)

L

W–B W–BLLLLD38(A), D39(B) Junction Connector, System Outline 1. Wireless Lock & Unlock Function Pushing the lock button locks all the doors and pushing the unlock button unlocks the all the doors. 2. 30–Second Auto Lock Function If none of the door are opened within 30 seconds after they are unlocked with the unlock button, all the doors are locked automatically again to prevent the doors from being left open. 3. Operation Prohibition Function with the Door Open When one of the doors is ajar or open, the door lock operation through the wireless remote control is prohibited. 4. Repeat Function If a door lock operation has not been confirmed for some reason after the system conducts the lock operation, the system repeats the lock operation after approximately one second. 5. Answer Back Function (Hazard Light Flashing) The hazard light flashes once when locking, and flashes twice when unlocking if the doors are locked/unlocked through the wireless remote control. 6. Key Reminder Function When the key is inserted in the key cylinder, all the operations of the wireless remote control system are prohibited. 7. Illuminating Function When the doors are unlocked with the wireless remote control, the interior lights are lit for approximately 15 seconds if the interior light switch is at ’door’ position. 8. Wireless Security Function The security function is adopted under which the door unlock and the like are controlled only when the wireless receiver checks the encrypted code sent from the transmitter key and identifies it as its own vehicle’s code. : Parts Location Code See Page Code See Page Code See Page 51 (H/B) 56 (3–Door) 57 (3–Door) D19 G5 J28 A 53 (S/D) 58 (4–Door) 59 (4–Door) 51 (H/B) 54 (5–Door) 55 (5–Door) D26 H3 53 (S/D) 58 (4–Door) J29 B 57 (3–Door) 51 (H/B) 54 (5–Door) 59 (4–Door) D33 A I3 53 (S/D) 58 (4–Door) 55 (5–Door) J32 51 (H/B) 55 (5–Door) 59 (4–Door) D38 A 53 (S/D) J1 57 (3–Door) 55 (5–Door) J33 51 (H/B) 59 (4–Door) 59 (4–Door) D39 B 53 (S/D) 55 (5–Door) 54 (5–Door) D76 53 (S/D) J2 57 (3–Door) K2 56 (3–Door) 54 (5–Door) 59 (4–Door) 58 (4–Door) F5 56 (3–Door) 55 (5–Door) 54 (5–Door) N2 58 (4–Door) J13 57 (3–Door) 56 (3–Door) G1 A 54 (5–Door) 59 (4–Door) 54 (5–Door) N3 G5 54 (5–Door) J28 A 55 (5–Door) 56 (3–Door) : Relay Blocks Code See Page Relay Blocks (Relay Block Location) 1 24 Engine Room R/B (Engine Compartment Left),

Wireless Door Lock Control

: Junction Block and Wire Harness Connector Code See Page Junction Block and Wire Harness (Connector Location) 4A 30 Floor Wire and Instrument Panel J/B (Lower Finish Panel) 4B 30 Engine Room Main Wire and Instrument Panel J/B (Lower Finish Panel) 4D 4E 30 Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel) 4H 4K 30 Roof Wire and Instrument Panel J/B (Lower Finish Panel) 4P 31 Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel) 4S 5A 38 Instrument Panel Wire and J/B No.5 (Left Kick Panel) 5B 38 Front Door LH Wire and J/B No.5 (Left Kick Panel) 6B 40 Front Door RH Wire and J/B No.6 (Right Kick Panel) : Connector Joining Wire Harness and Wire Harness Code See Page Joining Wire Harness and Wire Harness (Connector Location) 62 (H/B) AA2 Engine Room Main Wire and Engine Room Main Wire (Instrument Panel Left) 63 (S/D) 62 (H/B) FD1 Front Door RH Wire and Instrument Panel Wire (Right Kick Panel) 63 (S/D) 62 (H/B) GD1 Front Door LH Wire and Instrument Panel Wire (Left Kick Panel) 63 (S/D) 64 (5–Door) HJ1 Rear Door No.1 Wire and Floor Wire (Right Center Pillar) 66 (4–Door) 64 (5–Door) IJ1 Rear Door No.2 Wire and Floor Wire (Left Center Pillar) 66 (4–Door) 62 (H/B) JD1 63 (S/D) Floor Wire and Instrument Panel Wire (Instrument Panel Left) JD2 63 (S/D) 64 (5–Door) MJ1 Back Door No.1 Wire and Floor Wire (Left Rear Quarter Panel) 65 (3–Door) 64 (5–Door) MN1 Back Door No.1 Wire and Back Door No.2 Wire (Back Door Panel Center) 65 (3–Door) : Ground Points Code See Page Ground Points Location 62 (H/B) D1 Left Kick Panel 63 (S/D) 62 (H/B) D2 Right Kick Panel 63 (S/D) 64 (5–Door) Left Rear Quarter Panel J2 65 (3–Door) 66 (4–Door) Lower Back Panel Left 64 (5–Door) N1 Back Door Panel Center 65 (3–Door),

Memo

,

Theft Deterrent

D33(A) (BAT) (BAT) (IG) (ACC) Main Body ECU 7. 5A 25A 10A 7. 5A ECU–B D/L ECU–IG ACC BCTY(H/B) ACC IG ALTB BECU LGCY(S/D) 2 2154623 30 4B 7 4A L 25 L AA26B5B12 MJ1 15 MN13221J2 N1 W–B Courtesy BR (S/D) (S/D) J42 Door Lock Assembly (Luggage) W–B Courtesy BR BR BR SB (H/B) (H/B) (H/B) (H/B) N2 J29(B) Back Door Courtesy SW Junction Connector, D33(A) Main Body ECU DCTY PCTY RRCY HAZ GND1 LSWP UL2 L2 ACT– ACT+ 26 20 22 2515A16 1432

EHW

FLASH Relay 21 4A 24 4A 20 4A 5 4A 17 4E 1 4S 15 4H 16 4H 18 4H 8 4H 17 JD1 9 FD1 8 FD1 7 FD1 20 FD1 10 FD11111756143JD2 2 JD2 LSSR UL L UL L

M

21 20

E

8 F5 Door Lock Assembly (Front Passenger' s Side) 5 JD2 W–B (S/D) W–B ∗ 1 : S/D ∗3 ∗ 2 : H/B, S/D Except ∗3 (H/B) ∗ 3 : Cold Area Spec. , W–B w/ Engine Immobiliser System, w/ ABS, (S/D) w/ Rear Window Defogger, w/ Door Lock Control, w/ Daytime Running Light, 1 6B 3 6A 6 6B w/ Remote Control Mirror, w/ Air Conditioning D1 D2

R

J2 Door Courtesy SW (Front LH)

L

J1 Door Courtesy SW (Front RH) L L (∗1) (∗1)

L

(∗2) J32 Door Courtesy SW (Rear RH) YGG(∗1) (∗1) (∗1) D76 G Combination (∗2) Meter J33 Door Courtesy SW (Rear LH)

Y

(∗1) W–B W–B (S/D) Unlock W–B DetectionLLUnlockGGBR O LockPPOO,

Theft Deterrent

D33(A) Main Body ECU LSWD UL3 ACTD LSR 21 A 14A2A24A74H 17 4H 3 4A 4 4A 8 JD2 J28(A), J29(B) 8B2BJunction Connector 9 GD1 8 GD1 7 GD1 20 GD1 10 GD1 11A5A12A6A8HJ1 9 HJ1 8 IJ1 9 IJ1 8 10914LSSR UL L ULL4141

M

L UL Unlock Unlock L UL Detection DetectionMMEELSSR E LSSR 7 G5 H39696I3 Door Lock Assembly (Driver' s Side) Door Lock Door Lock Assembly Assembly (Rear RH) (Rear LH) 12 HJ1 13 HJ1 12 IJ1 13 IJ1 W–B (S/D) W–B W–B (H/B) (H/B) W–B W–B (S/D) (S/D) W–B Unlock W–B DetectionLLUnlockGYBR BR Lock P SBOWGR GR GRPPPW–B W–B (S/D) (S/D)

L

O O (S/D) (S/D)

Y

W–B W–B SB (S/D) (S/D) O O (S/D) (S/D) GR GRPPOO(S/D) (S/D), D33(A) Main Body ECU HRLY L1 UL13A12 10 (BAT) 10 4C 11 4E 4 4H 5 4H O(S/D) BR(S/D) 5 GD1 6 GD1 6 FD1 5 FD12A9A(∗5) 245231B9B(∗6) 32LUL L UL

E

6442E1A(∗5) 7 B (∗6) 17 4B 3 4J 6 13 D40 Junction Connector 8 11 W–B (H/B) W–B (S/D) W–B ∗ 1 5B 3 5B 4 5B 4 : S/D w/o Power Window ∗ 5 : w/ Rear Power Window ∗ 6 : w/o Rear Power Window ∗ 7 : w/ Power Window D1

LG

Y V GR H–LP/AMT Relay 10A H–LP LH/ H–LP LO LH D30 Door Lock Control SW Unlock G (H/B) W–B W–B (H/B) (H/B)

BR

Lock (H/B) F7 Door Lock Control SW (Front Passenger' s Side) Unlock O (S/D) W–B (S/D)

BR

Lock (S/D) G1(A), (B) Power Window Master SW BR LG Lock (∗7) W–B (∗7) UnlockOO(∗7) G7 Door Lock Control SW (Driver' s Side) Lock BR (∗4) W–B (∗4)

O

Unlock (∗4),

Theft Deterrent

D33(A) Main Body ECU HORN KSW SRX STX PRG RDA 15 9 18 A 19 A 17 A 16 A (BAT) 10A

HORN

28 4B 7 4D 6 4E

HORN

Relay 7 1A 16 JD1 15 JD132PRG RDA J13 Door Control Receiver

O P Y

1 5A D1

LG

W–B Y D19 Unlock Warning SW

Y P O

WWRR, (BAT) (BAT) (IG) 15A 7. 5A 10A DOME ECU–B ECU–IG W–B W–B221174S1A(S/D) 25 AA22B(H/B) 2

L

B 12 MN1 13 4B 30 4B2A(S/D) 11B(H/B) 15 MJ1 5 4P 12 4H 11A8B16 AD5 15 AD5 11 JD2 16 JD29B3B2B11 139415 6 +B1 +B2 IG DSWH SH– LSR(H/B) LUG(S/D) BRK– BRK+ KSW E IND 25 24 7 16 29 D26 G Theft Warning ECU (S/D) D35 Junction Connector O LG (S/D) 222

P

D25 Security Indicator Lamp

Y

1 1 10 D40 Junction Connector 3 6A D2 N1 J2 A1OBL

BR

P (S/D) LPLL(H/B) Y D36(A), D37(B) Junction Connector W–B GR R D37(B) Junction Connector A18(A), (B) Engine Hood Courtesy SW W–B W–B LGWW(H/B) O O W–B A23 Security HornPP(S/D) (S/D) OPP(H/B) (H/B) (H/B) Unlock W–B Detection P (H/B) (H/B) N4 Back Door Position SW Unlock W–B Detection P (S/D) (S/D) J43 Door Lock Assembly (Luggage) W–B,

Theft Deterrent

: Parts Location Code See Page Code See Page Code See Page A 48 (S/D) 54 (5–Door) 55 (5–Door) A18 B 46 (H/B) F5 56 (3–Door) J13 57 (3–Door) 46 (H/B) 58 (4–Door) 59 (4–Door) A23 48 (S/D) F7 58 (4–Door) 55 (5–Door) 51 (H/B) 54 (5–Door) J28 A 57 (3–Door) D19 A 53 (S/D) G1 58 (4–Door) 59 (4–Door) 51 (H/B) B 56 (3–Door) 55 (5–Door) D25 53 (S/D) 54 (5–Door) J29 B 57 (3–Door) 51 (H/B) G5 56 (3–Door) 59 (4–Door) D26 53 (S/D) 58 (4–Door) 55 (5–Door) J32 D30 51 (H/B) G7 58 (4–Door) 59 (4–Door) 51 (H/B) 54 (5–Door) 55 (5–Door) D33 A H3 J33 53 (S/D) 58 (4–Door) 59 (4–Door) D35 53 (S/D) 54 (5–Door) J42 59 (4–Door) I3 51 (H/B) 58 (4–Door) J43 59 (4–Door) D36 A 53 (S/D) 55 (5–Door) 54 (5–Door) N2 51 (H/B) J1 57 (3–Door) 56 (3–Door) D37 B 53 (S/D) 59 (4–Door) 54 (5–Door) N4 51 (H/B) 55 (5–Door) 56 (3–Door) D40 53 (S/D) J2 57 (3–Door) D76 53 (S/D) 59 (4–Door) : Relay Blocks Code See Page Relay Blocks (Relay Block Location) 1 24 Engine Room R/B (Engine Compartment Left) 2 28 Engine Room R/B No.2 (Engine Compartment Right) : Junction Block and Wire Harness Connector Code See Page Junction Block and Wire Harness (Connector Location) 1A 25 Engine Room Main Wire and Engine Room J/B (Engine Compartment Left) 4A 30 Floor Wire and Instrument Panel J/B (Lower Finish Panel) 4B 30 Engine Room Main Wire and Instrument Panel J/B (Lower Finish Panel) 4C 4D 4E 30 4H Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel) 4J 4P 4S 5A 38 Instrument Panel Wire and J/B No.5 (Left Kick Panel) 5B 38 Front Door LH Wire and J/B No.5 (Left Kick Panel) 6A 40 Instrument Panel Wire and J/B No.6 (Right Kick Panel) 6B 40 Front Door RH Wire and J/B No.6 (Right Kick Panel), : Connector Joining Wire Harness and Wire Harness Code See Page Joining Wire Harness and Wire Harness (Connector Location) 62 (H/B) AA2 Engine Room Main Wire and Engine Room Main Wire (Instrument Panel Left) 63 (S/D) 62 (H/B) AD5 Engine Room Main Wire and Instrument Panel Wire (Instrument Panel Left) 63 (S/D) 62 (H/B) FD1 Front Door RH Wire and Instrument Panel Wire (Right Kick Panel) 63 (S/D) 62 (H/B) GD1 Front Door LH Wire and Instrument Panel Wire (Left Kick Panel) 63 (S/D) 64 (5–Door) HJ1 Rear Door No.1 Wire and Floor Wire (Right Center Pillar) 66 (4–Door) 64 (5–Door) IJ1 Rear Door No.2 Wire and Floor Wire (Left Center Pillar) 66 (4–Door) 62 (H/B) JD1 63 (S/D) Floor Wire and Instrument Panel Wire (Instrument Panel Left) 62 (H/B) JD2 63 (S/D) 64 (5–Door) MJ1 Back Door No.1 Wire and Floor Wire (Left Rear Quarter Panel) 65 (3–Door) 64 (5–Door) MN1 Back Door No.1 Wire and Back Door No.2 Wire (Back Door Panel Center) 65 (3–Door) : Ground Points Code See Page Ground Points Location 60 (H/B) A1 Left Suspension Tower 61 (S/D) 62 (H/B) D1 Left Kick Panel 63 (S/D) 62 (H/B) D2 Right Kick Panel 63 (S/D) J2 66 (4–Door) Lower Back Panel Left 64 (5–Door) N1 Back Door Panel Center 65 (3–Door),

Front Wiper and Washer

(IG) 15A

WSH

2 4B

B W L

3Y5AD2 D5(A), D6(B) 1 Windshield Wiper SW Assembly3B4BM+1 +2 2 +B INT1 INT2 +S +1 +2 B1 MIST Washer SW OFF WF EW INT Off LO On 1 AD2

HI

+S INT1 INT2 B1 +B +SWEWiper Relay +S +B WF EW1B2B3A2A

W B

W–BGGL(H/B) L(H/B) A5 A26 Windshield Junction Connector Washer Motor L(S/D)

L Y

Wiper SW

G

W–B, (IG) 20A

WIP

1 4H 36 4B

B W L Y

2 AD2 4 4E 25 4B3512+2 +1 +S B

M E

4 A9 Windshield Wiper Motor 2 4E W–B 17 4E D1 A1 W–B W–B

Y

W–BLLWW

B

,

Front Wiper and Washer

System Outline 1. Intermittent Function When the wiper control switch is turned to INT position, the wiper makes intermittent operation with an interval time of approximately 3.3 seconds. 2. Washer–Linked Function When the washer switch is turned ON for approximately 0.3 seconds or more, the wiper starts a LO operation at the same time as the washer fluid is ejected. When the switch is turned ON for approximately 1.5 seconds or more, the wiper keeps a LO operation for approximately 2.2 seconds after the washer switch is turned OFF, and then stops its operation. : Parts Location Code See Page Code See Page Code See Page 46 (H/B) A9 48 (S/D) D5 A 53 (S/D) A5 48 (S/D) A26 50 (H/B) 51 (H/B) D6 B A9 46 (H/B) D5 A 51 (H/B) 53 (S/D) : Junction Block and Wire Harness Connector Code See Page Junction Block and Wire Harness (Connector Location) 4B 30 Engine Room Main Wire and Instrument Panel J/B (Lower Finish Panel) 4E 30 Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel) 4H : Connector Joining Wire Harness and Wire Harness Code See Page Joining Wire Harness and Wire Harness (Connector Location) 62 (H/B) AD2 Engine Room Main Wire and Instrument Panel Wire (Instrument Panel Left) 63 (S/D) : Ground Points Code See Page Ground Points Location 60 (H/B) A1 Left Suspension Tower 61 (S/D) 62 (H/B) D1 Left Kick Panel 63 (S/D),

Memo

,

Rear Wiper and Washer

(IG) (IG) D5(A), D6(B) Windshield Wiper SW Assembly 15A 15A RR WIP WSH WR +1R EW Wash Off 25 4A 2 4B On On+Washer5B7A2AA26 4 MJ1 Junction Connector 18 JD1 A4 M Rear Washer Motor 6 MJ1 2 MN1 10 AD2 9 MN112N1BLRear Wiper Motor Assembly

M

2 4E 17 4E D1WWW

L

LLLRear Wiper and Washer SW

O

LLLLW–B W–B, : Parts Location Code See Page Code See Page Code See Page A4 46 (H/B) D5 A 51 (H/B) 54 (5–Door) N1 A26 50 (H/B) D6 B 51 (H/B) 56 (3–Door) : Junction Block and Wire Harness Connector Code See Page Junction Block and Wire Harness (Connector Location) 4A 30 Floor Wire and Instrument Panel J/B (Lower Finish Panel) 4B 30 Engine Room Main Wire and Instrument Panel J/B (Lower Finish Panel) 4E 30 Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel) : Connector Joining Wire Harness and Wire Harness Code See Page Joining Wire Harness and Wire Harness (Connector Location) AD2 62 (H/B) Engine Room Main Wire and Instrument Panel Wire (Instrument Panel Left) JD1 62 (H/B) Floor Wire and Instrument Panel Wire (Instrument Panel Left) 64 (5–Door) MJ1 Back Door No.1 Wire and Floor Wire (Left Rear Quarter Panel) 65 (3–Door) 64 (5–Door) MN1 Back Door No.1 Wire and Back Door No.2 Wire (Back Door Panel Center) 65 (3–Door) : Ground Points Code See Page Ground Points Location D1 62 (H/B) Left Kick Panel,

Shift Lock

(ACC) (BAT) (IG) 10A 10A STOP GAUGE 18 4B 2 4P 12 4B 18 4S D22671Shift Lock Control ECU ACC STP IG SLS+ SLS– KLS+ E 12 8 W–B 5 D40 Junction Connector 3 6A D2 D43 Fuse Block Shift Lock Solenoid B 7. 5A ACC2GGBA13 Stop Lamp SW D13 Key Interlock B Solenoid

L

W–B W–B, System Outline The shift lever can be shifted from P range only when the brake pedal is depressed with the ignition key at ON position. : Parts Location Code See Page Code See Page Code See Page 50 (H/B) 51 (H/B) 45, 51 (H/B) A13 D22 D43 52 (S/D) 53 (S/D) 45, 53 (S/D) 51 (H/B) 51 (H/B) D13 D40 53 (S/D) 53 (S/D) : Junction Block and Wire Harness Connector Code See Page Junction Block and Wire Harness (Connector Location) 4B 30 Engine Room Main Wire and Instrument Panel J/B (Lower Finish Panel) 4P 31 Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel) 4S 6A 40 Instrument Panel Wire and J/B No.6 (Right Kick Panel) : Ground Points Code See Page Ground Points Location 62 (H/B) D2 Right Kick Panel 63 (S/D),

Rear Window Defogger

(BAT) (IG) (IG) 30A 7. 5A DEF A/C

DEF

Relay 2 4F 12 4Q 10 4S 15 DE1 12 DE1 20 JD2 E10 Junction Connector E6 Rear Window Defogger SW23RDEF IG+ 1 1 J31 Noise Filter J45 Noise Filter 1 MJ1 Rr DEF E Rear Window Off Defogger SW On

E

1 A (H/B) 1 D (S/D) J44(D), M2(A), O1(B), (C) Rear Window Defogger1B(H/B) 1 C (S/D) 5 7D40 Junction 9 DE1 E10 Connector Junction Connector 11536A O1 D2

B

(H/B) BBBBB(H/B) (H/B) (H/B) B B (S/D) (S/D) W–B W–BBB10A GAUGE W–B W–BPOO, : Parts Location Code See Page Code See Page Code See Page 51 (H/B) E10 52 (S/D) 54 (5–Door) D40 M2 A 53 (S/D) 55 (5–Door) 56 (3–Door) J31 50 (H/B) 57 (3–Door) 54 (5–Door) E6 B 52 (S/D) J44 D 59 (4–Door) O1 56 (3–Door) E10 50 (H/B) J45 59 (4–Door) C 58 (4–Door) : Junction Block and Wire Harness Connector Code See Page Junction Block and Wire Harness (Connector Location) 4F 30 4Q Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel) 4S 6A 40 Instrument Panel Wire and J/B No.6 (Right Kick Panel) : Connector Joining Wire Harness and Wire Harness Code See Page Joining Wire Harness and Wire Harness (Connector Location) 62 (H/B) DE1 Instrument Panel Wire and Instrument Panel No.2 Wire (Instrument Panel Center) 63 (S/D) 62 (H/B) JD2 Floor Wire and Instrument Panel Wire (Instrument Panel Left) 63 (S/D) 64 (5–Door) MJ1 Back Door No.1 Wire and Floor Wire (Left Rear Quarter Panel) 65 (3–Door) : Ground Points Code See Page Ground Points Location 62 (H/B) D2 Right Kick Panel 63 (S/D) 64 (5–Door) Back Door Panel Left O1 65 (3–Door) 66 (4–Door) Right Rear Quarter Panel,

Remote Control Mirror

(ACC) 7. 5A

ACC

6 4S 13 B D34(A), D35(B) Junction Connector 19 A D12 8 Outer Mirror SW

B

7 E MH MV Left Right Left Right HL HR VL VR M+ 5243613 D38 Junction Connector 13 GD1 12 GD1 12 FD1 13 FD1 14 FD1 14 GD13535MH MV MH MVMMMMM+ M+ 4445A D1 W–B SB O LeftWBSB SB Right G2 Outer Rear View Mirror (LH)

SB

SB SB Up GR GRWBBDown F2 Outer Rear View Mirror (RH) Left/ UpWWPRight/ Down Select SW Operation SW W G, : Parts Location Code See Page Code See Page Code See Page 51 (H/B) D35 B 53 (S/D) F2 58 (4–Door) D12 53 (S/D) 51 (H/B) 54 (5–Door) D38 51 (H/B) 53 (S/D) G2 56 (3–Door) D34 A 53 (S/D) 54 (5–Door) 58 (4–Door) F2 D35 B 51 (H/B) 56 (3–Door) : Junction Block and Wire Harness Connector Code See Page Junction Block and Wire Harness (Connector Location) 4S 31 Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel) 5A 38 Instrument Panel Wire and J/B No.5 (Left Kick Panel) : Connector Joining Wire Harness and Wire Harness Code See Page Joining Wire Harness and Wire Harness (Connector Location) 62 (H/B) FD1 Front Door RH Wire and Instrument Panel Wire (Right Kick Panel) 63 (S/D) 62 (H/B) GD1 Front Door LH Wire and Instrument Panel Wire (Left Kick Panel) 63 (S/D) : Ground Points Code See Page Ground Points Location 62 (H/B) D1 Left Kick Panel 63 (S/D),

Cigarette Lighter / Power Outlet

(ACC) 15A

CIG

3 4Q D14 ACC Cigarette Lighter or Power Outlet

E

D40 Junction Connector 6 6A 3 6A D2 W–B W–B (S/D) (S/D) W–B W–B GR (H/B) (H/B), : Parts Location Code See Page Code See Page Code See Page D14 51 (H/B) D14 53 (S/D) D40 51 (H/B) : Junction Block and Wire Harness Connector Code See Page Junction Block and Wire Harness (Connector Location) 4Q 31 Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel) 6A 40 Instrument Panel Wire and J/B No.6 (Right Kick Panel) : Ground Points Code See Page Ground Points Location 62 (H/B) D2 Right Kick Panel 63 (S/D),

Audio System

(IG) (IG) 7. 5A 10A MET ECU–IG 1 4M 24 4B 1 11 CA2 5V IC IG+

CPU

SI SE32I/F I/F 16 17 24 12 CA2 13 CA2 6 AA2 23 AA2 11 AD3

SB

(S/D) D3 A1

SB

(S/D) P B (S/D) (S/D)

BR

(S/D) D1 Combination MeterPPP(S/D) (S/D) (S/D) A25 Junction Connector W–B W–B W–BBBB(S/D) (S/D) (S/D) (S/D) (S/D) (S/D) C21 Speed Sensor, (ACC) (BAT) 7. 5A 15A ACC DOME 14 4D18AD2 D32 Antenna Amplifier

B

D10(A), D11(B), D74(C) 3A4A8ARadio Receiver Assembly ACC B ANT SPD FR– FR+ FL– FL+ GND3C5A1A6A2A7A18 FD1 17 FD1 18 GD1 17 GD1 8 4D 8 4C2121F6 G6 Speaker (Front Door RH) Speaker (Front Door LH)

SB

(S/D) D3GW(S/D) (S/D) D36 Junction ConnectorLYGR GR GRLLVV

B

P P W–B,

Audio System

J39 J38 Speaker (Rear LH) Speaker (Rear RH) 2121J27 J26 Speaker (Rear LH) Speaker (Rear RH) 2121I4 H4 Speaker (Rear LH) Speaker (Rear RH) 21215IJ1 4 IJ1 5 HJ1 4 HJ1 1 JD3 5 JD2 4 JD2 11 JD3 10 JD3 15 JD2 14 JD2 20 JD3YBWR(S/D) (S/D) (S/D) (S/D) 6B2B3B1BRL– RL+ RR– RR+ ALI ARI ASGN AUXI D10(A), D11(B), D74(C) 17 C 15 C 16 C 19 C Radio Receiver Assembly ∗ 1 : H/B 5–Door ∗ 2 : H/B 3–Door1234ALO ARO ASGN AUXO D75 Stereo Jack Adapter

Y

(S/D)

Y

(∗2) YYW(H/B) (∗1) (∗1) BBR(H/B) (∗1) (∗1)

B

(∗2)

B

(S/D)

W

(S/D)

W

(∗2) (Shielded) GWWW(H/B) (∗1) (∗1)

R

RRR(H/B) (∗1) (∗1) R R (∗2)

R

(S/D), : Parts Location Code See Page Code See Page Code See Page A25 48 (S/D) D36 53 (S/D) 56 (3–Door) G6 C21 49 (S/D) 51 (H/B) 58 (4–Door) D74 C D1 53 (S/D) 53 (S/D) H4 54 (5–Door) 51 (H/B) 51 (H/B) I4 54 (5–Door) D10 A D75 53 (S/D) 53 (S/D) J26 57 (3–Door) 51 (H/B) 54 (5–Door) J27 57 (3–Door) D11 B 53 (S/D) F6 56 (3–Door) J38 59 (4–Door) 51 (H/B) 58 (4–Door) J39 59 (4–Door) D32 53 (S/D) G6 54 (5–Door) : Relay Blocks Code See Page Relay Blocks (Relay Block Location) 1 24 Engine Room R/B (Engine Compartment Left) : Junction Block and Wire Harness Connector Code See Page Junction Block and Wire Harness (Connector Location) 4B 30 Engine Room Main Wire and Instrument Panel J/B (Lower Finish Panel) 4C 4D Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel) 4M 31 : Connector Joining Wire Harness and Wire Harness Code See Page Joining Wire Harness and Wire Harness (Connector Location) AA2 63 (S/D) Engine Room Main Wire and Engine Room Main Wire (Instrument Panel Left) 62 (H/B) AD2 63 (S/D) Engine Room Main Wire and Instrument Panel Wire (Instrument Panel Left) AD3 63 (S/D) CA2 61 (S/D) Engine Wire and Engine Room Main Wire (Engine Compartment Left) 62 (H/B) FD1 Front Door RH Wire and Instrument Panel Wire (Right Kick Panel) 63 (S/D) 62 (H/B) GD1 Front Door LH Wire and Instrument Panel Wire (Left Kick Panel) 63 (S/D) HJ1 64 (5–Door) Rear Door No.1 Wire and Floor Wire (Right Center Pillar) IJ1 64 (5–Door) Rear Door No.2 Wire and Floor Wire (Left Center Pillar) JD2 62 (H/B) Floor Wire and Instrument Panel Wire (Instrument Panel Left) JD3 63 (S/D) : Ground Points Code See Page Ground Points Location A1 61 (S/D) Left Suspension Tower 62 (H/B) D3 Instrument Panel Reinforcement Left 63 (S/D),

Combination Meter

(IG) 24 4B D1(A), D2(B), D76(C) Combination Meter 11 CA2 5V IC

CPU

I/F I/F I/F I/F I/F Clock Buzzer SW TRIP Drive SW Monitor3AP11PPAD3 1 4C 6 AA2 W–B 13 4A 12 CA2 13 CA2 23 AA2132OIG+ SI SE C21 Speed Sensor A1 J1BBBBA25 Junction Connector 10A ECU–IGPPW–B (H/B) W–B (H/B)

BR

Gage J5 Fuel Suction Pump and Gage Assembly

V

, (BAT) (IG) 7. 5A 7. 5A ECU–B MET 30 4B 2 4S 1 4M L 25 L AA2 16 B (H/B) D1(A), D2(B), D76(C) 2A1A14 A 16 C (S/D) Combination Meter Display Illumination I/F

CPU

I/F I/F I/F 17 A 16 A 19 C 18 C 17 C 24 A

P

5 11 12 E TX+1 +S ODO/TRIP SW 8 4C Clock SW

PBEW

4D D77 8 Hazard Warning Signal SW 26 4B D36 Junction Connector 22 19

O

(S/D) D3 Tachometer Speedometer (H/B)

L

Radio W Receiver Assembly (S/D) Pointer (H/B) PowerRGSteering

ECU

(H/B) B Dial (H/B) Engine V SBGRControl Module PANEL1 Fuse Tail (Canada)

G GR

(S/D)

R

(S/D)

L

(S/D)

BR

,

Combination Meter

D1(A), D2(B), D76(C) Combination Meter LED Driver

CPU

CAN Controller I/F I/F (H/B) CAN I/F (H/B) 7 A 15 A 21 A 20A9B(H/B) 9 C (S/D)

O

(S/D) 16A3

PBEW

16B28RV TC

G

O W (S/D) ∗ Door( 4) (∗4) D38(A), D39(B) P/S Junction Connector LG GR (S/D) Airbag

ABS Y

D29 Light Control Rheostat MAINT REQD Driver' s Seat Belt Temp. Hot Temp. Cool

W

G Door (∗ ) Graphic3 (∗3) Door ∗ (Front LH)( 3) (∗3) Door ( (∗ ) Front RH)3 (∗3)

O

(H/B) Door ( (∗ ) Luggage)D27 3 (∗3) Passenger Seat Belt Warning Lamp

CRUISE

(∗ P5) (∗5), ∗ 1 : w/ Daytime Running Light ∗ 2 : w/o Daytime Running Light ∗ 3 : S/D w/ Tachometer ∗ 4 : S/D w/o Tachometer, H/B ∗ 5 : S/D A/T D1(A), D2(B), D76(C) Combination Meter LED Driver (S/D) (S/D) 2 B 10B1B(H/B) 2 C 10 C 22 C 20 C 21C1C(S/D) 18 AD3 22 AD311

S

19 AA2

E

GGWWA1 (∗ R5) (∗5) (∗ N5) (∗5) (∗ ) D5 (∗5) ∗ 2( 5) (∗5) V V (∗ L5) (∗5) A10 Brake Fluid Level Warning SW

V

BRAKE (USA) Brake (Canada) W–B Washer W–BWWA22 Water Level Warning SW

Y

Main Body ECU (S/D) Door ( ) Door Courtesy SW G (∗ ) Rear LH 3 (∗3) (Rear LH) (S/D) Door ( (∗ ) Rear RH)Door Courtesy SWL3(∗3) (Rear RH) (S/D) Charge

L

(∗2) Generator

SB

(∗1),

Combination Meter

D1(A), D2(B), D76(C) 14 B 15B8B7B(H/B) Combination Meter 14 C 15C8C7C(S/D) 13 B 12B4B11 B (H/B) 13 C 12C4C11 C (S/D) 19 AD3 6 CA1 18 AA2GGWWHead (USA) Headlamp Dimmer SW L Assembly Oil PressureYY

Y Y

C16 Engine Oil Pressure SW Malfunction Indicator Lamp Engine Control B Module Beam Headlamp Dimmer SW P GR Assembly Headlamps Turn RH

BR

FLASH Relay Turn LH

LG

(S/D) (S/D) Front Fog (H/B) R Front Fog Light Relay, D33 D31 Main Body ECU Power Steering ECU PKB CANH CANL CANL CANH 24 23 227124C D16 Airbag Sensor A21(A), C20(B) Assembly Center Engine Control Module 96 B 97B516 15 4 ETHW THW CANH CANL CANH CANL NE+ NE– 13 22 41 A 49 A 122 B 121B718 22 11 15 AD4 16 AD4 22 11 8 19 4 15 17 6 D41 1 12 Junction Connector 10 DE1 1 DE1 11 AD4 2 AD43265TX– TX+ CANH CANL E8 A15 A/C Amplifier Skid Control ECU with Actuator

G W

C1

Y

D21 Parking Brake SWGRWWWWWWVVYSB D42 Junction Connector

B W

GGLLWWWWLPC2 Crankshaft Position SensorPLBR (Shielded) C19 Engine Coolant Temp. Sensor,

Combination Meter

: Parts Location Code See Page Code See Page Code See Page 46 (H/B) C20 49 (S/D) 51 (H/B) A10 D36 48 (S/D) 47 (H/B) 53 (S/D) C21 46 (H/B) 49 (S/D) 51 (H/B) A15 D38 A 48 (S/D) 51 (H/B) 53 (S/D) D1 A 46 (H/B) 53 (S/D) 51 (H/B) A21 D39 B 48 (S/D) D2 B 51 (H/B) 53 (S/D) 46 (H/B) 51 (H/B) 51 (H/B) A22 D16 D41 48 (S/D) 53 (S/D) 53 (S/D) 46 (H/B) 51 (H/B) 51 (H/B) A25 D21 D42 48 (S/D) 53 (S/D) 53 (S/D) 47 (H/B) D27 51 (H/B) D76 C 53 (S/D) C2 49 (S/D) 51 (H/B) D77 53 (S/D) D29 47 (H/B) 53 (S/D) 50 (H/B) C16 E8 49 (S/D) 51 (H/B) 52 (S/D) D31 47 (H/B) 53 (S/D) 55 (5–Door) C19 49 (S/D) 51 (H/B) J5 57 (3–Door) D33 C20 47 (H/B) 53 (S/D) 59 (4–Door) : Relay Blocks Code See Page Relay Blocks (Relay Block Location) 1 24 Engine Room R/B (Engine Compartment Left) : Junction Block and Wire Harness Connector Code See Page Junction Block and Wire Harness (Connector Location) 4A 30 Floor Wire and Instrument Panel J/B (Lower Finish Panel) 4B 30 Engine Room Main Wire and Instrument Panel J/B (Lower Finish Panel) 4C 4D Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel) 4M 4S : Connector Joining Wire Harness and Wire Harness Code See Page Joining Wire Harness and Wire Harness (Connector Location) 62 (H/B) AA2 Engine Room Main Wire and Engine Room Main Wire (Instrument Panel Left) 63 (S/D) 62 (H/B) AD3 63 (S/D) Engine Room Main Wire and Instrument Panel Wire (Instrument Panel Left) 62 (H/B) AD4 63 (S/D) 60 (H/B) CA1 61 (S/D) Engine Wire and Engine Room Main Wire (Engine Compartment Left) 60 (H/B) CA2 61 (S/D) 62 (H/B) DE1 Instrument Panel Wire and Instrument Panel No.2 Wire (Instrument Panel Center) 63 (S/D), : Ground Points Code See Page Ground Points Location 60 (H/B) A1 Left Suspension Tower 61 (S/D) 60 (H/B) C1 Engine Block Left 61 (S/D) 62 (H/B) D3 Instrument Panel Reinforcement Left 63 (S/D) 64 (5–Door) Right Rear Quarter Panel J1 65 (3–Door) 66 (4–Door) Lower Back Panel Right,

Cooling Fan

(BAT) (IG) 30A 10A RDI ECU–IG 1 24 4B B 17 5 1B 6 1B1123FAN NO. 1 FAN NO. 2 4 Relay Relay1581B 7 1B1113AA2 4 AA2

M LG O

W–B A2 A1 LGLLA8 Cooling Fan MotorBOOLG LGBBA25 LG Junction Connector W–B W–B W–B L A14 Radiator Fan Resistor, E8 A/C Amplifier TX– TX+ SG–1 S5–3 PRE32111610 DE1 1 DE1 9 AE1 4 AE1 3 AE1 1766154513216 AD4 15 AD4 – + PR 2 49 A 41 A 96 B 97 B CANL CANH ETHW THW FAN2 FAN NE+ NE– 22 A 21 A A21(A), C20(B) 122 B 121 B Engine Control Module

LG O

C1 LGWWWWOLLVVD41 Junction ConnectorBBBA25 Junction ConnectorYYGR GR A3 A/C Pressure Sensor BR (Shielded) L P C2 Crankshaft Position SensorPLC19 Engine Coolant Temp. Sensor,

Cooling Fan

: Parts Location Code See Page Code See Page Code See Page 46 (H/B) A21 A 48 (S/D) 47 (H/B) A3 C20 B 48 (S/D) 46 (H/B) 49 (S/D) A25 46 (H/B) 48 (S/D) 51 (H/B) A8 D41 48 (S/D) 47 (H/B) 53 (S/D) C2 46 (H/B) 49 (S/D) 50 (H/B) A14 E8 48 (S/D) 47 (H/B) 52 (S/D) C19 A21 A 46 (H/B) 49 (S/D) : Relay Blocks Code See Page Relay Blocks (Relay Block Location) 1 24 Engine Room R/B (Engine Compartment Left) : Junction Block and Wire Harness Connector Code See Page Junction Block and Wire Harness (Connector Location) 1B 25 Engine Room Main Wire and Engine Room J/B (Engine Compartment Left) 4B 30 Engine Room Main Wire and Instrument Panel J/B (Lower Finish Panel) : Connector Joining Wire Harness and Wire Harness Code See Page Joining Wire Harness and Wire Harness (Connector Location) 62 (H/B) AA2 Engine Room Main Wire and Engine Room Main Wire (Instrument Panel Left) 63 (S/D) 62 (H/B) AD4 Engine Room Main Wire and Instrument Panel Wire (Instrument Panel Left) 63 (S/D) 62 (H/B) AE1 Engine Room Main Wire and Instrument Panel No.2 Wire (Instrument Panel Left) 63 (S/D) 62 (H/B) DE1 Instrument Panel Wire and Instrument Panel No.2 Wire (Instrument Panel Center) 63 (S/D) : Ground Points Code See Page Ground Points Location 60 (H/B) A1 61 (S/D) Left Suspension Tower 60 (H/B) A2 61 (S/D) 60 (H/B) C1 Engine Block Left 61 (S/D),

Memo

,

Air Conditioning

(BAT) (IG) ∗ 1 : w/ PTC Heater ∗ 2 : w/o PTC Heater 40A 10A ∗ 3 : w/ Defroster Mode Detection SW HTR GAUGE ∗ 4 : w/o Defroster Mode Detection SW ∗ 5 : w/ A/C SW ∗ 6 : w/o A/C SW524HTR Relay3114L 17 4E 7 4F 5 4Q 1 ED1 BR 13 DE1 M E4 Blower Motor E3 Blower ResistorL42312BR 1067ELO HI M2 M1 2 ED159

R

W–B D1 D2

L

W–BLLBBE1 Blower SW

G B

W–B W–B W–B E10 Junction Connector R BR, E5 A/C SW (IG) L B 7. 5A A/C Off On 10 4SLBOff On 12 DE1 (∗3 ∗5) (∗3 ∗5) (∗6) LBE243E10 15 Junction Connector 18 16 E6 Rear Window Defogger SW 3 IG+ E8(A), E9(B) 8 A A/C Amplifier 15 A 16 A IG+ A/C LED IG MAX–HOT Off On HEAT B/V SBLW GND SG–2 TE 14 B 14A9A12A4A10 A SG A/CB876

LG

(∗1)

BR

L 12 (∗2) 9 DE1 3 6A D2 Max Hot

SW L

(∗2)

LG

(∗2) YOO

LG

(∗2)

BR

Defroster Mode Detection W–B W–B W–B W–B SW D40 E10 A/C SW Junction Connector Junction Connector E2 A/C Thermistor No. 1LL(∗2) (∗2) E10 V (∗5) Junction Connector L LG (∗3 ∗5) (∗3 ∗5) (∗5) (∗1) (∗4 ∗5) GR P,

Air Conditioning

HRLYM3315 CA1 14 DE1 7 AE1 E8(A), E9(B) A/C Amplifier 23 B 24 B HLS ALT TX+ TX– TAM SG–1 S5–3 PRE2A3A5A11A1A6A1DE1 10 DE1 10 AE1 9 AE1 4 AE1 3 AE1 6 173210 BA1 + PR2415 – 2 1 A3 A/C Pressure Sensor 15 AD4 16 AD4165A25 Junction Connector 122 B 121 B 41 A 49 A 11 BA1 NE+ NE– CANH CANL A21(A), C20(B) Engine Control Module C1 BR (Shielded)

L

C2 Crankshaft Position Sensor

P

LLVVWWWWD41 Junction Connector B5 Ambient Temp. SensorBWWWLG LG LG (∗1) (∗1) (∗1) D40 Junction D33 Connector Main Body ECUBBBBYYPPP(∗1) (∗1) (∗1) C9 Generator GR GR, (BAT) (BAT) ∗ 1 : w/ PTC Heater 40A 30A HTR HTR SUB2 SUB12211W(∗1) R(∗1) 222211252515HTR HTR HTR 2 AE1 5 AE1 SUB2 SUB3 SUB1Relay Relay Relay131323222211W–B 12 B 10 B (∗1) PTC3 PTC2

L

E8(A), E9(B) (∗1) A/C Amplifier312SOL+ PTC1BBB7A9B1AE1 A17 PTC Heater 6 AE1 7 CA1 C8 A/C Compressor 2 CA1 W–B (∗1) A1 W–B W–B W–B LG LG LGRR(∗1) (∗1) V BR O (∗1) (∗1) (∗1) RWW(∗1) (∗1) (∗1) W–B (∗1)

V

(∗1) B R (∗1) W–B (∗1),

Air Conditioning

: Parts Location Code See Page Code See Page Code See Page 46 (H/B) 47 (H/B) 50 (H/B) A3 C9 E3 48 (S/D) 49 (S/D) 52 (S/D) 50 (H/B) 47 (H/B) 50 (H/B) A17 C20 B E4 52 (S/D) 49 (S/D) 52 (S/D) 46 (H/B) 51 (H/B) 50 (H/B) A21 A D33 E5 48 (S/D) 53 (S/D) 52 (S/D) 46 (H/B) 51 (H/B) 50 (H/B) A25 D40 E6 48 (S/D) 53 (S/D) 52 (S/D) 46 (H/B) 51 (H/B) 50 (H/B) B5 D41 E8 A 48 (S/D) 53 (S/D) 52 (S/D) 47 (H/B) 50 (H/B) 50 (H/B) C2 E1 E9 B 49 (S/D) 52 (S/D) 52 (S/D) 47 (H/B) 50 (H/B) 50 (H/B) C8 E2 E10 49 (S/D) 52 (S/D) 52 (S/D) : Relay Blocks Code See Page Relay Blocks (Relay Block Location) 1 24 Engine Room R/B (Engine Compartment Left) 2 28 Engine Room R/B No.2 (Engine Compartment Right) : Junction Block and Wire Harness Connector Code See Page Junction Block and Wire Harness (Connector Location) 4E 30 Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel) 4F 4L 30 Engine Room Main Wire and Instrument Panel J/B (Lower Finish Panel) 4Q 31 Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel) 4S 6A 40 Instrument Panel Wire and J/B No.6 (Right Kick Panel) : Connector Joining Wire Harness and Wire Harness Code See Page Joining Wire Harness and Wire Harness (Connector Location) 62 (H/B) AD4 Engine Room Main Wire and Instrument Panel Wire (Instrument Panel Left) 63 (S/D) 62 (H/B) AE1 Engine Room Main Wire and Instrument Panel No.2 Wire (Instrument Panel Left) 63 (S/D) 60 (H/B) BA1 Engine Room No.2 Wire and Engine Room Main Wire (Engine Compartment Left) 61 (S/D) 60 (H/B) CA1 Engine Wire and Engine Room Main Wire (Engine Compartment Left) 61 (S/D) 62 (H/B) DE1 Instrument Panel Wire and Instrument Panel No.2 Wire (Instrument Panel Center) 63 (S/D) 62 (H/B) ED1 Instrument Panel No.2 Wire and Instrument Panel Wire (Instrument Panel Left) 63 (S/D), : Ground Points Code See Page Ground Points Location 60 (H/B) A1 Left Suspension Tower 61 (S/D) 60 (H/B) C1 Engine Block Left 61 (S/D) 62 (H/B) D1 Left Kick Panel 63 (S/D) 62 (H/B) D2 Right Kick Panel 63 (S/D),

I GROUND POINT

W–B A15 (GND2) Skid Control ECU with Actuator W–B W–B (GND1) (PGND) A19 Power Steering

ECU

A2 A3 W–B 23 W–B 13 W–B W–B AA2 CA2 (SE) C21 A21 (EC) Speed Sensor Engine Control Module W–B W–B 3 A22 (E) 1A EFI Relay Water Level Warning SW W–B 3 1B IG2 Relay W–B 2 W–B CA1 (SOL–) C8 A/C Compressor W–B 6 W–B AD5 (E) D9 Running Light Relay A1 W–B (E) A10 Brake Fluid Level Warning SW W–B (L) A14 Radiator Fan Resistor W–B W–B A2 (E) 2 (L) H–LP/AMT Turn Signal Lamp (H/B) Relay (Front Side LH) W–B W–B A1 (E) (E) A9 Turn Signal Lamp (H/B) Windshield Wiper (Front Side RH) Motor W–B W–B A18 (GND) 1 (–S) HTR SUB1 Engine Hood Courtesy SW Relay W–B W–B A23 (L) 2 (–S) HTR SUB3 Security Horn Relay W–B ST Relay (–S) 1 2 (–S) HTR SUB2 Relay W–B 1 (E) FAN NO. 2 Relay W–B 8 W–B BA1 W–B W–B W–B W–B W–B W–B W–B,

I

D34 Junction Connector B BR76(E02) C20 D3 (ECC) Engine Control Spiral Cable (∗1) Module W–B (GND) C14BR Ignition Coil (∗1) (No. 4)

BR

D15 (SG) Data Link (∗2) W–B W–B (GND) C11Connector 3 Ignition Coil (No. 1)

BR

J25 (MGND) Canister Pump W–B (GND) C12Module Ignition Coil (No. 2) 3 AJ1 6 AD2 W–B (GND) C13 Ignition Coil (No. 3) 5 AA1 13 CA1 ∗ 1 : w/ Cruise Control 14 CA2 ∗ 2 : w/o Cruise Control C1 BR BR C20 (E01) Engine Control Module

BR

(ME01) W–B (E03) W–B (E04)

W

(E1) C2 W–B W–B B1 (E) (E) B11 Turn Signal Lamp (H/B) (H/B) Side Marker Lamp (Front RH) (Front RH) W–B W–B B8 (E) (E) B12 Turn Signal Lamp (H/B) (H/B) Side Marker Lamp (Front LH) (Front LH) W–B W–B B9 (E) (E) B7 Fog Lamp (Front RH) (H/B) Parking Lamp (LH) W–B W–B W–B B10 (E) (E) B3 Fog Lamp (Front LH) (H/B) Parking Lamp (RH) W–B W–B (E) B14 (S/D) (S/D) Turn Signal, Side Marker and Parking Lamp (RH) W–B (E) B15 (S/D) Turn Signal, W–B W–B Side Marker and Parking Lamp (LH) B1 BR BR BR W–B BR BR

BR

(∗1) BR BR (Shielded)

BR B

W–B,

I GROUND POINT

FLASH Relay W–B 28 D4 (E) 4E (GND1) Main Body ECU Headlamp Dimmer SW Assembly W–B 12 (ED) 4E NOISE FILTER W–B W–B 1 K2 (E) 4K IG 1 Relay Room Lamp (Center) W–B K1 (L) PWR Relay Map Lamp W–B 2 D5 (EW) 4E HTR Relay Windshield Wiper Motor 1 W–B 17 W–B 4S JD1 (S/D) (S/D) 30 15 J24W–B W–B W–B D16 (E1) 4E 4A (GND) Occupant Airbag Sensor Classification Assembly Center ECU W–B 14 7 W–B (E2) 4E 4M 17 12 H3W–B 4E HJ1 (E) Door Lock Assembly (S/D) (Rear RH) I3 W–B 12 W–B IJ1 (E) Door Lock Assembly (S/D) (S/D) (Rear LH) W–B 4 G7 (E) 5B Door Lock Control (S/D) SW (Driver Side) W–B W–B 4 D12 (E) 5A Outer Mirror SW W–B (CG) D15 Data Link W–B 1 D19 Connector 3(UN–) 5A Unlock Warning SW W–B 1 G5 (E) 5B Door Lock Assembly (Driver' s Side) W–B 3 G1 (E) 5B Power Window Master SW W–B D1 W–B W–B W–B W–B (S/D),

I

W–B 4 E8 (GND) A/C Amplifier E10 Junction Connector W–B 7 E6 (E) Rear Window Defogger SW 5 W–B D77 (E) Hazard Warning (S/D) 9 DE1 Signal SW W–B W–B W–B D7 (E) (E) D14 Hazard Warning (H/B) (H/B) Cigarette Lighter Signal SW or Power Outlet W–B W–B D13 (KLS–) (E) D25 Key Interlock Solenoid Security Indicator Lamp W–B (GND) D23 Transponder Key ECUW913 W–B D27 (ILL–) (E) D30 Passenger Seat (H/B) (H/B) Door Lock Belt Warning Lamp Control SW W–B 10 12 W–B D26 (E) (E) D22 Theft Warning ECU Shift Lock 11 D40 Control ECU Junction Connector 3 6A54W–B 6A 6A (T1) D4 Headlamp Dimmer SW Assembly W–B26W–B D29 6A 6A (E) D14 Light Control Rheostat (S/D) Cigarette Lighter or Power Outlet W–B W–B11W–B 6A 6B (E) F5 Door Lock Assembly (Front Passenger' s Side) F7 6 Door Lock Control W–B( ) SW (Front E 6B(S/D) Passenger' s Side) W–B 2 W–B W–B ED1 (E) E1 Blower SW W–B (E) E3 Blower Resistor W–B W–B D2 W–B W–B W–B W–B W–B W–B,

I GROUND POINT

W–B W–B J5 (E) (E) N2 Fuel Suction (H/B) Back Door Pump and Courtesy SW Gage Assembly BR W–B W–B (FE) (LSWE) N4 (H/B) (H/B) Back Door Position SW W–B J3 (E) Rear Combination (H/B) N1 Lamp (RH) W–B J34 (E) Rear Combination (S/D) Lamp (RH) J1 W–B (E) J40 (S/D Bulb) Center Stop Lamp W–B (E2) J41 (S/D LED) Center Stop Lamp 8 MN1 W–B (L) J43 (S/D) Door Lock Assembly (Luggage) W–B (E) J42 (S/D) Door Lock Assembly (Luggage) W–B (E) J36 (S/D) License Plate Lamp (RH) W–B (E) J37 (S/D) License Plate Lamp (LH) W–B (E) J35 (S/D) Rear Combination Lamp (LH) W–B (GND) J13 7 MJ1 Door Control Receiver W–B (E) J4 (H/B) Rear Combination Lamp (LH) W–B 11 W–B MJ1 (E) M1 (H/B) (H/B) Center Stop Lamp W–B 9 W–B LJ1 (E) L1 (H/B) (H/B) License Plate Lamp W–B J2 W–B D10 (GND) Radio Receiver Assembly BR B D1 (ET) (E) O1 Combination Meter Rear Window Defogger D3 O1 W–B W–B B W–B (H/B) (H/B) (H/B) W–B W–B W–B W–B W–B W–B (S/D) (S/D) (S/D) (S/D),

I

: Parts Location Code See Page Code See Page Code See Page D34 53 (S/D) D40 53 (S/D) E10 52 (S/D) D40 51 (H/B) E10 50 (H/B) : Relay Blocks Code See Page Relay Blocks (Relay Block Location) 1 24 Engine Room R/B (Engine Compartment Left) 2 28 Engine Room R/B No.2 (Engine Compartment Right) : Junction Block and Wire Harness Connector Code See Page Junction Block and Wire Harness (Connector Location) 1A 25 Engine Room Main Wire and Engine Room J/B (Engine Compartment Left) 1B 4A 30 Floor Wire and Instrument Panel J/B (Lower Finish Panel) 4E 30 Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel) 4K 30 Roof Wire and Instrument Panel J/B (Lower Finish Panel) 4M 31 Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel) 4S 5A 38 Instrument Panel Wire and J/B No.5 (Left Kick Panel) 5B 38 Front Door LH Wire and J/B No.5 (Left Kick Panel) 6A 40 Instrument Panel Wire and J/B No.6 (Right Kick Panel) 6B 40 Front Door RH Wire and J/B No.6 (Right Kick Panel),

I GROUND POINT

: Connector Joining Wire Harness and Wire Harness Code See Page Joining Wire Harness and Wire Harness (Connector Location) 62 (H/B) AA1 63 (S/D) Engine Room Main Wire and Engine Room Main Wire (Instrument Panel Left) 62 (H/B) AA2 63 (S/D) 62 (H/B) AD2 63 (S/D) Engine Room Main Wire and Instrument Panel Wire (Instrument Panel Left) 62 (H/B) AD5 63 (S/D) 62 (H/B) AJ1 Engine Room Main Wire and Floor Wire (Instrument Panel Left) 63 (S/D) 60 (H/B) BA1 Engine Room No.2 Wire and Engine Room Main Wire (Engine Compartment Left) 61 (S/D) 60 (H/B) CA1 61 (S/D) Engine Wire and Engine Room Main Wire (Engine Compartment Left) 60 (H/B) CA2 61 (S/D) 62 (H/B) DE1 Instrument Panel Wire and Instrument Panel No.2 Wire (Instrument Panel Center) 63 (S/D) 62 (H/B) ED1 Instrument Panel No.2 Wire and Instrument Panel Wire (Instrument Panel Left) 63 (S/D) HJ1 66 (4–Door) Rear Door No.1 Wire and Floor Wire (Right Center Pillar) IJ1 66 (4–Door) Rear Door No.2 Wire and Floor Wire (Left Center Pillar) JD1 63 (S/D) Floor Wire and Instrument Panel Wire (Instrument Panel Left) 64 (5–Door) LJ1 Luggage Room No.2 Wire and Floor Wire (Luggage Room Left) 65 (3–Door) 64 (5–Door) MJ1 Back Door No.1 Wire and Floor Wire (Left Rear Quarter Panel) 65 (3–Door) 64 (5–Door) MN1 Back Door No.1 Wire and Back Door No.2 Wire (Back Door Panel Center) 65 (3–Door),

I

: Ground Points Code See Page Ground Points Location 60 (H/B) A1 61 (S/D) Left Suspension Tower 60 (H/B) A2 61 (S/D) 62 (H/B) A3 Left Cowl Top Side Panel 63 (S/D) 60 (H/B) B1 Radiator Support Left 61 (S/D) 60 (H/B) C1 61 (S/D) Engine Block Left 60 (H/B) C2 61 (S/D) 62 (H/B) D1 Left Kick Panel 63 (S/D) 62 (H/B) D2 Right Kick Panel 63 (S/D) 62 (H/B) D3 Instrument Panel Reinforcement Left 63 (S/D) 64 (5–Door) Right Rear Quarter Panel J1 65 (3–Door) 66 (4–Door) Lower Back Panel Right 64 (5–Door) Left Rear Quarter Panel J2 65 (3–Door) 66 (4–Door) Lower Back Panel Left 64 (5–Door) N1 Back Door Panel Center 65 (3–Door) 64 (5–Door) Back Door Panel Left O1 65 (3–Door) 66 (4–Door) Right Rear Quarter Panel,

J POWER SOURCE (Current Flow Chart) The chart below shows the route by which current flows from the battery to each electrical source

(Fusible Link, Circuit Breaker, Fuse, etc.) and other Parts. 10A TAIL 2 Headlamp Dimmer (*2) (*2) SW Assembly D4 (*2) 30A DEF 2 DEF Relay(Point Side) 2 30A ABS2/VSC2 30A HTR SUB1 30A RDI 40A HTR 1 7.5A OBD2 40A HTR SUB2 10A STOP 2 50A ABS1/VSC1 15A FR FOG 50A EPS 25A D/L Battery 120A ALT 3 25A AM1 2 Ignition SW (AM1) D8 T-LP Relay 10A TAIL (*1) (Point Side) 2 2 (*1) 7.5A PANEL1 IG 1 Relay (Point Side) 2 30A POWER PWR Relay (Point Side) 2 20A RL DOOR 2 20A RR DOOR 60A MAIN 3 20A EFI 1 EFI Relay(Point Side) 1 15A AM2 1 10A HORN 1 7.5A ALT-S 7.5A ECU-B 10A ETCS 10A HAZ 10A 1 H-LP LH/H-LP LO LH 10A H-LP RH/H-LP LO RH 15A DOME 30A ST,

J

7.5A PANEL2 2 7.5A PANEL1 2 Example (*2) (*2) 10A ID/UP/MIR HTR 2 Starter S1 Parts Code or Location 7.5A DRL 4 Location Electrical Source 7.5A ACC2 4 7.5A ACC ACC Cut Relay D45 2 15A CIG 7.5A A/C 10A ECU-IG 10A GAUGE 15A RR WIP 15A WSH 25A WIP 10A EFI2 1 IG2 Relay 7.5A IGN (Point Side) 1 2 7.5A MET * 1:H/B, S/D *3 * 2:Except *1 * 3:Cold Area Spec ., w/ Engine Immobiliser System, w/ ABS, w/ Rear Window Defogger, w/ Door Lock Control, w/ Daytime Running Light, w/ Remote Control Mirror, w/ Air Conditioning [LOCATION] 1 : Engine Room R/B and Engine Room J/B (See Page 24) 2 : Instrument Panel J/B (See Page 30) 3 : Fusible Link Block (See Page 42) 4 : Fuse Block (See Page 45),

J POWER SOURCE (Current Flow Chart) Engine Room R/B and Engine Room J/B (See Page 24)

Fuse System Page 7.5A ALT–S Charging 78 Combination Meter 226 Cruise Control 102 Door Lock Control 184 Electronically Controlled Transmission and A/T Indicator 96 Engine Control 84 Engine Immobiliser System 110 Headlight 120 7.5A ECU–B Interior Light 128 Key Reminder and Light Reminder 150 Power Window 178 Seat Belt Warning 168 SRS 159 Theft Deterrent 200 Wireless Door Lock Control 192 10A EFI2 Engine Control 84 10A ETCS Engine Control 84 10A HAZ Turn Signal and Hazard Warning Light 124 Headlight 120 10A H–LP LH/H–LP LO LH Theft Deterrent 200 10A H–LP RH/H–LP LO RH Headlight 120 Horn 144 10A HORN Theft Deterrent 200 Engine Control 84 15A AM2 Ignition 80 Starting 74 Audio System 222 Engine Control 84 15A DOME Interior Light 128 Theft Deterrent 200 Wireless Door Lock Control 192 Cruise Control 102 20A EFI Electronically Controlled Transmission and A/T Indicator 96 Engine Control 84 30A ABS2/VSC2 ABS 154 30A HTR SUB1 Air Conditioning 238 30A RDI Cooling Fan 234 30A ST Starting 74 40A HTR Air Conditioning 238 40A HTR SUB2 Air Conditioning 238 50A ABS1/VSC1 ABS 154 ∗ These are the page numbers of the first page on which the related system is shown.,

J

Fuse System Page 50A EPS EPS 174

Instrument Panel J/B (See Page 30)

Fuse System Page Air Conditioning 238 7.5A A/C Rear Window Defogger 216 Audio System 222 Door Lock Control 184 Interior Light 128 7.5A ACC Remote Control Mirror 218 Theft Deterrent 200 Wireless Door Lock Control 192 Cruise Control 102 Electronically Controlled Transmission and A/T Indicator 96 Engine Control 84 7.5A IGN Engine Immobiliser System 110 Seat Belt Warning 168 SRS 159 ABS 154 Audio System 222 Charging 78 Combination Meter 226 Cruise Control 102 Electronically Controlled Transmission and A/T Indicator 96 7.5A MET Engine Control 84 EPS 174 Interior Light 128 Key Reminder and Light Reminder 150 Seat Belt Warning 168 SRS 159 Taillight and Illumination 134 7.5A OBD2 Data Link Connector 3 112 Key Reminder and Light Reminder 150 7.5A PANEL1 Taillight and Illumination 134 Key Reminder and Light Reminder 150 7.5A PANEL2 Taillight and Illumination 134 ABS 154 Audio System 222 Combination Meter 226 Cooling Fan 234 10A ECU–IG Cruise Control 102 Door Lock Control 184 Electronically Controlled Transmission and A/T Indicator 96 Engine Control 84 ∗ These are the page numbers of the first page on which the related system is shown.,

J POWER SOURCE (Current Flow Chart)

Fuse System Page EPS 174 Headlight 120 10A ECU–IG Power Window 178 Theft Deterrent 200 Wireless Door Lock Control 192 Air Conditioning 238 Back–Up Light 140 Charging 78 Cruise Control 102 Electronically Controlled Transmission and A/T Indicator 96 10A GAUGE Rear Window Defogger 216 Seat Belt Warning 168 Shift Lock 214 SRS 159 Taillight and Illumination 134 Turn Signal and Hazard Warning Light 124 10A ID/UP/MIR HTR Engine Control 84 ABS 154 Cruise Control 102 Electronically Controlled Transmission and A/T Indicator 96 10A STOP Engine Control 84 Shift Lock 214 Stop Light 142 Engine Control 84 10A TAIL Key Reminder and Light Reminder 150 Taillight and Illumination 134 15A CIG Cigarette Lighter/Power Outlet 220 Front Fog Light 146 15A FR FOG Headlight 120 15A RR WIP Rear Wiper and Washer 212 Front Wiper and Washer 208 15A WSH Rear Wiper and Washer 212 20A RL DOOR Power Window 178 20A RR DOOR Power Window 178 20A WIP Front Wiper and Washer 208 Door Lock Control 184 Interior Light 128 25A D/L Theft Deterrent 200 Wireless Door Lock Control 192 Engine Control 84 30A DEF Rear Window Defogger 216 30A POWER Power Window 178 ∗ These are the page numbers of the first page on which the related system is shown.,

J Fusible Link Block (See Page 42)

Fuse System Page Charging 78 Engine Control 84 120A ALT Key Reminder and Light Reminder 150 Power Window 178 Taillight and Illumination 134

Fuse Block (See Page 45)

Fuse System Page 7.5A ACC2 Shift Lock 214 ∗ These are the page numbers of the first page on which the related system is shown.,

K CONNECTOR LIST

A1 A2 A3 A4 A5 Gray Gray Black Gray Black12121231212A6 A7 A8 A9 A10 Yellow Gray Gray1212123121245A11 A12 A13 A14 Yellow Black1212123412A15 A16 A17 A18 Black Black Black1212123345678910 11 121213 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 A19 A20 A21 Gray Black Black123456112345678910 11 12 13 14 15 16 17 18 19 2 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60,

K

A22 A23 A24 Black Black121212345678910 11 12 A25 A26 A27 Black Black12341212345678910 11 12 13 14 15 16 17 18 19 20 21 22 A28 A29 B1 B2 B3 B4 Gray Black Brown11121223112B5 B6 B7 B8 B9 Black Brown Gray Black2312121212B10 B11 B12 B13 Black Gray Gray12121212345678910 11 12 B14 B15 C1 C2 C3 Gray Gray Black Blue121234341212,

K CONNECTOR LIST

C4 C5 C6 C7 C8 Black Gray Black Gray Gray1212121212C9 C10 C11 C12 C13 Black Black Gray Black1212341234123434C14 C15 C16 C17 C18 Gray Black Gray Black Black1234112345612C19 C20 Black Black1212345678910 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 41 42 43 44 45 46 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99100101102103 110111112113114115116117118119120121122123124125126 104105106107108109 C21 C22 C23 C24 C25 Black Gray Dark Gray Black Gray1231212123412C26 C27 C28 C29 Black Gray Gray Black123451234123451256789678910,

K

C30 D1 D2 D312345678910 11 121234567812345613 14 15 16 17 18 19 20 21 22 23 24 9 10 11 12 13 14 15 1678910 11 12 D4 D5 D6 D7 Gray12345678910 11 12 131231234123447510566789D8 D9 D10 D11 Blue123412345678910 115678910345612341212 13 14 15 16 17 18 19 205678D12 D13 D14 D15 Black12123456789101216 15 14 13 12 11 10987654321D16 D18 D19 D20 D21 Yellow Yellow1234567891012121123411 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30,

K CONNECTOR LIST

D22 D23 D24 D25 Black Black1212345612345123456734678910 11 12 13 14 15 16 5 678910 11 12 D26 D27 D28 D29 Dark Gray1212312345678910 11 12 13 14 15344561234516 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36678910 D30 D31 D32 D331234561234567812310 11 1278910 11 1245678913 14 15 16 17 18 19 20 21 22 23 24 25 26 D3412345678910 11 12 13 14 15 16 17 18 19 20 21 22 D3512345678910 11 12 13 14 15 16 17 18 19 20 21 22,

K

D3612345678910 11 12 13 14 15 16 17 18 19 20 21 22 D3712345678910 11 12 13 14 15 16 17 18 19 20 21 22 D3812345678910 11 12 13 14 15 16 17 18 19 20 21 22 D3912345678910 11 12 13 14 15 16 17 18 19 20 21 22 D4012345678910111213,

K CONNECTOR LIST

D4112345678910 11 12 13 14 15 16 17 18 19 20 21 22 D42 D43 D44 Black12123412345678910 11 12 13 14 15 16 17 18 19 20 21 22 D45 D46 D74 D75 Gray Gray33551234567891012341421211 12 13 14 15 16 17 18 19 20 D76 D77 E1123451234512345678910 11 12 13 14 15 16 17 18 19 20678910 11 12 13 14 15 16678910 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 E2 E3 E4 E5 E6 Black Black121212123456783412345678E8 E91234567812345678910 11 12 9 10 11 12 13 14 15 16 13 14 15 16 17 18 19 20 21 22 23 24,

K

E10 F1 F21234521312345678910 115412 13 14 15 16 17 18 19 20 21 22 F4 F5 F6 F71212341123434565678910 2 G1 G2 G4 G51221123433456123456789545678910 10 11 12 13 14 15 16 17 18 G6 G7 H1 H2 H3 H412345121123412341345625678910 2 I1 I2 I3 I4 J1 J21234512111234134565678910 2,

K CONNECTOR LIST

J3 J4 J5 J8 J9 Yellow Yellow123451234512345612345612345678910678910 11 12 13 14 15 11 12 13 14 15 J10 J11 J12 J13 J14 Yellow12121212343412345J15 J16 J17 J20 J21 Yellow Yellow Yellow Yellow Yellow12121212341234J22 J23 J24 J25 J26 Black Black Black Black121212345612345789101112678910 1 J27 J28 J29212345612345678910 11 1278910 11 12 J30 J31 J32 J33 J34 J35 Black121112121234563456,

K

J36 J37 J38 J39 J40 J41 Gray Gray Gray121212212121J42 J43 J44 J45 K1 K2 Black Black Gray1123121212312L1 M1 M2 N1 N2 N3 Gray Black121212121234N4 O1 O1 P1 Q1 Q2 (H/B) Black (S/D) Black Black Orange Black111212341212U1 U2 U3 U4 U5 Gray Black Black Black Black123456123123123123789101112,

K CONNECTOR LIST

V1 V1 W1 W2 X1 Y1 (H/B) (S/D) Orange Black12121212123451267891034Z1 a1 b1 c1 Black Black1212112345678,

Memo

,

K CONNECTOR LIST AA1 AA2

123456789104321123456789987654321109876517 10 11 12 13 14 15 16 25 25 16 15 14 13 12 11 10 17 18 19 20 21 22 23 24 24 23 22 21 20 19 18

AD1 Yellow AD2

2143123451254321678910 10987634

AD3 Black

11 1098765432112345678910 11 22 21 20 19 18 17 16 15 14 13 12 12 13 14 15 16 17 18 19 20 21 22

AD4 Gray AD5 Blue

987654321543211234567891234518 17 16 15 14 13 12 11 10987610 11 12 13 14 15 16 17 186789,

K AE1 AJ1

1234567891043211234567765432110987658910 11 12 13 14 14 13 12 11 1098

BA1 CA1

543211234512219876576534674367898910 11 12 12 11 10981716151413121110 13 14 15 15 14 13

CA2 CP1 Gray

5432112211234598766789

DE1 DQ1 Yellow

4321987654321123412345678918 17 16 15 14 13 12 11 10 10 11 12 13 14 15 16 17 18,

K CONNECTOR LIST ED1 FD1

1221110 10 1 112345678920 209876543211 12 13 14 15 16 17 18 19 19 18 17 16 15 14 13 12

FD2

1289982110 113456717 18 18 177654311 10 12 13 14 15 16 16 15 14 13 12

GD1

1 10 10 1 112345678920 209876543211 12 13 14 15 16 17 18 19 19 18 17 16 15 14 13 12

GD2

1289982110 113456717 18 18 177654311 10 12 13 14 15 16 16 15 14 13 12,

K HJ1 IJ1

5432154321123451234598769876678967891716151413121110 1716151413121110 1011121314151617 1011121314151617

JD1

1289982110 113456717 18 18 177654311 10 12 13 14 15 16 16 15 14 13 12

JD2

1 10 10 1 112345678920 209876543211 12 13 14 15 16 17 18 19 19 18 17 16 15 14 13 12

JD3 JX1 JY1

Yellow Yellow212112345678910 10987654321121211 1213141516171819 20 20 1918171615141312 11,

K CONNECTOR LIST LJ1 MJ1

123455432154321678910 1098761234598766789

MN1 ZJ1 aJ1

54321122112211234598766789,

Memo

,

L PART NUMBER OF CONNECTORS

Code Part Name Part Number Code Part Name Part Number A1 Turn Signal Lamp (Front Side RH) C2 Crankshaft Position Sensor 90980–12028 90980–11162 A2 Turn Signal Lamp (Front Side LH) C3 VSV (Purge) 90980–11156 A3 A/C Pressure Sensor 90980–10845 C4 Fuel Injector (No.1) A4 Rear Washer Motor 90980–11051 C5 Fuel Injector (No.2) 90980–11875 A5 Windshield Washer Motor 90980–11019 C6 Fuel Injector (No.3) A6 Airbag Sensor (Front RH) 90980–12490 C7 Fuel Injector (No.4) A7 Speed Sensor (Front RH) 90980–11003 C8 A/C Compressor 90980–11156 A8 Cooling Fan Motor 90980–10928 C9 Generator 90980–11964 A9 Windshield Wiper Motor 90980–11599 C10 Generator 90980–09373 A10 Brake Fluid Level Warning SW 90980–11207 C11 Ignition Coil (No.1) A11 Speed Sensor (Front LH) 90980–11003 C12 Ignition Coil (No.2) 90980–11885 A12 Airbag Sensor (Front LH) 90980–12490 C13 Ignition Coil (No.3) A13 Stop Lamp SW 90980–11118 C14 Ignition Coil (No.4) A14 Radiator Fan Resistor 90980–10928 C15 Starter 90980–11400 A15 Skid Control ECU with Actuator 90980–12020 C16 Engine Oil Pressure SW 90980–11363 A16 Clutch Start SW 90980–10825 C17 Throttle Body Assembly 90980–11858 A17 PTC Heater 90980–10956 C18 Camshaft Position Sensor 90980–10947 A18 Engine Hood Courtesy SW 90980–11003 C19 Engine Coolant Temp. Sensor 90980–10735 A19 Power Steering ECU 90980–12300 C20 Engine Control Module 90980–12399 A20 Accelerator Position Sensor 90980–12303 C21 Speed Sensor 90980–11143 A21 Engine Control Module 90980–12462 C22 Back–Up Lamp SW 90980–11051 A22 Water Level Warning SW 90980–11068 C23 Air Fuel Ratio Sensor (Bank 1 Sensor 1) 90980–10869 A23 Security Horn 90980–11235 C24 Camshaft Timing Oil Control Valve 90980–11162 A24 Junction Connector 90980–11661 C25 Noise Filter 90980–10843 A25 Junction Connector 90980–11915 C26 Mass Air Flow Meter 90980–11317 A26 Junction Connector 90980–11398 C27 Park/Neutral Position SW 90980–12362 A27 Fusible Link Block 90980–11996 Electronically Controlled TransmissionC28 Solenoid 90980–11658 A28 Fusible Link Block 90980–11775 C29 Speed Sensor (Turbine) 90980–11156 A29 Cruise Control Clutch SW 90980–10906 C30 Fusible Link Block 90980–09223 B1 Turn Signal Lamp (Front RH) 82824–52130 D1 Combination Meter 90980–12200 B2 Horn 90980–10619 D2 Combination Meter 90980–12155 B3 Parking Lamp (RH) 90080–98298 D3 Spiral Cable 90980–12183 B4 Headlamp (RH) 90980–11314 D4 Headlamp Dimmer SW Assembly 90980–12007 B5 Ambient Temp. Sensor 90980–11070 D5 Windshield Wiper SW Assembly 90980–12358 B6 Headlamp (LH) 90980–11314 D6 Windshield Wiper SW Assembly 90980–12359 B7 Parking Lamp (LH) 90080–98298 D7 Hazard Warning Signal SW 82824–21030 B8 Turn Signal Lamp (Front LH) 82824–52130 D8 Ignition SW 90980–11615 B9 Fog Lamp (Front RH) 82824–60460 D9 Running Light Relay 90980–12034 B10 Fog Lamp (Front LH) D10 Radio Receiver Assembly 90980–10997 B11 Side Marker Lamp (Front RH) 90980–11156 D11 Radio Receiver Assembly 90980–10996 B12 Side Marker Lamp (Front LH) D12 Outer Mirror SW 90980–11657 B13 Junction Connector 90980–11661 D13 Key Interlock Solenoid 90980–12063 Turn Signal, Side Marker and Parking Lamp B14 (RH) D14 Cigarette Lighter or Power Outlet 90980–12498 90980–10942 Turn Signal, Side Marker and Parking Lamp D15 Data Link Connector 3 90980–11978 B15 (LH) D16 Airbag Sensor Assembly Center 90980–12391 C1 Starter 90980–09640

Note: Not all of the above part numbers of the connector are established for the supply. PRIUS (EM01V0U)

,

L

Code Part Name Part Number Code Part Name Part Number D18 Spiral Cable 90980–12160 F6 Speaker (Front Door RH) 90980–10935 D19 Unlock Warning SW Door Lock Control SW (Front Passenger’s 90980–12063 F7 Side) 90980–11013 D20 A/T Shift Lever Illumination G1 Power Window Master SW 90980–12122 D21 Parking Brake SW 90980–10871 G2 Outer Rear View Mirror (LH) 90980–12189 D22 Shift Lock Control ECU 90980–12183 G4 Power Window Regulator Motor (Front LH) 90980–10797 D23 Transponder Key ECU 90980–12423 G5 Door Lock Assembly (Driver’s Side) 90980–12226 D24 Transponder Key Amplifier 90980–12092 G6 Speaker (Front Door LH) 90980–10935 D25 Security Indicator Lamp 90980–12056 G7 Door Lock Control SW (Driver’s Side) 90980–11013 D26 Theft Warning ECU 90980–12564 H1 Power Window SW (Rear RH) 90980–10631 D27 Passenger Seat Belt Warning Lamp 90980–12012 H2 Power Window Regulator Motor (Rear RH) 90980–10797 D28 Oxygen Sensor (Bank 1 Sensor 2) 90980–11028 H3 Door Lock Assembly (Rear RH) 90980–12226 D29 Light Control Rheostat 90980–12361 H4 Speaker (Rear RH) 90980–10935 D30 Door Lock Control SW 90980–12550 I1 Power Window SW (Rear LH) 90980–10631 D31 Power Steering ECU 90980–12290 I2 Power Window Regulator Motor (Rear LH) 90980–10797 D32 Antenna Amplifier 90980–10871 I3 Door Lock Assembly (Rear LH) 90980–12226 D33 Main Body ECU 90980–12203 I4 Speaker (Rear LH) 90980–10935 D34 Junction Connector J1 Door Courtesy SW (Front RH) D35 Junction Connector 82824–52010 J2 Door Courtesy SW (Front LH) D36 Junction Connector 90980–12372 J3 Rear Combination Lamp (RH) D37 Junction Connector 90980–10957 J4 Rear Combination Lamp (LH) D38 Junction Connector D39 Junction Connector J5 Fuel Suction Pump and Gage Assembly 90980–11077 J8 Airbag Sensor Assembly Center 90980–12449 D40 Junction Connector 90980–11542 D41 Junction Connector J9 Airbag Sensor Assembly Center 90980–12450 90980–11915 J10 Front Seat Inner Belt (Driver’s Side) D42 Junction Connector 90980–10942 J11 Front Seat Inner Belt Assembly (Front RH) D43 Fuse Block 82610–52010 J12 Room Lamp (Luggage) 90980–11148 D44 Diode (Starter) 90980–10962 J13 Door Control Receiver 90980–12366 D45 ACC Cut Relay 82660–52040 J14 Airbag Sensor (Rear RH) D46 Front Fog Light Relay 82660–52030 90980–12352 J15 Airbag Sensor (Rear LH) D74 Radio Receiver Assembly 90980–12259 J16 Side Airbag Sensor (RH) D75 Stereo Jack Adapter 82824–21030 90980–12225 J17 Side Airbag Sensor (LH) D76 Combination Meter 90980–12557 J20 Pretensioner (RH) D77 Hazard Warning Signal SW 90980–12423 90980–12253 J21 Pretensioner (LH) E1 Blower SW 90980–10993 J22 Curtain Shield Airbag Squib (RH) E2 A/C Thermistor No.1 90980–11918 90980–12575 J23 Curtain Shield Airbag Squib (LH) E3 Blower Resistor 90980–11136 J24 Occupant Classification ECU 90980–12356 E4 Blower Motor 90980–10916 J25 Canister Pump Module 90980–12380 E5 A/C SW 90980–12550 J26 Speaker (Rear RH) E6 Rear Window Defogger SW 90980–12217 90980–10935 J27 Speaker (Rear LH) E8 A/C Amplifier 90980–12155 J28 Junction Connector E9 A/C Amplifier 90980–12200 90980–11661 J29 Junction Connector E10 Junction Connector 90980–11915 J30 Diode (Room Lamp) 90980–10962 F1 Power Window SW (Front RH) 90980–10789 J31 Noise Filter 90980–10916 F2 Outer Rear View Mirror (RH) 90980–12189 J32 Door Courtesy SW (Rear RH) F4 Power Window Regulator Motor (Front RH) 90980–10797 82824–52010 J33 Door Courtesy SW (Rear LH) Door Lock Assembly (Front Passenger’s F5 Side) 90980–12226

PRIUS (EM01V0U)

,

L PART NUMBER OF CONNECTORS

Code Part Name Part Number Code Part Name Part Number J34 Rear Combination Lamp (RH) Airbag Squib (Front Passenger’s Airbag 82824–52050 Q2 Assembly) 90980–12575 J35 Rear Combination Lamp (LH) U1 Occupant Classification ECU 90980–12357 J36 License Plate Lamp (RH) 90980–11148 U2 Occupant Classification Sensor (Front LH) J37 License Plate Lamp (LH) U3 Occupant Classification Sensor (Rear LH) J38 Speaker (Rear RH) 90980–12353 90980–11299 U4 Occupant Classification Sensor (Front RH) J39 Speaker (Rear LH) U5 Occupant Classification Sensor (Rear RH) J40 High Mounted Stop Light 90980–11148 Cruise Control SW (S/D) 90980–12360 J41 High Mounted Stop Light 90980–11967 Spiral Cable (H/B) 90980–12361 J42 Door Lock Assembly (Luggage) 90980–10908 V1 Spiral Cable (S/D) 90980–12360 J43 Door Lock Assembly (Luggage) 90980–11212 Steering Pad SW (H/B) 90980–12361 J44 Rear Window Defogger 90980–10913 Steering Pad SW (S/D) 90980–12360 J45 Noise Filter 90980–10916 Airbag Squib (Steering Wheel Pad) K1 Map Lamp 90980–11212 W1 90980–12224 Spiral Cable K2 Room Lamp (Center) – Airbag Squib (Steering Wheel Pad) L1 License Plate Lamp 90980–11162 W2 90980–12219 Spiral Cable M1 Center Stop Lamp 90980–10860 X1 Side Airbag Squib (RH) M2 Rear Window Defogger 90980–11853 90980–12452 Y1 Side Airbag Squib (LH) N1 Rear Wiper Motor Assembly 90980–10860 Z1 Speed Sensor (Rear RH) N2 Back Door Courtesy SW 90980–10795 90980–12416 a1 Speed Sensor (Rear LH) N3 Back Door Lock Assembly 90980–10825 Power Steering ECU N4 Back Door Position SW 90980–11150 b1 90980–12299 Power Steering Motor Rear Window Defogger (H/B) 90980–11853 O1 Power Steering ECU Rear Window Defogger (S/D) 90980–10914 c1 90980–12221 Power Steering Torque Sensor P1 Knock Control Sensor (Bank 1) 90980–11875 Airbag Squib (Front Passenger’s Airbag Q1 Assembly) 90980–12576

Note: Not all of the above part numbers of the connector are established for the supply. PRIUS (EM01V0U)

,

Memo

, * The system shown here is an EXAMPLE ONLY. It is different to the

HOW TO READ THIS SECTION actual circuit shown in the wiring diagram section.

[A]

S ta rtingEngineContro l

1234B- R B- R ACC [M] W 4 AM1 IG1 A11 1 (BAT) Heated Oxygen Sensor ST1 1 B- W 7. 5A 15A IGN EFI 8 AM2 IG2 7 B- R [L] 2 2 ST2 2 B- L231(2L- T) 2 2 [B] GR A

A 6

Ignition SW R- Y R- Y B- L B

B C

[E] 1134[H] W EFI MAIN (2L- T) [C] 7 BA3 Relay 12 BA1 [J] 121A1B1122A40(A), A41(B) [I] Starter Relay Y- R 21 Y- R Y- R22BA32A2BD2373C [F] 6 AB384[G] +B OX11615 3C 1 B- W (2L- T) B- R B- R B- R FP E125AD2 [D] 131A222216 AD1B1BM17 BA31111

B38(A), B39(B)

Starter

M

Battery W- R W- R W- R W- R

E

1 W- R W- R

F

[K] A1 A1 A3 B1 B 100A ALT 40A AM1 W 30A AM2 W- R W- R B- W (2L- T) W- B B- L (2L- T) (2L- T) B- W B- W B- W B- W B- W (22R- E) (22R- E) Emission ECU B- W <9- 8> B- R W- B W- B A37 Fuel Pump W- B R- G R- G R- G Y- R Y- R R- Y R- Y W- B B- W A19 R- G Circuit Opening Relay B9 Injection No. 1 W- R B- R B- R B- R B- R B11 Injection No. 2 W- R B- R B10 Injection No. 3 W- R B- R B12 Injection No. 4 W- R B- R B1 Data Link Connector 1 (Shielded) R- G R- G Y- R Y- R BRBB

BR M OVERALL ELECTRICAL WIRING DIAGRAM YARIS (EM01V0U)

, [A] : System Title [F] : Junction Block (The number in the circle is the J/B No. [B] : Indicates the wiring color. and the connector code is shown beside it). Junction Blocks are shaded to clearly separate them Wire colors are indicated by an alphabetical code. from other parts. B = Black W = White BR = Brown L = Blue V = Violet SB = Sky Blue Example: R = Red G = Green LG = Light Green 3C indicates that P = Pink Y = Yellow GR = Gray it is inside Junction Block O = Orange No.3 The first letter indicates the basic wire color and the second letter indicates the color of the stripe. Example: L – Y [G] : Indicates related system. [H] : Indicates the wiring harness and wiring harness connector. The wiring harness with maleLYterminal is shown with arrows ( ). (Blue) (Yellow) Outside numerals are pin numbers. [C] : The position of the parts is the same as shown in the wiring diagram and wire routing. [D] : Indicates the pin number of the connector. The numbering system is different for female and male connectors. Example: Numbered in other Numbered in other Female Male ( ) from upper left to from upper right to lower right lower left [I] : ( ) is used to indicate different wiring and connector, etc. when the vehicle model, engine type, or specification is different. [J] : Indicates a shielded cable. The numbering system for the overall wiring diagram is the same as above [K] : Indicates a ground point. [E] : Indicates a Relay Block. No shading is used and only the Relay Block No. is shown to distinguish [L] : The same code occurring on the next page indicates it from the J/B. that the wire harness is continuous. Example: Indicates Relay Block No.1 [M] : Indicates the ignition key position(s) when the power is supplied to the fuse(s).

M YARIS (EM01V0U)

,

SYSTEM INDEX SYSTEMS LOCATION SYSTEMS LOCATION

ABS .17–1 Illumination .12–1 Air Conditioning .29–1 Interior Light .11–1 Audio System .26–1 Key Reminder .16–1 Back–Up Light .13–1 Light Reminder .16–1 Charging .3–1 Multiplex Communication System (CAN) .8–1 Cigarette Lighter .24–3 Power Outlet .24–3 Combination Meter .27–1 Power Source .1–1 Cooling Fan .28–1 Power Window .20–1 Cruise Control .5–16 Rear Window Defogger .25–1 Data Link Connector 3 .7–1 Rear Wiper and Washer .23–1 Door Lock Control .21–1 Remote Control Mirror .24–1 Electronically Controlled Transmission and A/T Indicator .5–17 Seat Belt Warning .18–7 Engine Control .5–1 Shift Lock .23–3 Engine Immobiliser System .6–1 SRS .18–1 EPS .19–1 Starting .2–1 Front Fog Light .15–1 Stop Light .14–1 Front Wiper and Washer .22–1 Taillight .12–1 Headlight .9–1 Theft Deterrent .21–10 Horn .25–3 Turn Signal and Hazard Warning Light .10–1 Ignition .4–1 Wireless Door Lock Control .21–9

M OVERALL ELECTRICAL WIRING DIAGRAM YARIS (EM01V0U)

, 1 YARIS (Cont. next page)

PowerSourc e

1234

B A

EFI Relay 40A HTR SUB2 30A ABS2/VSC2 1 20A EFI 10A EFI2B12121E124B4B121A AA1 1 50A EPS 30A HTR SUB1 10A HORN12121250A ABS1/VSC1 30A RDI 15A AM21212W1121C 40A HTR

Y

12BACC2W

C

Y 4 AM1 IG11G

D

7. 5A ALT–S112GR 5 AM2 IG26P1D 3 1B 2 1B 4 1B 1 1B ST2 7 15A DOME121D8 Ignition SW 30A ST1214 AA21C1A1B2B7. 5A ECU–B1210A ETCS 5 AD4 3 AD2 4 AD21210A HAZ12W

E

10A H–LP LH/H–LP LO LH Battery12L

F

10A H–LP RH/H–LP LO RH12A1 Charging System <3–1> 120A ALT B

B

60A MAIN W A27(B), A28(A), C30(C) W Fusible Link Block

L

W–BPPPWWIG2 Relay GR GR Starting System <2–3>

M OVERALL ELECTRICAL WIRING DIAGRAM YARIS (EM01V0U)

, 1 YARIS (Cont' d)

PowerSourc e

5678T–LP RelayBB1(∗1) (∗1) (∗1) 10A TAIL A 4G ∗ 1 : H/B, S/D ∗3 ∗ 2 : Except ∗1 (∗1) (∗1) (∗1) 7. 5A PANEL1 ∗ 3 : Cold Area Spec. , w/ Engine Immobiliser System, w/ ABS, w/ Rear Window Defogger, 30A DEF DEF Relay w/ Door Lock Control, 1 2 10A ID/UP/MIR HTR w/ Daytime Running Light, w/ Remote Control Mirror, w/ Air Conditioning 15A FR FOG 7. 5A OBD2 25A D/LYY1B4F (∗2) 10A TAIL (∗2) 4 W 4M (∗2) 10A STOP 13 30A POWER W PWR Relay C B112GG3D4F B1 T1 25A AM1 Light OFF 20A RL DOOR Control SW Tail Noise Filter 20A RR DOOR Head 1 7. 5A ACC22BT1 D43 IG 1 Relay5310A ECU–IGFuse Block G (∗2) 2 1 25A WIP 8 4S2315A WSH 10 7. 5A PANEL2 7. 5A PANEL1 4E 15A CIG 10A GAUGE 13 4B14L57. 5A ACC 4F 15A RR WIP 7. 5A A/C 7. 5A IGN 18 AD4WW47. 5A MET E 4F 17 4E 7 4M

L F

1 6A D1 D2LPEngine ControlGGPModule<5–7>

W

D45 W ACC Cut Relay W–B W–B D4 Headlamp Dimmer SW Assembly

M YARIS (EM01V0U)

, 2 YARIS

S ta rtin g ∗ 1 : A/T

∗ 2 : M/T1234(BAT) (BAT) 30A 15A ST AM2 5 AM2 IG2B22ST27B111B D8 Ignition SW14AD2 9 AD45214A1STSW D44 ST Diode (Starter) Relay GR STA STAR23148 A 52B1118CA1 A25 Junction Connector 13 14 12 12 AA2 10 CA1 9 CA1 5 AA2 1 AD4751D36 Junction Connector1BA65BLC27 2 Park/NeutralMPPosition SW 10 AD4

N

C1(A), C15(B) Starter 4 10 CA2 13 AA2 Battery GR21Y(∗1) Y 3 A25 Junction Connector AI (∗2)

B

VVWW–B W–BYB(∗2) (∗2) A16 Clutch Start SWWWB(∗1) (∗1) GR BR (∗1)

GR

A21(A), C20(B) Engine Control Module

BR

Y GROOOOBSB B

M OVERALL ELECTRICAL WIRING DIAGRAM YARIS (EM01V0U)

, 3 YARIS

Charg in g

1234(BAT) (IG) (IG) ∗ 1 : w/ Daytime Running Light 7. 5A 7. 5A 10A ∗ 2 : w/o Daytime Running Light ALT–S MET GAUGE114M 19 4B1A5CA11B(H/B) 1 CA11C(S/D) 14 SB(∗1)

L(∗1)

15 AD3 7 AA2

B

4 CA11B3A1A4A2A

C9(A), C10(B) BMSLIG Generator Battery IC Regulator

C30 Fusible Link Block 120A ALT

P

A/C Amplifier<29–6> P P Engine Control Module<5–15> W W D39 Junction Connector G Running Light (∗1) Relay<9–7> ChargeLLLLB(∗2) D1(A), D2(B), D76(C) Combination MeterGG

M YARIS (EM01V0U)

, 4 YARIS

Ig n it io n

1234(BAT)

GR

D8 15A Ignition SW AM2 5 AM2 IG26PST2 5 AD4 4 AD2 14 AA2 11 CA1

R R LG

2 1B 1 1B 4 1B C11 C12 C13 C14 1 Ignition Coil (No. 1) 1 Ignition Coil (No. 2) 1 Ignition Coil (No. 3) 1 Ignition Coil (No. 4) 1 +B +B +B +B IG2 Relay GND IGT IGF IGF IGT2 GND IGF GND IGT3 IGF GND IGT443223424324331BYYW–B W–B Engine Control Module <5–11> AI CIPP

GR

W–BRRW–B W–B BR

W

Y Y

R

Y R

O

W–B Y LG W–B

G

L R W–B

LG R

C25 Noise Filter

M OVERALL ELECTRICAL WIRING DIAGRAM YARIS (EM01V0U)

,

Memo

, 5 YARIS (Cont. next page)

EngineContro l

1234(BAT) (BAT) (IG) 20A 15A 7. 5A

EFI AM2 IGN

2 2

C/OPN EFI IG2 5 AM2 IG2 6 Relay Relay Relay ST2 D8 27 4B 9 4B 5 4E 11 4B 8 4A

1 1A 4 1A 3 1A 2 1A 3 1B 2 1B 4 1B 1 1B Ignition SW

P A

14 AA2 4 AD2 5 AD4 11 CA1

M

1111

V B

2222RC

L L D P E GR F SB G GR H B B B I Y J A1 J1 Y B

W–B W–B

GR

W–B W–B SB LG C4 Fuel Injector (No. 1) P P GRRRRC5 Fuel Injector (No. 2)

GR

P BR C6 Fuel Injector (No. 3)

R GR

C7 Fuel Injector (No. 4) P P

P R V B

W–B W–B B Pump J5 Fuel Suction Pump and Gage Assembly

M OVERALL ELECTRICAL WIRING DIAGRAM YARIS (EM01V0U)

, 5 YARIS (Cont' d) (Cont. next page)

EngineContro l

5678(BAT) (BAT) 10A 10A

STOP ETCS

18 4B132

A13 Stop Lamp SW

41224 AA2

P A A21(A), C20(B) Engine Control Module 35 A 36 A 14 A 52 B 48 A 13 A 96 B 97B3A31 A ST1– STP STSW STAR STA ACCR ETHW THW +BM ELS FC IGSW # 40 # 30 # 20 # 10 MREL BATT +B2 VPMP VCPP PPMP EPPM MPMP +B IMI IMO EOM PRG

7 A 28 A 105 B 106 B 107 B 108 B 44 A 20A1A42 A 70 B 71 B 94 B 34A2A11 A 10A9A49 B 15 CA2 16 CA2 17 CA2 14 CA2 12 AD416AA1 10 AA1 9 AA1 3 AA1 5 AA1

V 10A B EFI2 R C

1 2

L 4 AJ1 1 AJ1 7 AJ1 6 AJ1 5 AJ1 2 AJ1 3 AJ1 D 1 P E GR F9843216 SB G VLVB VGND VCC VOUT SGND MTRB MGND GR H BBB4 I AA1 Y J M Canister Pressure Sensor Vent Valve Leak Detection Pump BV1V12 V B AA2 CA1 A C2 B9B5B AA2 AD5 B V R L P GR

Y P SB Stop Light B System<14–2>

GR Y

BBGStop Lamp SW<14–2> B B J25 Canister Pump Module Starting System<2–3> VBBPPVVVVLLLLOOOO

G

V V ACC Cut Relay<1–5> BR BR BR

P BR

BLPC19 Engine Coolant Temp. Sensor

W

O GR GR Transponder Key ECU<6–2>

BR

VLGTAIL Fuse<12–3> Light Control SW <12–3> C3 VSV (Purge)

M YARIS (EM01V0U)

, 5 YARIS (Cont' d) (Cont. next page)

EngineContro l

9 10 11 12

C17 Throttle Body Assembly E2 VC VTA VTA2 M+ M–

356421

A21(A), C20(B)

91 B 67 B 115 B 114 B 42 B 41 B 63 B Engine Control Module 85 B 84 B 83 B 82 B 81 B 21 A 22 A

ETA VCTA VTA1 VTA2 M+ M– GE01 IGT1 IGT2 IGT3 IGT4 IGF1 FAN FAN2 THA E2G VG ETHA HA1A A1A– A1A+ HT1B EX1B OX1B KNK1 EKNK NE+ NE– G2+

65 B 116 B 118 B 88 B 109 B 113 B 112 B 47 B 87 B 64 B 110 B 111 B 122 B 121 B 99B5CA2 4 CA2 2 CA2 3 CA2 1 CP1 2 CP142351432

THA E2G VG E2 HA1A A1A– A1A+ 4 AD5 3 AD5 1 AD5 2 AD5 1 2

+B +B 1 C26 2 C23

Mass Air Flow Meter Air Fuel Ratio Sensor 2 1

(Bank 1 Sensor 1) 141

HT1B E2

+B OX1B23

B B A C1 B B B

BPV

LG W GR

O Y

GR

B G (Shielded) (Shielded) LG G

V R

D28 BR Oxygen Sensor (Bank 1 Sensor 2) B LG LG LG W GR GR GR (Shielded) (Shielded) (Shielded) WWG

W

(Shielded) OWRP1 G Ignition Coils Knock Control Sensor <4–2><4–3><4–4> (Bank 1)

LG

B G

Y

BR (Shielded)

L

C2 Crankshaft Position SensorPP(Shielded)

W O

FAN NO. 1 Relay<28–2> C18 Camshaft Position Sensor B LG FAN NO. 2 Relay<28–3>

M OVERALL ELECTRICAL WIRING DIAGRAM YARIS (EM01V0U)

, 5 YARIS (Cont' d) (Cont. next page)

EngineControlCru iseContro l

13 14 15 16 (BAT) ∗ 1 : w/ Cruise Control 30A

DEF

11 4M

A20 Accelerator Position Sensor

1 DEF

Relay 10A ID/UP/ MIR HTR VCP2 VPA2 EPA2 VCPA VPA EPA

21324658AD3

A21(A), C20(B)

125 B 124 B Engine Control Module 33 A 58 A 56 A 60 A 57 A 55 A 59 A

NT+ NT– ELS3 VCP2 VPA2 EPA2 VCPA VPA EPA OC1+ OC1– EC E1 ME01 E01 E04 E03 SPD TC TACH ALT E02 CANL CANH CCS

100 B 123 B 32 A 104 B 43 B 45 B 46 B 86B8A27 A 15 A 50 B 44 B 49 A 41 A 40A6AD4

BR

(∗1)

D34 D3(A), V1(B) Junction Spiral Connector2ACable 1 A

6 ECC CCS4B3B

MAIN

2 6 AD2 +RES –SET 13 CA1

CANCEL A1 C2 C1 C1 V1(B) Cruise Control SW

BR B (A/T) C24 C29 Camshaft Timing Oil Control Valve Speed Sensor (Turbine) R G (A/T) W–B

W BR BR

W–B W–B W–BVV

V

Combination Meter<27–3>

P

Data Link Connector 3<7–3>

LG

P W Generator<3–2> B L

BR

Multiplex Communication System (CAN)<8–3>

B

BR BR BR (∗1) (∗1) (∗1) R

G

L L (∗1) (∗1)

M YARIS (EM01V0U)

, 5 YARIS (Cont' d)

E le c tro n ic a llyContro lledTransmis s ionandA/T In d ic a to r ∗ 2 : S/D M/T w/ Cruise Control

∗ 3 : S/D A/T 17 18 19 20 (IG) (IG) (IG) (BAT)

G

(A/T) 10A 10A 7. 5A 7. 5A

GAUGE ECU–IG MET ECU–B

1 CA1 2 19 4B 24 4B214M 30 4B 1

RB G

(A/T) 16

A25 Junction Connector 2 4S PL RL NL DL 2L LL 21 25 AA2

619738

L 1

(A/T) 21A2A14 CA1

A21(A), C20(B)

53 B 73 B 54 B 55 B 74 B Engine Control Module 56 B

RPN2LD S1 S2 SLU+ SLU– SLT+ SLT– ST THO1 ETHO W ODMS 5V IC22 AA2

79 B 78 B 57 B 77 B 76 B 75 B 80 B 72 B 95 B 24 A 26 A

LED Driver

2 AD3

CPU CAN Controller

17 AD3 14 AD3

NSSD Transmission

5 104938216Control SW

AT3 CAN I/FS1 S2 SLU+(H/B) SLU– SLT+ SLT– ST THO E2 SL(S/D) 3 O

(A/T) 4 B (H/B) 20 A 21 A 24 A D1(A), D2(B), D76(C) 4 C (S/D) Combination Meter

C28 Electronically Controlled Transmission Solenoid Multiplex Communication System (CAN)<8–2> D3

W SB R Park/Neutral Position (A/T) (A/T) SW<13–2> B L (A/T) R (A/T) LG P (A/T) Back–Up Light System<13–1> BR O SB (A/T) (A/T) G G (A/T) GRWG(A/T) (A/T) Y GR V (A/T) (A/T) C27OYPark/Neutral Position SW (A/T) O B (A/T) BBOL(A/T) (A/T, ∗2) LLL(A/T) (A/T) (A/T) A29 D22 Cruise Control Shift Lock Control ECU Clutch SWLBB(∗2) (∗2) (∗2) Malfunction Indicator LampBB

L CRUISE L

∗ P( 3) (∗3) L ∗ R( 3) (∗3) BR (∗ N3) (∗3) Tachometer (∗3) D (∗3) Speedometer (∗3) (∗3) (∗ L3) (∗3)

M OVERALL ELECTRICAL WIRING DIAGRAM YARIS (EM01V0U)

, 6 YARIS

Engin e ImmobiliserSyste m

1234(BAT) (IG) 7. 5A 7. 5A

ECU–B IGN

1 21 4E

D24

25 AA2 Transponder Key Amplifier

Transponder Key Coil

30 4B Engine Control Module<5–8> 12 4H

VC5 CODE TXCT AGND

145711 A

D36(A), D37(B) Junction Connector

8 AD4 17 AD4 7 AD42B1213 12 11 14 1545+B IG EFIO EFII EGND VC5 CODE TXCT AGND

GND IND KSW CTY D D23 168379 Transponder Key ECU LG

(S/D)

D35 Junction Connector LG

(S/D)

D25 Security Indicator Lamp W–B D40 Junction Connector

3 6A

D2

LPLL

R

WWOOW–B W–B W–B BR BR

LG

(H/B)

P

O G Unlock Warning SW<16–4> Door Courtesy SWBV(Front LH)<11–4> W GR Data Link Connector 3<7–2>

M YARIS (EM01V0U)

, 7 YARIS

D a ta L inkConnecto r 3

1234(BAT) ∗ 1 : w/ Cruise Control ∗ 2 : w/o Cruise Control 7. 5A

OBD2

5 4S 12 A 13 A

D34(A), D35(B) Junction Connector

21 B 20B34S 31 4E 23 4B 13 AD4 7 4E 12 4D 16 7 13 9 12

BAT SIL TC TAC TS CG SG CANH CANL

4 5 D15 6 14

BR Data Link Connector 3

(∗1) 5 A

D34(A) Junction Connector

6 A

Multiplex BR CommunicationSystem (CAN)<8–3>

(∗1) 6 AD2 13 CA1

D2 D1 C1

W–B W–B W–B SB W Transponder Key ECU BR BR BR <6–3> (∗2) G Occupant Classification ECU <18–9> O P Power Steering ECU <19–3> L W Airbag Sensor Assembly Center<18–1> P P Engine Control Module<5–15> LG LG

LG

Power Steering ECU<19–3>

M OVERALL ELECTRICAL WIRING DIAGRAM YARIS (EM01V0U)

, 8 YARIS

M u ltip lexCommunic a tionSyste m (CAN)

1234D33 D31 D16 Main Body ECU Power Steering ECU Airbag Sensor Assembly Center CANL CANH CANH CANL CANH CANL 22 231713 22 D41 165415 11 22 22 11 8 19 Junction Connector D42 7 18 154314 6 17 1 12 Junction Connector 16 AD4 15 AD4 1 DE1 10 DE1 11 AD4 2 AD4 20 21 49 41 6 142365CANH CANL CANL CANH CANH CANL TX+ TX– CANH CANL D1 A21 D15 E8 A15 Combination Meter Engine Control Module Data Link Connector 3 A/C Amplifier Skid Control ECU with Actuator

W R SB W

GYWWWWWLLY

V W

VVBWWWGGWW

M YARIS (EM01V0U)

, 9 YARIS (Cont. next page)

Headlig h t

1234(BAT) (BAT) (BAT) ∗ 1 : w/ Daytime Running Light ∗ 2 : w/o Daytime Running Light 10A 10A 7. 5A ∗ 3 : w/ H–LP/AMT RelayH–LP RH/ H–LP LH/ H–LP LO RH H–LP LO LH ECU–B ∗ 4 : w/o H–LP/AMT Relay222111GR(∗4) GR(∗3) GR(∗3) 3 BA1 6 BA1 L(∗3) L7LAD5 (∗1 ∗3) (∗1 ∗3) 3 3 GR(∗3) 25 AA2 B4 B6 Headlamp (RH) Headlamp (LH) 228AA22121BR 30 4B51L20 AD3 H–LP/AMT Relay 2 4S 7 BA1 4 BA1 2 BA1 5 BA13214 B (H/B) V(∗4) 14 C (S/D) 2A2234 4B 16 4B L(∗3) V(∗4) GR(∗3) 17 4B 16 4C 4 4J 11 B 13 B (H/B) 11 C 13 C (S/D) 35 4B 3 4JPP(∗2) (∗2) (∗1) 7 LG SB75A/C Amplifier<29–6> D39 Junction98Connector 8 LG Main Body ECU<21–7> HU HL 6 SB12WHeadlamp Dimmer SW Assembly<15–1> B1 T1 RF (H) ED HU HL (ED) ED (∗2) D40 Junction Connector OFF Flash 18 B D37(B) Tail Low Junction Connector L 16 B 17BAHead High (∗1 ∗3) RF ED D4 12 11 Headlamp Dimmer SW L P(∗1) Assembly B W–B 12 17 W–B BR(∗1) 4E 4E C D1 AI Light Control SW GRGG(∗1) BBPBR Dimmer SW L(∗4) L(∗3) GR GR V(∗3) G

BR

(∗1) D1(A), D2(B), D76(C) Combination Meter Beam GR GR

L

Head (USA) PLLLL(∗1) W–B (∗3)

L

(∗4) Y V (∗3)

M OVERALL ELECTRICAL WIRING DIAGRAM YARIS (EM01V0U)

, 9 YARIS (Cont' d)

Headlig h t

5678(BAT) (IG) ∗ 1 : w/ Daytime Running Light ∗ 3 : w/ H–LP/AMT Relay 7. 5A 10A

ECU–B L ECU–IG

1 30 4B 7 4S 12 4H 25 AA28B

D37(B) Junction Connector

9 B 11A4B312 16 +B IG FOG

D9 Running Light Relay DRL H HI E PKB CHG–

17821196AD5

L A

(∗1 ∗3)

P(∗1) B BR(∗1) C A1 L

LRP(∗1 ∗3) D36(A), D37(B) Junction Connector

P

(∗1) GR R

BR

(∗1) W–B W–B

O

Headlamp Dimmer SW Assembly<15–1>

LG

Parking Brake SW<11–4>

G

Generator<3–3>

M YARIS (EM01V0U)

, 10 YARIS

T u rn S ignalandHazardWarn ingLig h t

1234(IG) (BAT) 10A 10A

GAUGE HAZ

2 7

E E TR TL RH LH TR TL D4 6 5 Headlamp Dimmer SW Assembly

32 4B 12 4S 11 4S14FLASH Relay65

IG +B ER EL

28 4E

LR LL EHW GND

2387

Main Body ECU

<21–3> 31 4B 14 4B 28 4A 27 4A 16 4S 13 4S 17 4S 7 4M 17 4E 15 A (S/D) 4 B (H/B) 4A3A1A2A

D7(B), D77(A) Hazard Warning Signal SW

15B8B(H/B) 4 A (S/D) 3B5B15C8C(S/D) 1 B (H/B) 2 A (S/D) 2 A (S/D) 3 B (H/B) 3 B (H/B) 1111116A(S/D) 6 A (S/D) 522226B(H/B) 6 B (H/B) 2 2 24 A 11

W–B

3 6A 5 6A 1 6A

B1 A1 J1 J2 D3 D2 D1

B14 Turn Signal, Side Marker and Parking Lamp (RH) W–B G (S/D) (S/D) Turn B1 Turn Signal Lamp A24(A), B13(B) (Front RH) Junction Connector W–B W–BGG(H/B) (H/B) B15 Turn Signal, Side Marker and G Parking Lamp (LH) (H/B) W–B LG (S/D) (S/D) Turn B8 Turn Signal Lamp (Front LH) W–B LG LG (H/B) (H/B)

R LG

(H/B) W–B W–B LG (H/B) (H/B) (H/B) A2 Turn Signal Lamp (Front Side LH) W–B G (H/B) (H/B) A1 Turn Signal Lamp (Front Side RH) W–B Y Turn J3(B), J34(A) Rear Combination Lamp (RH) W–B LG Turn J4(B), J35(A) Rear Combination Lamp (LH) Turn RH

BR

Turn LH BR LG D1(A), D2(B), D76(C) Combination Meter Turn Signal SW W–B W–B W–B B D40 Junction V Connector W–B

B

W–B W–B W–B

M OVERALL ELECTRICAL WIRING DIAGRAM YARIS (EM01V0U)

,

Memo

, 11 YARIS (Cont. next page)

In te r iorLig h t

1234(BAT) 15A

DOME D33(A) Main Body ECU

13 4B

BCTY(H/B) LGCY(S/D) ILE GND1 DCTY PKB

237126 24 5 4K 4 4P 7 4A 2 4K 1 4K 17 4E 6 4C 21 4A 2 4C 5 4C

BR(S/D) BR(H/B)

1B6B5B110 A 12 MJ12A12 JD1 2 15 MN111123221

O

2312

N1 J2 D1

K1 Map LampLLLW–B K2 Room Lamp (Center) W–B On Off L

P

Door GR GR L J12 D38(A), D39(B) Room Lamp (Luggage) Junction Connector

SB W

J30 J28(A), J29(B) Diode (Room Lamp) Junction Connector W–B Courtesy BR BR (H/B) (H/B) (H/B) N2 Back Door Courtesy SW W–B Courtesy BR (S/D) (S/D) J42 Door Lock Assembly (Luggage)

P

W–B W–B W–B

B

Transponder Key ECU<6–3>

R

J2 Door Courtesy SW (Front LH)

Y

D21 Parking Brake SW

LG

Running Light Relay<9–7>

M OVERALL ELECTRICAL WIRING DIAGRAM YARIS (EM01V0U)

, 11 YARIS (Cont' d)

In te r iorLig h t

5678∗ 1 : S/D w/ Tachometer (ACC) (BAT) (BAT) (IG) ∗ 2 : S/D w/o Tachometer, H/B ∗ 3 : S/D ∗5 ∗ 4 : H/B, S/D Except ∗5 7. 5A 25A 7. 5A L 7. 5A ∗ 5 : Cold Area Spec. ,

ACC D/L ECU–B MET w/ Engine Immobiliser System,

w/ ABS, w/ Rear Window Defogger, 2 w/ Door Lock Control, w/ Daytime Running Light, 1 25 1 4ML L w/ Remote Control Mirror,

AA2 w/ Air Conditioning

30 4B 2 4S D1(A), D76(C) 2A1ACombination Meter 2146

D33(A) ACC ALTB BECU Main Body ECU PCTY RRCY CANH CANL

20 22 23 A 22 A 24 4A 20 4A 5 4A

LED Driver CPU CAN Controller CAN I/F

22 C 20 C 21 C 21 A 20 A 24A1115JD2 2 JD2 3 JD2

Y(∗3) G(∗3) L(∗3) D3 L

J1 Door Courtesy SW (Front RH)

L

(∗3)

L

(∗4) J32 Door Courtesy SW (Rear RH)

G

(∗3)

G

(∗4) J33 Door Courtesy SW (Rear LH)

Y

(∗3) Multiplex Communication System (CAN)<8–1>

Y

(∗3) Door ∗ (( ) Rear LH)G 1 (∗1) (∗3) Door ( ) L (∗ ) Rear RH1 (∗1) (∗3) (∗ ) Door2 (∗2) Door (∗1) Graphic (∗1) B Multiplex Communication System (CAN)<8–2> Door ( ) (∗1) Front LH (∗1) Door ∗ (( ) Front RH)1 (∗1) Door ∗ (Luggage)( 1) (∗1)

BR M YARIS (EM01V0U)

, 12 YARIS (Cont. next page)

T a illightandIllu m in a tio n

1234

BR

(BAT) B A

V B A28 Fusible Link Block 1 4G 6 4Q 10 4P

1 (∗2) (IG) 10A

TAIL(∗1) 7. 5A 7. 5A

10A 7. 5A PANEL1 MET

TAIL T–LP PANEL2(∗2) Relay

(∗1) (∗1) 9 4S 4 4M 10 4E 33 4B 10 4A 15 4B 29 4A 7 4P 1 4M 2 4Q 9 4Q ∗ 1 : H/B, S/D ∗3 ∗ 2 : Except ∗1 ∗ 3 : Cold Area Spec. , SB(H/B) w/ Engine Immobiliser System, C 13 w/ ABS, R(H/B) w/ Rear Window Defogger, D

B1 w/ Door Lock Control, R(S/D)

w/ Daytime Running Light, E

B1 T1 w/ Remote Control Mirror, G 5 G

w/ Air Conditioning22DE1 F

Light OFF Control GR SW Tail

1 1

Head

10 A 11 A 12 A

T1 16 B (H/B)

10 4 LJ1 16 C (S/D) 1 A 14 A

G9B10B7B8B

(∗2)

Illumination I/F

4 A (S/D) 4 A (S/D) 4 B (H/B) 4 B (H/B) 4343I/F22112CPU

I/F

11221226A(S/D) 6 A (S/D) 24 A 15A7A6B(H/B) 6 B (H/B)

W–B W–B W–B 9 LJ1 GR G

(S/D)

Y H

8 BA1 4 6A

D2 A1 B1 J1 J2 D3

B14 Turn Signal, Side Marker and Parking Lamp (RH) D4 Headlamp Dimmer SW Assembly

G

120A ALT (S/D) Side Marker W–B G (S/D) (S/D) Parking W Main Body ECU (∗1) <21–3> W–B (∗1) B15 W Turn Signal, Side Marker and (∗2) Parking Lamp (LH)

G

(S/D) Side (∗1) Marker W–B G (∗1) (S/D) (S/D) Parking W–B G (H/B) (H/B) B11 Side Marker Lamp (Front RH) W–B W–B W–B G (H/B) (H/B) B12 Side Marker Lamp (Front LH) W–B W–B G (H/B) (H/B) G B3 (∗2) Parking Lamp (RH) W–BGP(H/B) (H/B) B7 A24(A), B13(B) Parking Lamp (LH) Junction Connector Tail W–B GR J3(B), J34(A) Rear Combination Lamp (RH)

G

Engine Control Module<5–8> Tail W–B W–BGG

G

J4(B), J35(A) (S/D) Rear Combination Lamp (LH) W–B W–BGG(H/B) (H/B) (H/B) (H/B) L1 License Plate Lamp W–B G (S/D) (S/D) J36 License Plate Lamp (RH) W–B W–B G (S/D) (S/D) (S/D) J37 License Plate Tail (Canada) Lamp (LH)

G

Pointer

B

BR DialGR

Y GR

D1(A), D2(B), D76(C) Combination Meter

M OVERALL ELECTRICAL WIRING DIAGRAM YARIS (EM01V0U)

, 12 YARIS (Cont' d)

T a illightandIllu m in a tio n

5678

BR A (IG) V B

10A

GAUGE

1 4P8B9B11 B

SB(H/B) C D38(A), D39(B)

2 A

Junction R(H/B) Connector D R(S/D) E G F 1337510 E10 ILL+ T IG

20 Junction Connector 19 21 22 D29

Light Control Rheostat

2 10 A

ILL+

255

ILL– ILL– RV RL TC E

32215B2983146R

LG

11 10 8 16 B 17 B 18 B 15 A

E10 9 Junction Connector

16 A 18 A 20B8R

DE1 GR G Y H

2 6A

D2

LG L E1 Blower SW W GR E6 Rear Window Defogger SWRWBE5 A/C SW

W

(S/D) D77 Hazard Warning Signal SWWWR(H/B) (H/B) D7 Hazard Warning Signal SW W SB (H/B) (H/B) D30 Door Lock Control SW D38(A), D39(B) Junction Connector

GR

D20 A/T Shift Lever IlluminationWGGGVD10(A), D11(B) Radio Receiver Assembly Passenger Seat Belt Warning Lamp B <18–7> (H/B)

LG

W O BR D36(A), D37(B) Junction Connector Y SB W–B

M YARIS (EM01V0U)

, 13 YARIS

Back– UpLig h t

1234(IG) 10A ∗ 1 : A/T

GAUGE ∗ 2 : M/T

19 4B 1 CA122

C22 Back–Up Lamp SW RB RL J28(A), J29(B)

9 B Junction Connector

R

1 1 10A9A

R

(∗1) 5 A (S/D) 5 A (S/D) 30 4A1B(H/B) 1 B (H/B) 3 CA16A(S/D) 6 A (S/D) 22 4B6B(H/B) 6 B (H/B)

J1 J2

R G (∗2) (∗2) GGG(∗1) RRR(∗1) (∗1) C27 Park/Neutral Position SW Engine Control Module <5–17>

R

W–B R Back–Up J3(B), J34(A) Rear Combination Lamp (RH) W–B BR Back–Up J4(B), J35(A) Rear Combination Lamp (LH)

M OVERALL ELECTRICAL WIRING DIAGRAM YARIS (EM01V0U)

, 14 YARIS

S topLight∗ 1 : S/D LED Type

∗ 2 : S/D Bulb Type1234(BAT) 10A

STOP

18 4B

A13 Stop Lamp SW G Engine Control Module<5–6> O

(S/D) 12 4B O (H/B) 21 18

Skid Control ECUGGShift Lock 10 MJ1

with Actuator<17–2> 4B 4S Control ECU<23–4> 12 4A2A(∗1) 1 B (H/B) 1

J28(A), J29(B)

3 B Junction Connector4B1A(∗1) 2 B (H/B) 23A4A1A(S/D) 1 A (S/D) 5 B (H/B) 5 B (H/B) 6 A (S/D) 6 A (S/D) 6 B (H/B) 6 B (H/B) 11 MJ1

W–B(H/B) W–B(S/D) W–B J2 J1

J4(B), J35(A) Rear Combination Lamp (LH) W–B W–BVVGBStop J3(B), J34(A) Rear Combination Lamp (RH) W–BOO(S/D) Stop

O

(H/B) W–B (H/B) W–B O (∗1) (∗1) M1(B), J41(A) Center Stop Lamp W–B O (∗2) (∗2) J40 Center Stop Lamp

M YARIS (EM01V0U)

, 15 YARIS

F rontFogLig h t

1234(BAT) ∗ 1 : w/ Daytime Running Light 15A ∗ 2 : w/o Daytime Running Light FR FOG 9 4M D4 Headlamp Dimmer SW Assembly LFG BFG Fog Light SW OFF25D46 Front Front Fog Light Relay LFG BFG4313YR7AD27B(H/B) 6 A A24(A)( , B13 (B) 7 C S/D) Junction Connector2B1B22B10 B9 Fog Lamp (Front LH) Fog Lamp (Front RH) 24A11D3 B1 Headlamp Dimmer SW W Assembly<9–4> (∗2)

O

Running Light Relay<9–7> (∗1)

V

(H/B) Front ( ) ( FogBR S/D S/D) R V D1(A), D2(B), D76(C) Combination Meter W–B W–BRRW–B R

M OVERALL ELECTRICAL WIRING DIAGRAM YARIS (EM01V0U)

, 16 YARIS

KeyReminderandLightReminder

1234(IG) (BAT) 7. 5A 7. 5A

MET ECU–B

1 4M 1 25 AA2 2 4S 30 4B 1412D33(A)

Main Body ECU 6 BECU CANL CANH GND1 DCTY KSW Illumination I/F 22 A 23 A

5V IC 1 26 9 17 4E 21 4A 7 4D 6 4E 4 4C

CPU CAN Controller CAN I/F I/F Buzzer

20 21 24 D1

Combination Meter Multiplex Communication 1 5A System (CAN)<8–2> D3 D1

Taillight and Illumination System<12–4>

BR B L

Multiplex Communication System (CAN)<8–1> W–B Interior Light System <11–4> W–BYLLD19 Unlock Warning SW

Y

Theft Warning ECU<21–12>

O

Transponder Key ECU<6–3>

M YARIS (EM01V0U)

, 17 YARIS

A B S

1234(IG) (IG) (BAT) (BAT) 7. 5A 10A 30A 50A

MET ECU–IG ABS2/ ABS1/VSC2 VSC1

2214M 24 4B11

A25 Junction Connector A11 A7

19 Speed Sensor (Front LH) Speed Sensor (Front RH) 21218AA1 7 AA11A1AA1

LED Driver 259831 30 1 23 IG1 FL+ FL– FR+ FR– +BS +BM A15 Skid Control ECU with Actuator CPU STP CANL CANH RL– RL+ RR– RR+ GND1 GND2 CAN Controller 105612 11 34 33 2 24 CAN I/F

11 AJ1 10 AJ1 9 AJ1 8 AJ12B(H/B) 24 A 21 A 20A2C(S/D) 2 aJ1 1 aJ1 2 ZJ1 1 ZJ11212a1 Z1

Speed Sensor Speed Sensor

(Rear LH) (Rear RH)

D3 A2

BRAKE (USA) Brake (Canada) Combination Meter System<27–5>

BR

Multiplex Communication System (CAN)<8–2>

ABS B

Speedometer D1(A), D2(B), D76(C) Combination Meter Stop Lamp SWGBBB<14–1> Multiplex Communication System (CAN)<8–4> BRBBRWYYGBRLLPWLG LG V W–B W–BWWW–BBB

M OVERALL ELECTRICAL WIRING DIAGRAM YARIS (EM01V0U)

,

Memo

, 18 YARIS (Cont. next page)

S R S

1234(IG) 7. 5A

IGN

16 4E J15 J14 A6 A12 Airbag Sensor (Rear LH) Airbag Sensor (Rear RH) Airbag Sensor Airbag Sensor (Front RH) (Front LH) BCL+ BCL– BCR+ BCR– 2121+SR –SR +SL –SL212112121AD1 2 AD1 3 AD1 4 AD1 BCL+ BCL– J17 BCR+ BCR– J16 Side Airbag Sensor (LH) Side Airbag Sensor (RH) BBL+ BBL– BBR+ BBR– 4343D16(A), J8(C), J9(B) 16 A 21 A 29 A 27 A 30 A 28A8C15C8B11 B Airbag Sensor Assembly Center SIL IG2 +SR –SR +SL –SL BBD+ BBD– BBP+ BBP– E2 E1 PD+ PD– PP+ PP– P+ P– P2+ P2– SFP+ SFP– SFD+ SFD– ICP+ ICP– ICD+ ICD– 26 A 25A2C1C4B5B4A3A1A2A7B6B9C10C9B10B7C6C14 4E 30 4E 1 DQ1 2 DQ1 3 DQ1 4 DQ1 2 JX1 1 JX1 2 JY1 1 JY1 17 4E21212A1A2B1B21211212J21 J20 Q1(A), Q2(B) X1 Y1 J22 J23 Pretensioner Pretensioner Airbag Squib Side Airbag Squib (RH) Side Airbag Squib (LH) Curtain Shield Airbag Curtain Shield (LH) (RH) (Front Passenger' s Airbag Assembly) Squib (RH) Airbag Squib (LH) D1 W–B W Data Link Connector 3<7–3> W–B W–B

B

Y–B

Y

Y–BWW

Y

B B Y–R Y–BWWY–G Y Y–B Y–RBBYY–G Y–B Y–R Y Y–B Y–B Y–BRRYYLB

Y

Y–BYRBY–BLR

M OVERALL ELECTRICAL WIRING DIAGRAM YARIS (EM01V0U)

, 18 YARIS (Cont' d) (Cont. next page)

SRSSeatBeltWarn in g

5678

J24(A), U1(B)

(IG) (IG) Occupant Classification ECU

Taillight and D1(A), D2(B), D76(C) Illumination Combination Meter System<12–5>

7. 5A 10A

MET GAUGE D77 FSR+ FSR– Hazard Warning Signal SW938A4A PAON ILL–

1 4M 15 4S

Passenger' s Seat Belt/Airbag Indicator (ON/OFF) LED Driver IG+ PBEW P–AB

6 8 10

CPU CAN Controller D27 Passenger Seat Belt Warning Lamp 2 DIM CAN I/F Passenger' s Seat Belt/Airbag Indicator (ON/OFF) IG+ PBEW P–AB PAON ILL–

635141A21 A 20 A 24A9B(H/B) 9 C (S/D) 14 4S 3 4E 32 4E 15 4E 17 A 23 A 12 B 13 B

P–AB PAON FSP+ FSP– D+ D– D2+ D2– CANL CANH DSP+ DSP– DBE+ DBE–

5A6A8A7AD16(A), J8(C), J9(B) 22 A 13 A 14 C 13 C 11 C 12 C

Airbag Sensor Assembly Center

1A2A4A3A

D18(A), W1(B), W2(C) D+ D– D2+ D2– Spiral Cable 11

21432B1B2C1CLSP+ LSP– LBE+ LBE–

W1(B), W2(C) J10 Airbag Squib Front Seat Inner Belt (Driver' s Side)

(Steering Wheel Pad) 3 6A

D3 D2

Y–B B

Y

Airbag Y–R Y–G Driver' sSeat Belt Multiplex Communication System (CAN) <8–2>

BR O

(H/B)

Y

(H/B) Multiplex Communication System (CAN)<8–4>

Y

(S/D)

O

(S/D)

R

(S/D)

Y

Y–R (H/B)

O

(H/B)

GR

(S/D) BRY(H/B) G GR (S/D) (H/B) W B PANEL1 Fuse G (H/B) (H/B) <12–7>

GR

(S/D) R GR

Y BR

W–B W (H/B) (H/B) D40 Junction Connector

M YARIS (EM01V0U)

, 18 YARIS (Cont' d)

SeatBeltWarn in g

9 10 11 12 J24(A), U1(B) Occupant Classification ECU (IG) (BAT) 7. 5A 7. 5A IGN ECU–B DIA GND BSW BGND SVC1 SIG1 SGD1 SVC3 SIG3 SGD3 SVC2 SIG2 SGD2 SVC4 SIG4 SGD4 +B IG2A3A9A5A11B7B1B5B9B3B12B8B2B6B10B4B1A7A214D17JD2 6 JD2 1 JD2 25 AA221123123123123RBE+ RBE– SVC1 SIG1 SGD1 SVC3 SIG3 SGD3 SVC2 SIG2 SGD2 SVC4 SIG4 SGD4

O

15 4A 30 4B J11 U2 U3 U4 U5 8 D36 Front Seat Inner Belt Occupant Classification Occupant Classification Occupant Classification Occupant Classification Assembly (Front RH) Sensor (Front LH) Sensor (Rear LH) Sensor (Front RH) Sensor (Rear RH) Junction Connector 17 4E 12 4H

P

D1GGData Link Connector 3<7–2> W–B W–B

O P R SB G GR Y W W L O V R BR

V V

O

L L

M OVERALL ELECTRICAL WIRING DIAGRAM YARIS (EM01V0U)

, 19 YARIS

E P S

1234(IG) (BAT) (IG) 7. 5A 50A 10A

MET EPS ECU–IG

1 4M174S c1(D)

Power Steering Torque Sensor

8B1A

M

1A6B2B11B1C2C6D5D7D8D

LED Driver PIG IG SIL TS M1 M2 TRQV TRQ1 TRQ2 TRQG CPU CANH CANL SPD PGND CAN Controller

1B7B5BA19(A), D31(B), b1(C), c1(D) 2 A

Power Steering ECU CAN I/F

21 20 24

D3 A3

Speedometer Multiplex Communication System (CAN)<8–2> P/S

B BR

D1 Combination Meter

W

Multiplex Communication System (CAN)<8–2> L R D36(A), D37(B) Junction ConnectorRPCombination Meter<27–3> Data Link Connector 3<7–2><7–3>

LG

b1(C) Power Steering Motor

R B R W Y

W–B B

M YARIS (EM01V0U)

, 20 YARIS (Cont. next page)

PowerWindow∗ 1 : w/ Rear Power Window

∗ 2 : w/o Rear Power Window1234G1(A), (B) (BAT) (BAT) (IG) Power Window Master SW A28 7. 5A Fusible 10A ECU–B Link Block ECU–IG2BUDDU16A16 A 15A4A3A(∗1) 1 15 B 16 B 18 B 12 B 10 B (∗2) 1 4G 2 GD2 11 GD2 10 GD2 PWR12Relay M G4 Power Window Regulator Motor (Front LH) 21 4A 25 AA2 1 11 FD2 10 FD2 13 26 5 20A 20A PWS DCTY IG RL RR 30A DOOR DOOR POWER Main Body ECU 2 BECU 17 4E 1 4A 19 4A 2 4H 11 4H 30 4B

SB A SB B

2 FD252L3F1 Power Window SW (Front RH) 4121

M

D1 F4 Power Window Regulator Motor (Front RH) L L W–B W–B

SB SB L

GR B 120A ALT

L

Interior Light System<11–4> GR GR

L

R UpWWWPPP

G

Down

G R M OVERALL ELECTRICAL WIRING DIAGRAM YARIS (EM01V0U)

, 20 YARIS (Cont' d)

PowerWindow

5678G1(A), (B) Power Window Master SW ∗ 1 : w/ Rear Power Window ∗ 2 : w/o Rear Power WindowUDUDE12 A 13 A 10 A 18A1A(∗1) 7 B (∗2) 8 GD2 9 GD2 17 GD2 18 GD2 11 JD1 10 JD1 2 JD1 1 JD1 2 IJ1 3 IJ1 2 HJ1 3 HJ1

SB A SB B

1 IJ1511HJ151SB 3 SB3424235B1212MMI2 H2 D1 Power Window Regulator Power Window Regulator Motor (Rear LH) Motor (Rear RH)

SB

Y UpRYYYGBBB

B

Down I1 Power Window SW (Rear LH)

SB

Y UpRRRRGGGG

B

Down H1 Power Window SW (Rear RH) W–B

M YARIS (EM01V0U)

, 21 YARIS (Cont. next page)

DoorLockContro l

1234D33(A) (BAT) (BAT) (IG) (ACC) Main Body ECU 7. 5A 25A 10A 7. 5A ECU–B D/L ECU–IG ACC BCTY(H/B) ACC IG ALTB BECU KSW DCTY PCTY RRCY LGCY(S/D) GND1 TRLY HAZ LSWP UL2 L2 ACT– ACT+ 2 21546926 20 22 23 1 19 255A16 1432

A B C

30 4B 7 4D 21 4A 24 4A 20 4A 5 4A 7 4A 17 4E 1 4S 15 4H 16 4H 18 4H 8 4H L 25 L AA2 17 JD1 9 FD1 8 FD1 7 FD1 20 FD1 10 FD175614LSSR UL L UL L

M E

8 F5 Door Lock Assembly (Front Passenger' s Side) W–B

D

(S/D) W–B(H/B)

E

W–B(S/D)

F

1 6B 3 6A 6 6B D1 D2 Key Reminder System<16–4> Interior Light System <11–2><11–4><11–5> W–B W–B(S/D) T–LP Relay<12–1> FLASH Relay<10–4> Unlock W–B DetectionLLUnlockGGBR O LockPPOO

M OVERALL ELECTRICAL WIRING DIAGRAM YARIS (EM01V0U)

, 21 YARIS (Cont' d) (Cont. next page) ∗ 1 : w/ Rear Power Window ∗ 2 : w/o Rear Power Window

DoorLockContro l ∗ 3 : w/ Power Window

∗ 4 : S/D w/o Power Window5678

D33(A) Main Body ECU LSWD UL3 ACTD LSR HRLY CANL CANH L1 UL1 HORN

21 A 14A2A24A3A22 A 23 A 12 10 15

A M B

1 2

C

7 4H 17 4H 3 4A 4 4A 7 MN1 6 MN1 8 JD2 4 4H 5 4H 10 4C 11 4E

BR(S/D)

8 MJ1 9 MJ1

O(S/D)

5 GD1 6 GD1 6 FD1 5 FD18B2B7B1B9GD1 8 GD1 7 GD1 20 GD1 10 GD1 11A5AJ28(A), J29(B) 12A6A

Junction Connector

8 10914

LSSR UL L ULL2A9A(∗1)

321B9B(∗2) 4523

L UL L UL

8 HJ1 9 HJ1 8 IJ1 9 IJ1

M E

4141464

E L UL Unlock Unlock L UL

7 G5 Detection Detection

Door Lock Assembly (Driver' s Side) E M M

1 A (∗1)

E LSSR E LSSR7B(∗2)

9696

D40 Junction

12 HJ1 13 HJ1 12 IJ1 13 IJ1 Connector

W–B W–B D

(S/D) (S/D)

W–B(H/B) E W–B(S/D) F

1 5B 4 5B 3 5B

D1

Unlock W–B DetectionLLUnlockGYBR BR Lock P SBOWH3 Door Lock Assembly (Rear RH) GR GR GRPPPW–B W–B (S/D) (S/D)

L

O O (S/D) (S/D)

Y

W–B W–B SB (S/D) (S/D) O O (S/D) (S/D) GR GR GR B GR (H/B) (H/B) (H/B) PPPBP(H/B) (H/B) (H/B) N3 I3 Back Door Door Lock Assembly Lock Assembly (Rear LH) O O (S/D) (S/D) G7 Door Lock Control SW (Driver' s Side) Headlamp LG Lock BR Dimmer SWAssembly<9–4> (∗4) W–B (∗4)

O

Unlock (∗4) Multiplex Communication System (CAN) <8–1> G1(A), (B) Power Window Master SW BR LG Lock (∗3) W–B (∗3) UnlockOO(∗3) Unlock G (H/B) W–B W–B (H/B) (H/B)

BR

Lock (H/B) D30 Door Lock Control SW Unlock O (S/D) W–B (S/D)

BR

Lock (S/D) HORN Relay<25–3> F7 Door Lock Control SW (Front Passenger' s Side)

M YARIS (EM01V0U)

, 21 YARIS (Cont' d)

W ire lessDoorLockControlTheftDete rre n t

∗ 5 : w/ Theft Deterrent System 9 10 11 12

D33(A) Main Body ECU (BAT) (BAT) (IG)

15A 7. 5A 10A W–B W–B

DOME ECU–B ECU–IG SRX STX PRG RDA

18 A 19 A 17 A 16A221A(S/D) 2 B (H/B) 21174S L

B

25 AA22A(S/D) 11B(H/B) 12 MN1 13 4B 30 4B8B44P 5 4P 12 4H9B11 JD2 15 MJ1 11 A

D36(A), D37(B) Junction Connector

1 B 16 AD5 15 AD5 16 JD2

D38(A), D39(B) 3B2B Junction Connector

8 A 11 139415 6 +B1 +B2 IG DSWH SH– LSR(H/B)

LUG(S/D) BRK– BRK+ E IND KSW

16 JD1 15 JD1 14 JD1 25 24 16 29 D26 7

G Theft Warning ECU

(S/D)

D35

325JunctionConnector

PRG RDA +B 16 LG 2 2

(S/D)

GND J13 1 D25 Door Control Receiver Security Indicator Lamp 1 1 D40

5 Junction Connector 10 11 W–B

W–B7B8W–B W–B MJ1 MN1

(H/B) (H/B) (H/B) (H/B) 3 6A

J2 D2 N1 J2 A1 P

(∗5)

O

(∗5) WWRRW–B W–BLLLLOB(∗5)

BR

(S/D) LPLL(H/B)

P

(∗5) W–B GR R D37(B) Junction Connector A18(A), (B) Engine Hood Courtesy SW W–B LGWW(H/B) O O W–B A23 Security HornPP(S/D) (S/D) YOPPUnlock Warning SW<16–4> (H/B) (H/B) (H/B) Unlock W–B Detection P (H/B) (H/B) N4 Back Door Position SW Unlock W–B Detection P (S/D) (S/D) J43 Door Lock Assembly (Luggage) W–B

M OVERALL ELECTRICAL WIRING DIAGRAM YARIS (EM01V0U)

, 22 YARIS

F rontWiperandWasher

1234(IG) (IG) 15A 20A WSH WIP 2 4B 1 4H 36 4B

B

A26 Junction Connector 5 AD2 2 AD2 4 4E D5(A), D6(B) A5 Windshield Wiper SW Assembly Windshield3B4BM Washer Motor +1 +2 25 4B +B INT1 INT2 +S +1 +2 B1 MIST Washer SW3512OFF WF EW +2 +1 +S B INT Off LO On 1 AD2

HI M

+S INT1 INT2 B1

E

4 A9 Windshield Wiper Motor 2 4E +B +SWEWiper Relay +S +B WF EW1B2B3A2A17 4E

W B

D1 A1

L

(S/D) GGLL(H/B) (H/B)

L

Y Y Wiper SW

G

W–B W–B W–B

Y

W–BLLWW

B M YARIS (EM01V0U)

, 23 YARIS

RearWiperandWasherShiftLock

1234(IG) (IG) (IG) (ACC)

D5(A), D6(B) Windshield Wiper SW Assembly

15A 15A 10A D43

RR WIP WSH WR +1R EW GAUGE Fuse Block Wash Off 2

25 4A 2 4B 2 4P

On On+Washer

5B7A2A

A26

4 MJ1 Junction Connector 18 JD1

A4 M Rear Washer Motor

6 MJ1213976

IG AT3 NSSD STP ACC D22 Shift Lock Control ECU

2 MN1 10 AD2 9 MN1

SLS+ SLS– KLS+ E

12812

N1 B L Rear Wiper Motor Assembly M W–B 5 D40 Junction Connector

2 4E 17 4E 3 6A

D1 D2

WWW

L

LLLRear Wiper and Washer SW

O

LLLLW–B W–B

R

Shift Lock Solenoid Electronic Controlled Transmission and A/T Indicator System <5–19> D13 G Stop Lamp SW<14–2> Key Interlock Solenoid

L

W–B W–B B 7. 5A ACC2

M OVERALL ELECTRICAL WIRING DIAGRAM YARIS (EM01V0U)

, 24 YARIS

RemoteControlMirrorCig a re tte L ig h te r /PowerOutle t

1234(ACC) (ACC) 7. 5A 15A

ACC CIG

13 B

D34(A), D35(B) Junction Connector

6 4S 3 4Q 19 A

D12

8 Outer Mirror SW 1

D14 B ACC Cigarette Lighter or Power Outlet

7 E

E MH MV Left Right Left Right HL HR VL VR M+

5243614 5 12 D40

Junction Connector

13 D38 11

Junction Connector

13 GD1 12 GD1 12 FD1 13 FD1 14 FD1 14 GD13535

MH MV MH MV MMMM M+ M+

4466A 3 6A 4 5A

D1 D2

W–B SB O LeftWBSB SB Right G2 Outer Rear View Mirror (LH)

GR SB

SB SB Up GRWBBDown F2 Outer Rear View Mirror (RH) Left/ UpWWPRight/ Down Select SW Operation SWWGW–B (S/D) W–B W–B GR (H/B) (H/B)

M YARIS (EM01V0U)

, 25 YARIS

RearWindowDefoggerHorn

1234(BAT) (IG) (IG) (BAT) 30A 7. 5A 10A DEF A/C HORN22DEF HORN Relay Relay 2 4F 12 4Q 10 4S 7 1A 8 1A 15 DE1 12 DE1 28 4B 17 AA2 20 JD2 Main Body ECU <21–8> 18 4E E10 Junction Connector 1 17 1 BA1 J45 Noise Filter E6 Rear Window Defogger SW232RDEF IG+ 1 MJ1 Rr DEFE1A(H/B) Rear1D(S/D) Window Off Defogger SW18AJ31 J44(D), M2(A), O1(B), (C) On Noise Filter Rear Window Defogger HO D3(A), V1(B), (C) Spiral Cable

E

1 B (H/B) 12B(S/D) 1 C (S/D) 1 C (H/B) 1 B2 Horn V1(B), (C) 5 7 Horn Steering Pad SW D40 Junction Connector 9 DE1 E10 Junction Connector 11536A O1 D2

B

(H/B) BBBBB(H/B) (H/B) (H/B) B B (S/D) (S/D) W–B W–BBB10A GAUGE W–B W–BPOOWBLGGGG

M OVERALL ELECTRICAL WIRING DIAGRAM YARIS (EM01V0U)

, 26 YARIS

AudioSyste m ∗ 1 : H/B 5–Door

∗ 2 : H/B 3–Door1234(ACC) (BAT)

J39 J38 Speaker (Rear LH) Speaker (Rear RH)

7. 5A 15A2121

ACC DOME J27 J26

2 Speaker (Rear LH) Speaker (Rear RH) 14 4D12121

I4 H4 Speaker (Rear LH) Speaker (Rear RH)

21215IJ1 4 IJ1 5 HJ1 4 HJ1 8 AD2 D32

Antenna Amplifier B

1 JD3 5 JD2 4 JD2 11 JD3 10 JD3 15 JD2 14 JD2 20 JD3

YBWR

(S/D) (S/D) (S/D) (S/D)

D10(A), D11(B), D74(C)

3A4A8ARadio Receiver Assembly6B2B3B1B

ACC B ANT RL– RL+ RR– RR+ FR– FR+ FL– FL+ GND SPD ALI ARI ASGN AUXI

5A1A6A2A7A3C17 C 15 C 16 C 19C123418 FD1 17 FD1 18 GD1 17 GD1 ALO ARO ASGN AUXO

D75 Stereo Jack Adapter

2121

F6 G6 Speaker (Front Door RH) Speaker (Front Door LH) D3

L Y GR GR GRLLVV

B

P P W–B

Y

(S/D)

Y

(∗2) CombinationWYYWMeter<27–2> (S/D) (H/B) (∗1) (∗1) BBR(H/B) (∗1) (∗1)

B

(∗2)

B

(S/D)

W

(Shielded) (S/D) G W (∗2) RWWW(H/B) (∗1) (∗1) RRRR(H/B) (∗1) (∗1)

R

(∗2)

R

(S/D)

M YARIS (EM01V0U)

, 27 YARIS (Cont. next page)

Combin a tionMete r ∗ 1 : S/D w/ Tachometer

∗ 2 : S/D w/o Tachometer, H/B1234(IG) (BAT) (IG) 10A 7. 5A 7. 5A

ECU–IG ECU–B MET

24 4B 1 25 AA2 30 4B 2 4S 1 4M

L A25 ( Junction 16 B H/B

) D1(A), D2(B), D76(C)

Connector2A1A14 A 16 C (S/D) Combination Meter

11 CA2 5V IC

Display Illumination I/F LED Driver CPU CAN Controller I/F I/F I/F I/F I/F (H/B) I/F I/F I/F I/F I/F Clock CAN I/F Buzzer SW TRIP Drive SW (H/B) Monitor

3 A 24 A 17 A 16 A 19 C 18 C 17C7A15 A 21 A 20A9B(H/B) 9 C (S/D)

P P AD3 G 5 11 12 E TX+1 +S

6 AA2 ODO/TRIP SW 1 4C 8 4D 8 4C Clock SW

W–B 20 D36 D77 Junction Hazard Warning Signal SW Connector

13 4A 22 19 26 4B 12 CA2 13 CA2 23 AA2132O

IG+ SI SE Radio Power Engine Control A1 J1 D3 Receiver Steering Module<5–14> Assembly ECU<19–3>

<26–3>

C21 Speed Sensor

BBBBPPW–B

L

W–B (H/B) (H/B)

BR

(H/B)

L

Gage Pointer (H/B) J5 (H/B) B Fuel Suction Pump and Gage Assembly Dial (H/B)

V

Taillight and Illumination System <12–3><12–4> Tail (Canada)

BR

Tachometer

W

(S/D) Speedometer

R

Door (∗2) (∗2) Door (∗ ) Graphic1 (∗1) Door (∗ () Front LH)1 (∗1) V SB Door ( ) (∗ ) Front RH1 (∗1)

GR

Door (S/D) ∗ (( Luggage)1) (∗1)

R

(S/D) P/S

L

(S/D) Airbag (S/D) Taillight and Illumination System<12–4>

ABS

MAINT REQD Driver' s Multiplex Communication Seat Belt System (CAN)<8–2> SRS System<18–6> Temp. Hot Temp. Cool

M OVERALL ELECTRICAL WIRING DIAGRAM YARIS (EM01V0U)

, 27 YARIS (Cont' d)

Combin a tionMete r ∗ 1 : S/D w/ Tachometer

∗ 3 : S/D A/T5678

D1(A), D2(B), D76(C) 14 B 15B8B7B(H/B) Combination Meter 14 C 15C8C7C(S/D) LED Driver

(S/D) (S/D) 2 B 10B1B13 B 12B4B11 B (H/B) 2 C 10C1C13 C 12 C 22 C 20 C 21C4C11 C (S/D) 18 AD3 22 AD3 19 AD3

Interior Light

1 System<11–7> 2 S 19 AA2 18 AA2

E

1 1

V C16 Engine Oil Pressure SW

6 CA1

A1 CRUISE P

(∗3) (∗3) (∗ R3) (∗3)

N

(∗3) (∗3) (∗ ) D3 (∗3) V V ∗ 2( 3) (∗3) (∗3) L (∗3) A10 Brake Fluid Level Warning SW BRAKE (USA) Brake (Canada) W–B Washer W–BWWA22 Water Level Warning SW Charge Charging System<3–3> Head (USA) Headlight System<9–3> Oil PressureYYY

Y

Door ∗ ( )( 1) Rear LH (∗1) Door ∗ (( ) Rear RH)1 (∗1) Malfunction Indicator Lamp Engine Control System<5–19> Beam Headlight System<9–3> Headlight System<9–3> Turn RH Turn Signal and Hazard Warning Light System<10–3> Turn LH (S/D) (S/D) Front Fog (H/B) Front Fog Light System<15–2>

M YARIS (EM01V0U)

, 28 YARIS

CoolingFan

1234(BAT) (IG) 30A 10A RDI ECU–IG 1 24 4B B 17 5 1B 6 1B1123FAN NO. 1 FAN NO. 2 4 Relay Relay1581B 7 1B1113AA2 4 AA2

M

Engine Control Module<5–12> W–B A2 A1 LGLLA8 Cooling Fan MotorBOOLG LGBBA25 LG Junction Connector W–B W–B W–B L A14 Radiator Fan Resistor

M OVERALL ELECTRICAL WIRING DIAGRAM YARIS (EM01V0U)

,

Memo

, 29 YARIS (Cont. next page)

A irConditio n in g

1234

E5

(BAT) (IG) (IG) A/C SW 40A 10A 7. 5ALB

HTR GAUGE ∗ 1 : w/ PTC Heater A/C

∗ 2 : w/o PTC Heater Off ∗ 3 : w/ Defroster Mode Detection SW 2 ∗ 4 : w/o Defroster Mode Detection SW On ∗ 5 : w/ A/C SW 1 ∗ 10 4S 6 : w/o A/C SW52

L B

4 HTR

Relay Off12 DE1 On

3 1 (∗3 ∗5) 1 4L 17 4E 7 4F 5 4Q (∗3 ∗5) (∗6)

L B E E10243

15 Junction Connector 1 ED1 BR 18 16

IG+

8 A 15 A 16 A

IG+ A/C LED

13 DE1 IG MAX–HOT E8(A), E9(B)A/C Amplifier

Off M E4 Blower Motor On HEAT B/V SBLW GND SG–2 TE

1 E3 14 B 14A9A12A4A10 A

Blower Resistor SG A/C B L4876

231LG (∗1) 1067

E LO HI M2 M1124L12 E10

0 Junction Connector (∗2) 13535

D40

2 ED1 9 DE1 4 Junction Connector5911 1

R 3 6A W–B 2 D1 D2 D2 L

W–BLLBBE1 Blower SW

G B

W–B W–B W–B R BR W–B W–B Max Hot

SW L

(∗2)

LG

(∗2) W–B E6 Rear Window Defogger SWYOO

LG

(∗2)

BR

W–B DefrosterMode Detection

SW

E2 A/C Thermistor No. 1LLA/C SW (∗2) (∗2) E10 Junction ConnectorLV(∗5) (∗1) LG (∗3 ∗5) (∗3 ∗5) (∗5) GR (∗4 ∗5)

P M OVERALL ELECTRICAL WIRING DIAGRAM YARIS (EM01V0U)

, 29 YARIS (Cont' d)

A irConditio n in g

∗ 1 : w/ PTC Heater5678(BAT) (BAT) 40A 30A

HTR HTR SUB2 SUB1

2211

W

(∗1)

R

(∗1) 15 CA1222211252515

HTR HTR HTR

14 DE1 7 AE1 2 AE1 5 AE1 SUB2 SUB3 SUB1Relay Relay Relay131323222211

E8(A), E9(B) W–B A/C Amplifier2A3A23 B 24 B 12 B 10 B (∗1) TX+ TX– HLS ALT PTC3 PTC2 L

(∗1) 312

TAM SG–1 S5–3 PRE SOL+ PTC1BBB

5 A 11A1A6A7A9B1AE1

A17 PTC Heater

10 AE1 9 AE1 4 AE1 3 AE1 6 AE132+ PR 10 BA1 7 CA1 2 CA1 11 BA1 – 1 A3 2 A/C Pressure Sensor 1

C8 W–B A/C Compressor

465

A25 Junction Connector A1

B5 Ambient Temp. SensorWWW

B B

B B Multiplex Communication System (CAN)<8–4> BYYLG LG Headlamp Dimmer SW (∗1) (∗1) Assembly<9–4> GR GRPPPGenerator<3–2> (∗1) (∗1) (∗1) LG LG LGRR(∗1) (∗1) V BR O (∗1) (∗1) (∗1) W–B W–B W–BRWW(∗1) (∗1) (∗1) W–B (∗1)

V

(∗1) B R (∗1) W–B (∗1)

M YARIS (EM01V0U)

]
15

Similar documents

X AUTOMATIC TRANSAXLE SYSTEM PRECAUTION
U340E AUTOMATIC TRANSAXLE – AUTOMATIC TRANSAXLE SYSTEM AX–1 X AUTOMATIC TRANSAXLE SYSTEM PRECAUTION NOTICE: • Perform the RESET MEMORY (AT initialization) when replacing the automatic transaxle assembly, engine assembly or ECM (See page AX-14). • Perform the REGISTRATION (VIN registration) when repl
ON Semiconductor 2N5550 Amplifier Transistors NPN Silicon 2N5551*
ON Semiconductor 2N5550 Amplifier Transistors NPN Silicon 2N5551* *ON Semiconductor Preferred Device MAXIMUM RATINGS Rating Symbol 2N5550 2N5551 Unit Collector–Emitter Voltage VCEO 140 160 Vdc Collector–Base Voltage VCBO 160 180 Vdc Emitter–Base Voltage VEBO 6.0 Vdc Collector Current — Continuous IC
GENERAL DESCRIPTION QUICK REFERENCE DATA PINNING - TO92 variant PIN CONFIGURATION SYMBOL
GENERAL DESCRIPTION QUICK REFERENCE DATA Glass passivated sensitive gate SYMBOL PARAMETER MAX. UNIT thyristor in a plastic envelope, intended for use in general purpose VDRM, Repetitive peak off-state voltages 200 V switching and phase control VRRM applications. This device is intended IT(AV) Averag
N-Channel JFETs
N-Channel JFETs 2N4117A PN4117A SST4117 2N4118A PN4118A SST4118 2N4119A PN4119A SST4119 Part Number VGS(off) (V) V(BR)GSS Min (V) gfs Min (S) IDSS Min (A) 4117 –0.6 to –1.8 –40 70 30 4118 –1 to –3 –40 80 80 4119 –2 to –6 –40 100 200 Ultra-Low Leakage: 0.2 pA Insignificant Signal Loss/Error Voltage
Order this document SEMICONDUCTOR TECHNICAL DATA by 2N3903/D NPN Silicon
Order this document SEMICONDUCTOR TECHNICAL DATA by 2N3903/D NPN Silicon *Motorola Preferred Device COLLECTOR BASE EMITTER 1 MAXIMUM RATINGS Rating Symbol Value Unit CASE 29–04, STYLE 1 TO–92 (TO–226AA) Collector–Emitter Voltage VCEO 40 Vdc Collector–Base Voltage VCBO 60 Vdc Emitter–Base Voltage VEB
DISCRETE SEMICONDUCTORS DATA SHEET 2N2222; 2N2222A NPN switching transistors Product specification 1997 May 29 Supersedes data of September 1994 File under Discrete Semiconductors, SC04
DISCRETE SEMICONDUCTORS DATA SHEET M3D125 2N2222; 2N2222A NPN switching transistors Product specification 1997 May 29 Supersedes data of September 1994 File under Discrete Semiconductors, SC04 FEATURES PINNING • High current (max. 800 mA) PIN DESCRIPTION • Low voltage (max. 40 V). 1 emitter 2 base A
Small-signal Transistors Selection guide
Philips Semiconductors Small-signal Transistors Selection guide V TYPE CEO IC Ptot fhhTPNP PACKAGE max. max. max. FE FE min. PAGE NUMBER min. max. COMPL. (V) (mA) (mW) (MHz) BC846 SOT23 65 100 250 110 450 100 BC856 305 BC846A SOT23 65 100 250 110 220 100 BC856A 305 BC846AT SC-75 65 100 150 110 220 1
Small-signal Transistors Selection guide
Philips Semiconductors Small-signal Transistors Selection guide SURFACE-MOUNT DEVICES NPN GENERAL PURPOSE LOW-POWER TRANSISTORSVIPfTYPE CEO C tothhTPNP PACKAGE max. max. max. FE FE min. PAGE NUMBER min. max. COMPL. (V) (mA) (mW) (MHz) 2PC4081 SC-70 40 100 200 120 560 100 2PA1576 210 2PC4081Q SC-70 4
Small-signal Transistors Selection guide
Philips Semiconductors Small-signal Transistors Selection guide LEADED DEVICES (continued) NPN HIGH-VOLTAGE POWER TRANSISTORSVIPfTYPE CEO C tothhTPACKAGE max. max. max. FE FE PNP min. PAGE NUMBER min. max. COMPL. (V) (mA) (mW) (MHz) BF419 TO-126 250 300 6000 45 typ. >45 90 – 532 BF457 TO-126 160 100
DISCRETE SEMICONDUCTORS DATA SHEET 1PS302 High-speed double diode Product specification 1996 Apr 03 File under Discrete Semiconductors, SC01
DISCRETE SEMICONDUCTORS DATA SHEET handbook, halfpage M3D114 1PS302 High-speed double diode Product specification 1996 Apr 03 File under Discrete Semiconductors, SC01 FEATURES DESCRIPTION PINNING • Very small plastic SMD package The 1PS302 consists of two PIN DESCRIPTION • High switching speed: max.
Small-signal Transistors Selection guide
Philips Semiconductors Small-signal Transistors Selection guide LEADED DEVICES NPN GENERAL PURPOSE LOW-POWER TRANSISTORSVIPfTYPE CEO C tothhTPACKAGE max. max. max. FE FE PNP min. PAGE NUMBER min. max. COMPL. (V) (mA) (mW) (MHz) 2N2484 TO-18 60 50 360 250 800 60 – 131 2N4124 TO-92 25 200 500 120 360
DISCRETE SEMICONDUCTORS DATA SHEET 1PS301 High-speed double diode Product specification 1996 Apr 03 File under Discrete Semiconductors, SC01
DISCRETE SEMICONDUCTORS DATA SHEET handbook, halfpage M3D114 1PS301 High-speed double diode Product specification 1996 Apr 03 File under Discrete Semiconductors, SC01 FEATURES DESCRIPTION PINNING • Very small plastic SMD package The 1PS301 consists of two PIN DESCRIPTION • High switching speed: max.
DISCRETE SEMICONDUCTORS DATA SHEET 1PS300 High-speed double diode Product specification 1996 Apr 03 File under Discrete Semiconductors, SC01
DISCRETE SEMICONDUCTORS DATA SHEET handbook, halfpage M3D114 1PS300 High-speed double diode Product specification 1996 Apr 03 File under Discrete Semiconductors, SC01 FEATURES DESCRIPTION PINNING • Very small plastic SMD package The 1PS300 consists of two PIN DESCRIPTION • High switching speed: max.
DISCRETE SEMICONDUCTORS DATA SHEET 1PS226 High-speed double diode Product specification 1996 Apr 03 Supersedes data of December 1993 File under Discrete Semiconductors, SC01
DISCRETE SEMICONDUCTORS DATA SHEET handbook, halfpage M3D114 1PS226 High-speed double diode Product specification 1996 Apr 03 Supersedes data of December 1993 File under Discrete Semiconductors, SC01 FEATURES DESCRIPTION PINNING • Small plastic SMD package The 1PS226 consists of two PIN DESCRIPTION
DISCRETE SEMICONDUCTORS DATA SHEET 1PS193 High-speed diode Product specification 1996 Apr 03 Supersedes data of December 1993 File under Discrete Semiconductors, SC01
DISCRETE SEMICONDUCTORS DATA SHEET handbook, halfpage M3D114 1PS193 High-speed diode Product specification 1996 Apr 03 Supersedes data of December 1993 File under Discrete Semiconductors, SC01 FEATURES DESCRIPTION PINNING • Small plastic SMD package The 1PS193 is a high-speed PIN DESCRIPTION • High
DISCRETE SEMICONDUCTORS DATA SHEET 1PS184 High-speed double diode Product specification 1996 Apr 03 Supersedes data of December 1993 File under Discrete Semiconductors, SC01
DISCRETE SEMICONDUCTORS DATA SHEET handbook, halfpage M3D114 1PS184 High-speed double diode Product specification 1996 Apr 03 Supersedes data of December 1993 File under Discrete Semiconductors, SC01 FEATURES DESCRIPTION PINNING • Small plastic SMD package The 1PS184 consists of two PIN DESCRIPTION
DISCRETE SEMICONDUCTORS DATA SHEET 1PS181 High-speed double diode Product specification 1996 Apr 03 Supersedes data of December 1993 File under Discrete Semiconductors, SC01
DISCRETE SEMICONDUCTORS DATA SHEET handbook, halfpage M3D114 1PS181 High-speed double diode Product specification 1996 Apr 03 Supersedes data of December 1993 File under Discrete Semiconductors, SC01 FEATURES DESCRIPTION PINNING • Small plastic SMD package The 1PS181 consists of two PIN DESCRIPTION
DISCRETE SEMICONDUCTORS DATA SHEET 1N914; 1N916 High-speed diodes Product specification 1996 Apr 10 Supersedes data of April 1992 File under Discrete Semiconductors, SC01
DISCRETE SEMICONDUCTORS DATA SHEET M3D176 1N914; 1N916 High-speed diodes Product specification 1996 Apr 10 Supersedes data of April 1992 File under Discrete Semiconductors, SC01 FEATURES DESCRIPTION • Hermetically sealed leaded glass The 1N914; 1N916 are high-speed switching diodes fabricated in pla
DISCRETE SEMICONDUCTORS DATA SHEET
DISCRETE SEMICONDUCTORS DATA SHEET handbook, halfpage M3D119 1N5817; 1N5818; 1N5819 Schottky barrier diodes Product specification 1996 May 03 Supersedes data of April 1992 File under Discrete Semiconductors, SC01 FEATURES DESCRIPTION • Low switching losses The 1N5817 to 1N5819 types are Schottky bar
DISCRETE SEMICONDUCTORS DATA SHEET 1N5225B to 1N5267B Voltage regulator diodes Product specification 1996 Apr 26 Supersedes data of April 1992 File under Discrete Semiconductors, SC01
DISCRETE SEMICONDUCTORS DATA SHEET M3D176 1N5225B to 1N5267B Voltage regulator diodes Product specification 1996 Apr 26 Supersedes data of April 1992 File under Discrete Semiconductors, SC01 FEATURES DESCRIPTION • Total power dissipation: Low-power voltage regulator diodes in hermetically sealed lea
DISCRETE SEMICONDUCTORS DATA SHEET 1N5059 to 1N5062 Controlled avalanche rectifiers Product specification 1996 Jun 20 Supersedes data of April 1992 File under Discrete Semiconductors, SC01
DISCRETE SEMICONDUCTORS DATA SHEET handbook, 2 columns M3D116 1N5059 to 1N5062 Controlled avalanche rectifiers Product specification 1996 Jun 20 Supersedes data of April 1992 File under Discrete Semiconductors, SC01 FEATURES DESCRIPTION This package is hermetically sealed and fatigue free as coeffic
DISCRETE SEMICONDUCTORS DATA SHEET 1N4728A to 1N4749A Voltage regulator diodes Product specification 1996 Apr 26 Supersedes data of April 1992 File under Discrete Semiconductors, SC01
DISCRETE SEMICONDUCTORS DATA SHEET handbook, halfpage M3D130 1N4728A to 1N4749A Voltage regulator diodes Product specification 1996 Apr 26 Supersedes data of April 1992 File under Discrete Semiconductors, SC01 FEATURES DESCRIPTION • Total power dissipation: Low voltage regulator diodes in hermetical
DISCRETE SEMICONDUCTORS DATA SHEET 1N4531; 1N4532 High-speed diodes Product specification 1996 Apr 03 Supersedes data of April 1992 File under Discrete Semiconductors, SC01
DISCRETE SEMICONDUCTORS DATA SHEET handbook, halfpage M3D050 1N4531; 1N4532 High-speed diodes Product specification 1996 Apr 03 Supersedes data of April 1992 File under Discrete Semiconductors, SC01 FEATURES DESCRIPTION • Hermetically sealed leaded glass The 1N4531, 1N4532 are high-speed switching d
DISCRETE SEMICONDUCTORS DATA SHEET
DISCRETE SEMICONDUCTORS DATA SHEET M3D176 1N4150; 1N4151; 1N4153 High-speed diodes Product specification 1996 Apr 19 Supersedes data of April 1992 File under Discrete Semiconductors, SC01 FEATURES DESCRIPTION • Hermetically sealed leaded glass The 1N4150, 1N4151, 1N4153 are high-speed switching diod
DISCRETE SEMICONDUCTORS DATA SHEET
DISCRETE SEMICONDUCTORS DATA SHEET M3D176 1N4148; 1N4446; 1N4448 High-speed diodes Product specification 1996 Apr 15 Supersedes data of April 1992 File under Discrete Semiconductors, SC01 FEATURES DESCRIPTION • Hermetically sealed leaded glass The 1N4148, 1N4446, 1N4448 are high-speed switching diod
DATA SHEET
DISCRETE SEMICONDUCTORS DATA SHEET handbook, 2 columns M3D116 1N4001G to 1N4007G Rectifiers Product specification 1996 May 24 Supersedes data of April 1992 File under Discrete Semiconductors, SC01 FEATURES DESCRIPTION This package is hermetically sealed and fatigue free as coefficients of • Glass pa
DATA SHEET
DISCRETE SEMICONDUCTORS DATA SHEET handbook, halfpage M3D119 1N4001ID to 1N4007ID Rectifiers Product specification 1996 Jun 10 Supersedes data of April 1992 File under Discrete Semiconductors, SC01 FEATURES DESCRIPTION This package is hermetically sealed and fatigue free as coefficients of • Glass p
Small-signal Transistors Selection guide
Philips Semiconductors Small-signal Transistors Selection guide LEADED DEVICES (continued) NPN HIGH-VOLTAGE MEDIUM-POWER TRANSISTORSVIPfTYPE CEO C tothhTPNP PACKAGE max. max. max. FE FE min. PAGE NUMBER min. max. COMPL. (V) (mA) (mW) (MHz) BF420 TO-92 300 50 830 50 >50 60 BF421 534 BF422 TO-92 250 5
Small-signal Transistors Selection guide
Philips Semiconductors Small-signal Transistors Selection guide LEADED DEVICES (continued) NPN HIGH-VOLTAGE LOW-POWER TRANSISTORS V TYPE CEO IC Ptot fhhTPNP PACKAGE max. max. max. FE FE min. PAGE NUMBER min. max. COMPL. (V) (mA) (mW) (MHz) 2N5550 TO-92 140 300 630 60 >60 100 2N5400 184 2N5551 TO-92
Small-signal Transistors Selection guide
Philips Semiconductors Small-signal Transistors Selection guide LEADED DEVICES (continued) NPN POWER DARLINGTON TRANSISTORS V TYPE CES IC Ptot f thhToff PNP PACKAGE max. max. max. FE FE min. max. PAGE NUMBER min. max. COMPL. (V) (mA) (mW) (MHz) (ns) BDX42 TO-126 45 1000 1250 2000 >2000 200 typ. – BD